The contact owns a 2000 Ford Expedition. While the vehicle was undergoing an oil change, the cruise control switch underneath the hood that was connected to the brake master cylinder caught on fire. The contact stated that the ignition was off at the time. The contact was able to extinguish the fire. A fire report was not filed. The contact, a certified mechanic, stated that there was brake fluid coming out of the cruise control switch. The vehicle was not repaired. The dealer was not contacted. The manufacturer was not notified of the failure. The approximate failure mileage was 201,000.

- Finksburg, MD, USA

Throttle feels like its sticking. The breaks feel like they get harder the longer you drive or use them. Its been extremely cold the last few weeks (air temp of -28F lows to -3F for highs). You let off the break from a stop sign or stop light and it will suddenly accerlerate by itself. Seems to happen anytime after 40mph, even if you slow back down to 10-15mph it will accelerate back up on its own, up to as fast as 65mph!) I need to downshift and ride brakes (which are hard as a rock!!!) to keep it from excelling though town and to try to keep the rpms at bay. When coming to a stop and turning its hard to steer and it makes jumpy/jerky movements forward when brakes are applied. When vehicle comes to a stop the rpms skyrocket until you shut down the engine. If you havn't given it enough time before you start it again, the engine and rpms soar up again. Things we've tried with no luck are, disengaging the cruise control, replacing the spring under hood where the throttle cable is. Thought maybe it was stretched and not depressing fully to alow deceleration. After that we replaced the throttle body itself. Again, no luck on test drive. You can hear a click/ping in the pedal and see it come up once truck is in park, give it time. Pedal seems to be partially depressed and there is play. Have tried to stick foot under the pedal to try and get it to disenge. Worked the first few times that's also why thought it was the spring. No longer works to do that. Can seem to hear a difference either in motor or trany, acting as if it's working harder when it seems to take control of itself. Started happening 12-24-17. Been to the shop many times with no answers as to why this is happening. It's very scary and dangerous! after reading about all the others this is happened to its hard to imagine that there hasn't been a recall or at the very least an answer yet!

- Brainerd, MN, USA

Anti-lock brake system activated while driving on interstate with cruise control set at 65 mph, causing uncontrolled stop in moving traffic without warning. Never had any previous problems with ABS system. The ABS warning light was not on (and is still not on). Ford's customer relations center suggested I take my vehicle to a Ford dealership for to determine the cause of this problem. They also said there are no warranties, recalls or programs that would provide coverage for this critical safety issue with the ABS system. Before I do anything else to my vehicle I wanted to notify NHTSA first.

- Clayton, NC, USA

Brake line above fuel line completely rusted through. Luckily I was stopped for fuel and lost brake pressure. Upon inspection at my local garage, all brake lines were rusted to the point all were replaced. Upon closer inspection, the rear suspension parts are rusting underneath the coating that covered the suspension parts. I realize the vehicle is 14 years old, but I have much older vehicles that have zero rust. Just for the record, we have years that we have no snow, so my exposure to salt roads is very limited. Items such as brake lines and suspension parts should be made of a better quality material. After all, this vehicle still has the original exhaust system! regardless of age, with just over 77K miles this is a serious safety issue.

- Roanoke, VA, USA