1997 Ford Expedition
380 Technical Service Bulletins (TSBs)
TSB List for the 1997 Ford Expedition
Technical Service Bulletins (TSBs) for the 1997 Expedition are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
STEERING
-
TSB #0399
TIE ROD END INSPECTION PROCEDURE. *TT Read More »
-
TSB #9912778
INFORMATION REGARDING NEW SERVICE STEERING GEAR. *TT Read More »
STEERING: STEERING WHEEL/HANDLE BAR
-
TSB #98169
STEERING -ALIGNMENT-TOE SET PROCEDURE SERVICE TIP. YD Read More »
-
TSB #97614
STEERING COLUMN- HIGH SPEED VIBRATION- 4X2 VEHICLES EQUIPPED WITH 5.4L ENGINE. *JD Read More »
-
TSB #BC9682961001
CONCERNS FOR THE LABOR TIME STANDARD IN TBS 96-19-02 (STEERING - GRUNT NOISE DURING STEERING WHEEL RETURN FROM FULL RIGHT TURN) IS INCORRECT. *TT Read More »
STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE
-
TSB #98241
DIAGNOSTIC SERVICE TIPS ON PASSIVE ANTI THEFT SYSTEM ( PATS ). *YC Read More »
STEERING:LINKAGES
-
TSB #9810569
CONCERNS OF SQUEAKY / NOISY PITMAN ARM. *YC Read More »
STEERING:LINKAGES:TIE ROD ASSEMBLY
-
TSB #04L19
CUSTOMER MAINTENANCE REMINDER - LITERATURE PROGRAM 04L19 - TIE ROD INSPECTION PROCEDURE. *TT Read More »
-
TSB #031513
TIE ROD END INSPECTION PROCEDURE. *TT Read More »
-
TSB #03610
TIE ROD END INSPECTION PROCEDURE. CANADA VEHICLES ONLY. *TT *JB Read More »
SUSPENSION
-
TSB #030709
REPEAT AIR SUSPENSION COMPRESSOR DRIER FAILURES. *TT Read More »
-
TSB #15692
SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT Read More »
-
TSB #99157
SOME VEHICLES MAY EXHIBIT VIBRATION, SHIMMY AND BODY BOOM AT SPEEDS ABOVE 72 KM/H (45 MPH). *TT Read More »
-
TSB #980310
EXPERIENCING VIBRATION AT CRUISE OVER 50 MPH. *YC Read More »
-
TSB #BC0318972301
FRONT DRIVE AXLE FLUID LEAK. *JD Read More »
-
TSB #BC0318970201
FRONT DRIVE AXLE FLUID LEAK. *JD Read More »
SUSPENSION:FRONT
-
TSB #982741
SOME VEHICLES MAY EXHIBIT A LOW SPEED ( UNDER 35MPH ) CLICKING NOISE. THIS MAY BE CAUSED BY A CAGE NUT ROCKING ON THE COTTOR PIN FOR FRONT AXLE HALF SHAFT SPINDLE. *AK Read More »
-
TSB #BC0318A97020
FRONT DRIVE AXLE FLUID LEAK. *TW Read More »
-
TSB #BC1006597230
IF 4X4 FRONT AXLE IS LEAKING THROUGH THE VENT TUBE, ORDER THE NEW FRONT AXLE TUBE ASSEMBLY FROM THE NATIONAL PARTS DEPOT. *JD Read More »
-
TSB #BC0675961025
VEHICLES MAY EXPERIENCE FLUID LEAKS OUT OF THE FRONT AXLE VENT TUBE. *TT Read More »
SUSPENSION:FRONT:STABILIZER BAR
-
TSB #981515
A CLUNKING NOISE HEARD FROM FRONT ENDCAUSED BY FRONT STABILIZER BAR CONTACTING THE FRAME. *AK Read More »
SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM
-
TSB #0392
REPEAT AIR SUSPENSION COMPRESSOR DRIER FAILURES. *TT Read More »
-
TSB #16015
SOME VEHICLES WITH AIR SUSPENSION MAY EXHIBIT AN INITIAL OR REPEAT COMPRESSOR DRYER FAILURE. *TT Read More »
-
TSB #15651
SOME VEHICLES EQUIPPED WITH AIR SUSPENSION MAY EXHIBIT AN AIR LEAK AND/OR OVERNIGHT BLEED DOWN OF THE AIR SUSPENSION. *TT Read More »
-
TSB #15528
SUBJECT REGARDING AIR SUSPENSION COMPRESSOR QUALITY. *YD Read More »
-
TSB #15362
SOME VEHICLES MAY EXHIBIT AIR SUSPENSION MALFUNCTION. *TT Read More »
-
TSB #14359
SUBJECT PERTAINING TO AIR SUSPENSION LEAKS. *JB Read More »
-
TSB #98254
SOME VEHICLES EQUIPPED WITH AIR SUSPENSION MAY EXHIBIT AN INTERMITTENT CHECK SUSPENSION LAMP ON AND DIAGNOSTIC TROUBLE CODE (DTC) C1770 AND/OR C1845 ILLUMINATED. *YC Read More »
-
TSB #97713
NOISE- "BUZZING"- UNDERHOOD WHEN AIR SUSPENSION IS IN OPERATION. *JD Read More »
-
TSB #BC3513972301
AIR SUSPENSION VEHICLES ARE SHIPPED WITH THE AIR SUSPENSION SWITCH IN THE OFF POSITION. *JD Read More »
-
TSB #BC1017997230
ALL AIR SUSPNESION EXPEDTIONS ARE SHIPPED WITH THE AIR SUSPENSION SWITCH IN THE OFF POSITION. *JD Read More »
SUSPENSION:REAR
-
TSB #050618
REAR AXLE NOISE REPAIR. *SC Read More »
SUSPENSION:REAR:SPRINGS:COIL SPRINGS
-
TSB #BC2225970501
RATTLE OR CLUNK NOISE IN REAR OF VEHICLE CAUSED BY THE BUSHING FALLING OUT OF THE SWAY BAR LINK. *TW Read More »
-
TSB #BC105969705
VEHICLES BUILT BEFORE 4/11/97 MAY EXPERIENCE A RATTLE OR CLUNK. *TW Read More »
SUSPENSION:REAR:SPRINGS:AIR SUSPENSION SYSTEM
-
TSB #0454
AIR SUSPENSION COMPRESSOR NOISE. *TT Read More »
-
TSB #BC0743961018
PROCEDURE WHEN AIR SUSPENSION LIGHT IS ON. *TT Read More »
SERVICE BRAKES, HYDRAULIC
-
TSB #99411
VEHICLES EXPERIENCING INCREASED BRAKE PEDAL EFFORT AND / OR FALSE ABS CYCLING AT LOW SPEEDS, OR ABS LAMP ILLUMINATION. *TT Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
-
TSB #99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT Read More »
-
TSB #985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
-
TSB #985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC Read More »
-
TSB #9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
-
TSB #991313
SUBJECT REGARDING ANTI-LOCK BRAKE LAMP ILLUMINATION, INCREASED BREAK PEDAL EFFORT AND / OR FALSE ANTI-LOCK BRAKE SYSTEM (ABS) CYCLING AT LOW SPEEDS. *TT Read More »
-
TSB #99411
VEHICLES EXPERIENCING INCREASED BRAKE PEDAL EFFORT AND / OR FALSE ABS CYCLING AT LOW SPEEDS, OR ABS LAMP ILLUMINATION. *TT Read More »
-
TSB #12216
THIS BULLETIN MENTIONS THAT FOR ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. Read More »
-
TSB #BC0676961025
INFORMATION WHEN ELECTRONIC/HYDRAULIC CONTROL UNIT (EHCU) MALFUNCTIONS. *TT Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT
-
TSB #14905
SOME VEHICLES MAY EXHIBIT AMBER ANTI-LOCK BRAKE SYSTEM (ABS) LAMP ON WITH UNDEFINED DIAGNOSTIC TROUBLE CODES (DTCS) STORED. *TT Read More »
SERVICE BRAKES, AIR:DISC:ROTOR
-
TSB #9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC Read More »
PARKING BRAKE
-
TSB #982117
A NEW PARKING BRAKE CONTROL RUBBER BUMPER STOP IS NOW AVAILABLE FOR SERVICE. *YC Read More »
-
TSB #4698
ON SOME VEHICLES, THE RUBBER STOP BUMPER MAY BE MISSING FROM THE PARKING BRAKE CONTROL, A REPLACEMENT SERVICE PART IS NOW AVAILABLE. *TT Read More »
-
TSB #11806
SUBJECT REGARDING A MISSING RUBBER STOP BUMPER FROM THE PARKING BRAKE COTNROL. *TT Read More »
-
TSB #BC3522972301
PARKING BRAKE PEDAL TRAVEL AND EFFORT ON EXPEDITIONS. *JD Read More »
-
TSB #BC1017397230
PARKING BRAKE PEDAL TRAVEL AND EFFORT ON EXPEDITIONS BROUGHT INTO THE DEALERSHIP WITH CUSTOMER COMPLAINTS CONCERNING PARKING BRAKE. *JD Read More »
PARKING BRAKE:CONVENTIONAL
-
TSB #BC0474961114
LONG TRAVEL OF PARKING BRAKE PEDAL. *TW Read More »
-
TSB #BC0009961101
SOFT PARKING BRAKE PEDAL OR LONG PARKING BRAKE PEDAL FEEL. *TW Read More »
-
TSB #BC9672961001
PROCEDURE FOR BRAKE WARNING INDICATOR STAYS ON RED IN CLUSTER. *TT Read More »
ENGINE AND ENGINE COOLING
-
TSB #041601
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT Read More »
ENGINE AND ENGINE COOLING:ENGINE
-
TSB #07212
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. Read More »
-
TSB #031404
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. Read More »
-
TSB #03144
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. Read More »
-
TSB #16683
FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV). *TT *JB Read More »
-
TSB #8058
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT Read More »
-
TSB #98B33
OWNER NOTIFICATION FOR REPLACEMENT OF ENGINE CYLINDER HEADS. *TT Read More »
-
TSB #982325
THE MALFUCNTION INDICATOR LAMP ( MIL ) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0455 MAY BE STORED IN MEMORY. *YC Read More »
-
TSB #9874
A NEW SILICONE GASKET AND SEALANT. *YC Read More »
-
TSB #970902971811
CONCERNS WITH "SQUEAKING" AND/OR "RATTLING" NOISES MAY OCCUR DURING DIFFERENT DRIVING CHARACTERISTICS AND FROM VARYING POINTS ON THE VEHICLE. *YC Read More »
-
TSB #976007
BRIEF INFORMATION REGARDING CYLINDER HEAD TEMPERATURE (CHT) AND FAIL SAFE COOLING. *TT Read More »
-
TSB #BC3090970225
VEHICLES WITH A ROUGH RUNNING/MISS SYMPTOM WITH A MISFIRE DTC ON A PARTICULAR CYLINDER WHERE NORMAL DIAGNOSIS DOES NOT PINPOINT A CAUSE - CHECK FOR DAMAGE TO CAMSHAFT. *TW Read More »
-
TSB #BC1034397020
ILLUMINATION OF THE CHECK ENGINE LIGHT. *JD Read More »
-
TSB #BC0325972301
SOME 5.4L FRONT END SERPETNTINE BELTS MAY MAKE SOME NOISE BETWEEN TEMPERATURES FO 30 F-50 F. *JD Read More »
-
TSB #BC1017697230
CHECK ENGINE LIGHT ON WITH DTC P0455 IN CONTINUOUS MEMORY ON VEHICLE APPLICATIONS. *JD Read More »
-
TSB #BC0056970201
SOME EXPEDITIONS MAY EXPERIENCE SOME BELT CHIRP AT COLD START UP IN AMBIENT TEMPERATURES OF 30-50 DEGREES F. *JD Read More »
-
TSB #BC0315970201
FEAD BELT SQUEAL, COLD ONLY. REVISED BELT RELEASED. *JD Read More »
-
TSB #BC1014797020
BELT CHIRP AT COLD START UP IN AMBIENT TEMPERATURES OF 30-50 DEGREES F. *JD Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
-
TSB #15901
THIS BULLETIN STATES THAT SOME 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER OR LARGER KNOCK SENSOR THREADED HOLD THAN THE ONE IN THE ORIGINAL ENGINE ASSEMBLY. *TT Read More »
-
TSB #0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »
-
TSB #15517
SUBJECT REGARDING EXAGGERATED ENGINE BRAKING ON DECELERATION. *YD Read More »
-
TSB #01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT Read More »
-
TSB #01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT Read More »
-
TSB #14372
INFORMATION ON IDLE VIBRATION OR ENGINE DROAN ON ACCELERATION. *JB Read More »
-
TSB #0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT Read More »
-
TSB #14609
SUBJECT REGARDING HIGH IDLE AND/OR CHECK ENGINE LIGHT CONDITION. *JB Read More »
-
TSB #8058
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. **MR Read More »
-
TSB #13832
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT Read More »
-
TSB #13322
SOME VEHICLES MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT Read More »
-
TSB #7155
VEHICLES EQUIPPED WITH WINDSOR ENGINES ONLY MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT Read More »
-
TSB #13331
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT Read More »
-
TSB #13285
EXPERIENCING ENGINE KNOCK AT INITIAL COLD STARTUP. *TT Read More »
-
TSB #6350
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT Read More »
-
TSB #99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT Read More »
-
TSB #996034
EXPERIENCING A ENGINE KNOCK AT COLD START-UP. *TT Read More »
-
TSB #12767
EXHIBITING A VIBRATION THAT MAY BE INTERPRETED AS AN NVH CONDITION. *TT Read More »
-
TSB #12798
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT Read More »
-
TSB #4981
SOME VEHICLES EQUIPPED WITH 5.4L ENGINES MAY EXHIBIT A COLD START ENGINE KNOCK CONCERN UNTIL WARMED UP. *TT Read More »
-
TSB #5257
INFORMATION ON VEHICLES EXHIBITING COLD ENGINE KNOCK. *TT Read More »
-
TSB #982110
DURING HIGH IDLE SPEEDS THROTTLE STICKS AFTER STEADY STATE DRIVING IN COLD AMBIENT TEMPERATURES. *YC Read More »
-
TSB #12139
SOME VEHICLES EQUIPPED WITH 4.6L OR 6.8L ENGINES MAY EXHIBIT A COLD START ENGINE NOISE UNTIL WARMED UP. *MJS Read More »
-
TSB #985059
EXPERIENCING COLD ENGINE KNOCK (REPEAT / REVISED MESSAGE). *TT Read More »
-
TSB #985062
SUBJECT REGARDING IDLE VIBRATION (REPEAT MESSAGE). *TT Read More »
-
TSB #12170
INFORMATION CONCERNING THE OCTANE SHORTING BAR LOCATED ON THE PASSENGER SIDE OF ENGINE COMPARTMENT NEAR THE BULKHEAD IS NOT INTENDED TO BE FUNCTIONAL IN REDUCING DETONATION/SPARK KNOCK. *MJS Read More »
-
TSB #12174
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS Read More »
-
TSB #985185
COLD START ENGINE NOISE Read More »
-
TSB #98-4738
COLD ENGINE KNOCK 5.4L ACTION. *AK Read More »
-
TSB #4638
MALFUNCTION INDICATOR LAMP ON, WITH P0300 - P0308 MISFIRE DIAGNOSTIC TROUBLE CODES WITH A 4.6L ENGINE. *TT Read More »
-
TSB #4664
THIS BULLETIN STATES THAT FOR CERTAIN VEHICLES IT IS NOT POSSIBLE TO SET THE CHECK ENGINE LIGHT AND SET DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK) IF A CUSTOMER REFUELS THE VEHICLE WITH THE ENGINE RUNNING. Read More »
-
TSB #980317
SYMPTOMS REGARDING P0300-P0308 MISFIRE DTCS WITH 4.6L ENGINES. *YC Read More »
-
TSB #11530
WHEN DIAGNOSING CRANK / NO START ON CERTAIN VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT (PATS) CHECK THE CUSTOMERS KEY RING FOR ANY MAGNETIC OBJECTS LIKE THE MOBILE SPEEDPASS KEY WHICH MAY AFFECT THE SIGNAL TRANSMISSION BETWEEN THE PATS KEY ... Read More »
-
TSB #983570
SOME ENGINES MAY EXHIBIT OIL LEAKAGE. *TT Read More »
-
TSB #BC0782961014
CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
-
TSB #14365
THIS BULLETIN ADDRESSES CONCERNS A NOISE AT INTIAL ENGINE STARTUP WHEN COLD FROM THE ACCESSORY DRIVE BELT. *JB Read More »
-
TSB #BC0056972301
SOME VEHICLES WITH AIR CONDITIONING CAN EXHIBIT A COLD START ACCESSORY DRIVE BELT NOISE (CHIRP) CONCERN. *JD Read More »
-
TSB #BC1014697020
BELT CHIRP AT COLD START UP IN AMBIENT TEMPERATURES OF 30-50 DEGREES F. *JD Read More »
-
TSB #BC0325961129
SOME FRONT END SERPENTINE BELTS MAY MAKE NOISE WHEN BETWEEN 30 AND 50 DEGREES FAHRENHEIT. *TW Read More »
-
TSB #BC0315961101
FEAD BELT SQUEAL, COLD ONLY. *TW Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM
-
TSB #6232
SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE COIL RESULTING IN ENGINE MISFIRE WITH DIAGNOSTIC TROUBLE CODE P0304 AND / OR ROUGH IDLE. Read More »
-
TSB #12720
SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE FLEXIBLE RUBBER COOLANT HOSE. *TT Read More »
-
TSB #BC0197970201
ENGINE OVERHEATING- WATER PUMP CONCERN DUE TO FREE SPINNING WATER PUMP IMPELLER. *JD Read More »
-
TSB #BC1011097020
OVERHEATING ON 4.6/5.4L VEHICLES MAY BE CAUSED BY POSSIBLE WATER PUMP CONCERN DUE TO FREE SPINNING WATER PUMP IMPELLER. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
-
TSB #982521
CONCERNS OF BREAKAGE OF THE EXHAUST SYSTEM BETWEEN THE MUFFLER AND TAILPIPE MAY OCCUR ON SOME VEHICLES. *YC Read More »
-
TSB #982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC Read More »
-
TSB #BC3062970228
ILLUMINATION OF CHECK ENGINE LIGHT WITH DTC P0446 MAY BE DUE TO CONTAMINATED CANNISTER, EVAP LINES OR VENT SOLENOID. *TW Read More »
-
TSB #BC9668961001
CONCERN FOR VEHICLES EXHIBITING LEAN CODES P0171 & P0174 (VACUUM LEAK). *TT Read More »
-
TSB #BC9671961001
PUSH CONNECTION BETWEEN THE FLEXIBLE FUEL VAPOR LINE AT THE CARBON CANISTER & THE METAL FUEL VAPOR LINE MAY NOT SEAT FULLY ON THE FUEL VAPOR LINE. *TT Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
-
TSB #982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK Read More »
-
TSB #981512
A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK Read More »
-
TSB #BC3270970207
CHECK ENGINE LIGHT - DTC P0446 - CHECK FOR MOLD FLASHING IN THE 90 DEGREE ELBOW EVAP LINE CONMING OUT OF THE CANNISTER. *TW Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
-
TSB #BC3510972301
CHECK ENGINE LIGHT ON WITH DTC P0455 IN CONTINUOUS MEMORY ON 1997 5.4L VEHICLE APPLICATIONS. *JD Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
-
TSB #0554
USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE. *TT Read More »
-
TSB #17320
BROKEN EXHAUST MANIFOLD STUDS. *TT Read More »
FUEL SYSTEM, GASOLINE
-
TSB #15648
SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION AND/OR PREMATURE SHUTOFF OF THE GAS PUMP WHEN THE VEHICLE IS BEING REFUELED. *TT Read More »
-
TSB #976011
EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT Read More »
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
-
TSB #14197
SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION. *TT Read More »
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
-
TSB #15480
SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION AND/OR PREMATURE SHUTOFF OF THE GAS PUMP WHEN THE VEHICLE IS BEING RE-FUELED. *TT Read More »
-
TSB #00201
SOME VEHICLES MAY EXHIBIT HESITATION ON ACCELERATION OR WHILE TURNING. *JB Read More »
-
TSB #BC1035297020
FUEL PUMP SENDER, IN AREAS WITH STEEP SLOPES, THE LOW FUEL WARNING LIGHT MAY PREMATURELY ACTIVATE. *JD Read More »
-
TSB #BC0683961024
HIGH OR IRREGULAR GAUGE MOVEMENT OR IRREGULAR LOW FUEL LIGHT BELOW 1/4 FULL. *TT Read More »
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
-
TSB #02193
DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES-VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE. *MJ Read More »
-
TSB #981612
FUEL MAY LEAK FROM THE SPRING LOCK COUPLINGS. YD Read More »
-
TSB #BC5211961001
INFORMATION FOR HIGH OR IRREGULAR FUEL GAUGE MOVEMENT OR IRREGULAR LOW FUEL FUEL LIGHT BELOW 1/4 FULL. *TT Read More »
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS
-
TSB #BC0884961004
FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES. *TT Read More »
FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM
-
TSB #96225
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW Read More »
-
TSB #BC9676961001
IMPROPER RTV APPLICATION AT THE FRONT/REAR LOWER INTAKE MANIFOLD END SEALS & SIDE GASKETS MAY CAUSE AN OIL/COOLANT LEAK. *TT Read More »
FUEL SYSTEM, OTHER
-
TSB #0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT Read More »
-
TSB #983582
SUBJECT REGARDING VEHICLES EXHIBITING ERRATIC AND / OR INACCURATE FUEL GAUGE READINGS. *TT Read More »
-
TSB #983582
ERRATIC AND / OR INACCURATE FUEL GAUGE READINGS. *TT Read More »
FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY
-
TSB #99E03
EMISSION RECALL FOR VEHICLES THAT WERE BUILT WITH A FUEL FILLER-VALVE WHICH COULD LEAK WHILE THE VEHICLE IS BEING OPERATED WHICH CAN EXCEED EVAPORATIVE EMISSIONS STANDARDS. *TT Read More »
FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM
-
TSB #BC1035197020
THE FUEL GAGE MAY SWING ERRATICALLY ON STEEP SLOPES. *JD Read More »
POWER TRAIN
-
TSB #13745
SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS Read More »
-
TSB #9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT Read More »
-
TSB #4631
BRIEF INFORMATION ON VEHICLES EXHIBIT VIBRATION AT CRUISE OVER 50 MPH. *TT Read More »
-
TSB #983170
CONCERNS WITH CODES P0500, P0503, P1501 OR P1503 WHICH MAY BE CAUSED MY A LOOSE SPEEDOMETER DRIVE GEAR. *TT Read More »
-
TSB #BC5177961001
INFORMATION FOR CONCERNS OS SPEEDOMETER, SPEED CONTROL INOP & VSS (VEHICLE SPEED SENSOR) DTC'S. *TT Read More »
POWER TRAIN:MANUAL TRANSMISSION
-
TSB #971110972313
A NEW DESIGN TRANSMISSION CASE AND EXTENSION HOUSING HAS BEEN RELEASED. *YC Read More »
-
TSB #97090297187
SOME VEHICLES MAY STALL WHEN THE TRANSMISSION IS PLACED INTO GEAR. *YC Read More »
-
TSB #BC0694961023
INFORMATION FOR RECREATIONAL TOWING (ALL WHEELS ON THE GROUND). *TT Read More »
-
TSB #BC0753961017
4X4 VEHICLES MAY EXHIBIT A GRINDING NOISE WHILE SHIFTING INTO 4L. *TT Read More »
-
TSB #BC0844961008
E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT Read More »
-
TSB #BC9694961001
INFORMATION ON VEHICLES THAT MAY EXHIBIT A SLIGHT DELAY IN THE FIRST DRIVE AWAY AFTER THE VEHICLE HAS BEEN PARKED OVERNIGHT, OR FOR A LONGER PERIOD OF TIME. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION
-
TSB #15749
SOME VEHICLES EQUIPPED WITH 4 WHEEL DRIVE MAY EXHIBIT A NOTCHY OR STICKING FEELING IN SLOW SPEED TURNS WITH NO EFFECT ON STEERING EFFORTS OR ASSIST WHILE IN THE AUTOMATIC 4X4 POSITION. *TT Read More »
-
TSB #98168
TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD Read More »
-
TSB #0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS Read More »
-
TSB #7353
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT Read More »
-
TSB #7100
INFORMATION REGARDING TRANSMISSION TROUBLE CODES. *MJS Read More »
-
TSB #99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT Read More »
-
TSB #9996
EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. Read More »
-
TSB #9946
CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR. *TT Read More »
-
TSB #9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC Read More »
-
TSB #982544
SOME MOTOR HOME VEHICLES EQUIPPED WITH E4OD TRANSMISSIONS MAY EXPERIENCE HYDRAULIC SYSTEM MALFUNCTIONS AFTER REPLACING THE TRANSMISSION CASE. *YC Read More »
-
TSB #98123
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT Read More »
-
TSB #BC2226970501
SERVICING TIP - TRANSMISSION - THERE ARE TWO DIFFERENT SIZE DIRECT CLUTCH STEEL PLATES WHEN SERVICING 4R44E OR 5R55E TRANSMISSIONS. *TW Read More »
-
TSB #BC2307970501
LOSS OF SOME ACCESSORIES SUCH AS DRIVER'S POWER WINDOW FUNCTION WHEN THE TRANSMISSION IS SHIFTED OUT OF PARK OR NEUTRAL. *TW Read More »
-
TSB #97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD Read More »
-
TSB #BC0053970201
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD Read More »
-
TSB #BC1015397020
VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD Read More »
-
TSB #962410
TRANSMISSION - E40D - 4R70W - 4R44E - 5R55E - NEW DIGITAL TRANSMISSION RANGE SENSOR - DIAGNOSIS SERVICE TIP. *TW Read More »
-
TSB #962418
TRANSMISSION - E40D - REVISED DESIGN FORWARD PLANET THRUST WASHER - SERVICE TIP. *TW Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
-
TSB #042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT Read More »
-
TSB #97090297183
EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL). *YC Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
-
TSB #01166
SOME VEHICLES MAY EXHIBIT WATER IN THE TRANSFER CASE, THIS COULD CAUSE LOW RANGE 4X4 LAMP TO ILLUMINATE, SHORT OF TRANSFER CASE SWITCH, OR WINDSHIELD WIPERS TO BE ERRATIC OR INOPERATIVE. *SLC Read More »
-
TSB #13505
ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. Read More »
-
TSB #5128
SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. ENGINEERING IS INVESTIGATING. *TT Read More »
-
TSB #985128
SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. *TT Read More »
-
TSB #BC5168961001
PROCEDURE FOR RESOLVING THE CONCERN OF WATER ENTRY INTO THE TRANSFER CASE. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
-
TSB #03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT Read More »
-
TSB #002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT Read More »
-
TSB #981613
TRANSMISSION FLUID LEAKS AT RADIATOR. YD Read More »
-
TSB #9946
CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR. *TT Read More »
-
TSB #97410
TRANSMISSION- E4OD- COOLER BYPASS VALVE SERVICE DURING TRANSMISSION OVERHAUL- SERVICE TIP. *JD Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
-
TSB #962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW Read More »
-
TSB #96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH
-
TSB #01181
BRAKE SHIFT INTERLOCK.*JB Read More »
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
-
TSB #BC0053972301
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD Read More »
-
TSB #BC0121970201
DRIVELINE RATTLE OVER BUMPS. *JD Read More »
-
TSB #BC1012997020
DRIVELINE RATTLE OVER BUMPS. *JD Read More »
POWER TRAIN:DRIVELINE
-
TSB #15123
SOME VEHICLES MAY EXHIBIT A DRIVELINE VIBRATION AT SPEEDS BETWEEN 60-70 MPH. *SLC Read More »
-
TSB #996113
EXPERIENCING FRONT DIFFERENTIAL NOISE. *TT Read More »
-
TSB #996139
CONCERNS WITH FRONT DIFFERENTIAL NOISE. *TT Read More »
POWER TRAIN:DRIVELINE:UNIVERSAL JOINT
-
TSB #12572
VEHICLES MAY EXHIBIT A HIGH SPEED DRIVELINE VIBRATION. *TT Read More »
POWER TRAIN:DRIVELINE:DRIVESHAFT
-
TSB #98-4725
VIBRATION AT CRUISE OVER 50 MPH. *AK Read More »
POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT
-
TSB #15897
SUBJECT REGARDING DRIVELINE ANGLE-RELATED VIBRATION AT VARIOUS SPEEDS AND LOAD CONDITIONS. *TT Read More »
-
TSB #99143
SOME 4X4 VEHICLES BUILT WITH CENTER DISCONNECT FRONT AXLES MAY EXHIBIT A MOANING NOISE FROM THE FRONT DIFFERENTIAL WHILE OPERATING IN 4X2 MODE. *TT Read More »
-
TSB #996113
EXPERIENCING FRONT DIFFERENTIAL NOISE. *TT Read More »
-
TSB #996139
CONCERNS WITH FRONT DIFFERENTIAL NOISE. *TT Read More »
POWER TRAIN:AXLE ASSEMBLY
-
TSB #05618
REAR AXLE NOISE REPAIR. *TT Read More »
-
TSB #12905
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT Read More »
-
TSB #12797
ADDRESSING CONCERNS OF A LOW SPEED (UNDER 35 MPH) CLICKING NOISE CAUSED BY A CAGE NUT ROCKING ON THE COTTER PIN FOR THE FRONT AXLE HALF SHAFT SPINDLE. *TT Read More »
-
TSB #4628
SOME VEHICLES MAY EXHIBIT REAR AXLE NOISE. *TT Read More »
-
TSB #983074
CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT Read More »
-
TSB #BC0254970201
4X4 FRONT AXLE IS LEAKING THROUGH THE VENT TUBE. *JD Read More »
-
TSB #BC0065961101
4X4 FRONT AXLE LEAKING THROUGH VENT TUBE. *TW Read More »
-
TSB #BC9674961001
LIGHT TO MODERATE AXLE NOISE (AXLE WHINE) AT 50 TO 65 MPH (80 TO 105 KPH) DURING ACCELS, DECELS OR CRUISE MAY BE DUE TO AXLE NOISE BEING TRANSMITTED FROM THE AXLE INTO THE VEHICLE. *TT Read More »
ELECTRICAL SYSTEM
-
TSB #03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT Read More »
-
TSB #98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC Read More »
-
TSB #12227
FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT Read More »
ELECTRICAL SYSTEM:STARTER ASSEMBLY
-
TSB #97111097234
VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC Read More »
-
TSB #BC0745961018
CONCERN OF STARTER STAYING ENGAGED, LOOK AT CHAFED WIRE AT THE REAR BRACKET FOR THE RIGHT FRONT UPPER CONTROL ARM. *TT Read More »
ELECTRICAL SYSTEM:WIRING
-
TSB #99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT Read More »
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
-
TSB #BC5196961001
CONCERN OF STARTER STAYING ENGAGED. RED WIRE THAT RUNS FROM THE STARTER RELAY TO THE STARTER MAY CHAFE & CAUSE STARTER TO STAY ENGAGED AFTER CRANK. *TT Read More »
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
-
TSB #98-4817
SOME 1997-1998 EXPLORER/MOUNTAINEER/EXPEDITION OR NAVIGATOR VEHICLES WITH 4-WD 4X4 SYSTEM MAY EXHIBIT BOTH Read More »
ELECTRICAL SYSTEM:IGNITION
-
TSB #99164
CONCERNS WITH A HARD TO TURN IGNITION KEY AND / OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER. *TT Read More »
-
TSB #962523
RUNS ROUGH - MALFUNCTION INDICATOR LAMP (MIL) ON - DIAGNOSTIC TROUBLE CODES (DTCS) P0300 THROUGH P0308 STORED IN MEMORY - VEHICLES BUILT THROUGH 10/14/96 WITH 4.6L ENGINE. *TW Read More »
-
TSB #BC0477961114
ENGINEERING IS INVESTIGATING DEALERSHIP CONCERNS WITH FOULED OR CRACKED SPARK PLUGS. *TW Read More »
-
TSB #BC0696961023
CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT Read More »
ELECTRICAL SYSTEM:IGNITION:MODULE
-
TSB #9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT Read More »
-
TSB #97620
MALFUNCTION INDICATOR LAMP (MIL) - ILLUMINATED- DIAGNOSTIC TROUBLE CODE (DTC) P0446 STORED IN CONTINUOUS MEMORY- VEHICLES BUILT THROUGH 1/17/97. *JD Read More »
-
TSB #BC3282970206
GEM CONCERN - CHECK FOR MORE THAN ONE GEM CONTROLLED COMPONENT THAT IS INOPERATIVE OR FOR A STRING OF FALSE GEM DTC'S RECEIVED IN MEMORY. *TW Read More »
-
TSB #BC3363972301
THE NGS DISPLAYS INCORRECT DATE FOR THE ING GEM PID ON THE VEHICLES. *JD Read More »
-
TSB #BC1022797230
THE NGS DISPLAYS INCORRECT DATA FOR THE IGN GEM PID ON THE VEHICLES. *JD Read More »
-
TSB #962511
POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW Read More »
-
TSB #BC0340961127
CERTAIN 1997 VEHCILES MAY HAVE BEEN BUILT WITH THE 240 SECOND MISFIRE DELAY. *TW Read More »
-
TSB #BC0054961101
VEHICLES MAY HAVE BEEN BUILT WITH A 240 SECOND MISFIRE DELAY. *TW Read More »
ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE
-
TSB #0162
VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK. *TT Read More »
-
TSB #12154
SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS Read More »
-
TSB #98110
SUBJECT REGARDING PASSIVE ANTI THEFT SYSTEM (PATS) DIAGNOSTIC SERVICE TIPS. *TT Read More »
-
TSB #983566
INFORMATION REGARDING PROGRAMMING / DIAGNOSING PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT Read More »
-
TSB #983566
INFORMATION ON PROGRAMMING / DIAGNOSING ANY PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT Read More »
-
TSB #BC3272970207
VEHICLES ARE EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) - VEHICLE WILL NOT START WITHOUT THE CORRECT IGNITION KEY. *TW Read More »
-
TSB #BC1025097230
PASSIVE ANTI-THEFT SYSTEM. *JD Read More »
EXTERIOR LIGHTING
-
TSB #15526
SUBJECT REGARDING INOPERATIVE RUNNING BOARD LIGHTS.*YD Read More »
EXTERIOR LIGHTING:BRAKE LIGHTS
-
TSB #99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT Read More »
EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
-
TSB #02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ Read More »
-
TSB #BC9673961001
PROCEDURE FOR BRAKE EXTERIOR LIGHTS STAY ON (TAIL & HIGH MOUNT STOP LIGHT). *TT Read More »
EXTERIOR LIGHTING:TURN SIGNAL:SWITCH
-
TSB #99B02
INFORMATION ON REPLACING MULTIFUNCTION SWITCH. *TT Read More »
VISIBILITY
-
TSB #0457
POP/THUMP NOISE AT END OF WINDOW MOVEMENT AND/OR DRIVER'S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION. *TT Read More »
VISIBILITY:WINDSHIELD
-
TSB #13838
CONCERNS WITH VEHICLES EXHIBITING A WINDSHIELD CREAK / SQUEAK. *TT Read More »
-
TSB #13054
EXPERIENCING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT Read More »
-
TSB #97050110618
STRESS CRACKS ON WINDSHIELDS. *TW Read More »
VISIBILITY:GLASS, SIDE/REAR
-
TSB #96228
WINDNOISE - FRONT WINDOW RUN LIP HANGING OUT - VEHICLES BUILT THROUGH 8/14/96. *TW Read More »
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
-
TSB #15549
INFORMATION REGARDING POP/THUMP NOISE FROM POWER WINDOW. *YH Read More »
-
TSB #996780
THIS ONLINE SERVICE BULLETIN INVOLVES VEHICLES EXHIBITING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT Read More »
-
TSB #976007
BRIEF INFORMATION REGARDING CYLINDER HEAD TEMPERATURE (CHT) AND FAIL SAFE COOLING. *TT Read More »
-
TSB #BC9680961001
CONCERN WHERE THE DOOR GLASS DROPS WHEN CYCLED DOWN ON VEHICLES WITH THE POWER DOOR OPTION. *TT Read More »
VISIBILITY:REARVIEW MIRRORS/DEVICES
-
TSB #996042
INFORMATION ON USING 1999 PROCEDURES MANUAL FOR SIDE MIRROR REPLACEMENT. *TT Read More »
VISIBILITY:WINDSHIELD WIPER/WASHER
-
TSB #4802
REAR WIPER ARM INSTALLATION. *TT Read More »
-
TSB #984802
WHEN INSTALLING A REAR WIPER ARM ON SOME VEHICLES, BE SURE TO FOLLOW THE PROCEDURE IN THE 1999 WORKSHOP MANUAL SECTION 501-16-92. *YC Read More »
VISIBILITY:REAR WINDOW WIPER/WASHER
-
TSB #5370
SOME VEHICLES MAY EXHIBIT A REAR WIPER THAT DOES NOT FUNCTION PROPERLY (JAMMED). *TT Read More »
-
TSB #12282
SOME VEHICLES MAY EXHIBIT A REAR WIPER THAT DOES NOT FUNCTION PROPERLY (JAMMED). *TT Read More »
-
TSB #98-4802
INFORMATION ON PROCEDURES TO FOLLOW WHEN INSTALLING A REAR WIPER ARM. *TT Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
-
TSB #98613
SUBJECT REGARDING COLD AIR FELT ON THE FLOOR WHILE IN HEAT MODE. *YC Read More »
-
TSB #98417
COLD AIR MAY BE FELT ON THE FLOOR WHILE IN HEAT MODE ON SOME VEHICLES. *YC Read More »
-
TSB #BC9695961001
ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) INVALID DIAGNOSTIC CODES U1235 & 155 MAY BE STORED IF THE IGNITION SWITCH IS CYCLED FROM 'OFF' TO 'RUN' EXTREMELY SLOWLY. *TT Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE
-
TSB #01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC Read More »
-
TSB #BC0854961007
REATTACHMENT OF HEATER HOSE FITTINGS FOR CONCERN OF NO HEAT, OVERHEAT, OR COOLANT LOSS MAY OCCUR DUE TO HEATER HOSES NOT PROPERLY CONNECTED AT THEIR QUICK-CONNECT FITTINGS. *TT Read More »
AIR BAGS
-
TSB #6640
EXHIBITING AN AIR BAG LAMP ON INTERMITTENTLY WITH LAMP FAULT CODE (LFC) 24, OR DIAGNOSTIC TROUBLE CODE B1924 AND / OR B1342 STORED IN MEMORY. *TT Read More »
-
TSB #5852
VEHICLES EXHIBITING INTERMITTENT ILLUMINATION OF AIR BAG LIGHT WITH DIAGNOSTIC TROUBLE CODE B1924. *TT Read More »
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
-
TSB #6640
EXHIBITING AN AIR BAG LAMP ON INTERMITTENTLY WITH LAMP FAULT CODE (LFC) 24, OR DIAGNOSTIC TROUBLE CODE B1924 AND / OR B1342 STORED IN MEMORY. *TT Read More »
-
TSB #12529
SOME VEHICLES MAY EXHIBIT AN AIR BAG LIGHT ON INTERMITTENTLY WITH DIAGNOSTIC TROUBLE CODE B1924. *TT Read More »
STRUCTURE
-
TSB #7896
SERVICING TRAILER HITCH. Read More »
-
TSB #98113
SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS. *TT Read More »
STRUCTURE:FRAME AND MEMBERS
-
TSB #15122
SOME VEHICLES MAY EXHIBIT A VIBRATION AT IDLE AND/OR ENGINE DROANING NOISE ON ACCELERATION FROM A STOP. *SLC Read More »
-
TSB #12738
SOME VEHICLES MAY EXHIBIT A IDLE VIBRATION. Read More »
-
TSB #BC2375970501
VEHICLES BUILT BEFORE 3/24/97 MAY EXPERIENCE WIND NOISE AT THE A-PILLAR. *TW Read More »
-
TSB #BC2382970501
VEHICLES MAY EXPERIENCE A STAINING OF THE ANODIZED ALUMINUM TRIM WITH THE USE OF SOME CAR WASHES WHICH CONTAIN ULTRA VIOLET PROTECTANTS. *TW Read More »
-
TSB #BC3277970207
VEHICLES EQUIPPED WITH 4-WHEEL DRIVE, ROOF RACK AND BASE SUSPENSION MAY EXPERIENCE CLEARANCE DIFFICULTIES WITH CERTAIN GARAGES/CARPORTS. *TW Read More »
STRUCTURE:BODY
-
TSB #15939
CONCERNS WITH SPEED BODY BOOM. *TT Read More »
-
TSB #13744
SOME VEHICLES MAY EXHIBIT A BODY BOOM WHILE DRIVING HIGHWAY SPEEDS. *MJS Read More »
-
TSB #982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC Read More »
-
TSB #98021698312
SOME COMPONENTS OF THE FRAME MAY REQUIRE SERVICING DUE TO COLLISION DAMAGE. *YC Read More »
-
TSB #9831
REPAIRS TO VINYL COVERED SURFACES. *YC Read More »
-
TSB #9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC Read More »
-
TSB #983284
SOME VEHICLES MAY EXPERIENCE AN AUDIBLE 50 HZ BODY BOOM. *TT Read More »
STRUCTURE:BODY:BUMPERS
-
TSB #996876
INFORMATION PERTAINING TO CONDITIONS WITH RED STAINING (SPOTS) ON THE FRONT BUMPER WING ENDS. *TT Read More »
-
TSB #13106
ON SOME VEHICLES THE FRONT BUMPERS MAY EXHIBIT RED STAINING (SPOTS) ON THE BUMER WING ENDS. *TT Read More »
STRUCTURE:BODY:DOOR
-
TSB #99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT Read More »
-
TSB #6332
CONDITIONS WITH DOOR TRIM PANEL HAVING LOOSE OR BROKEN PULL HANDLES. *TT Read More »
-
TSB #99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT Read More »
-
TSB #9912792
CONDITIONS ON BROKENT DOOR PULL HANDLES. *TT Read More »
-
TSB #12796
ON SOME VEHICLES, THE DOOR TRIM PANELS MAY HAVE LOOSE OR BROKEN PULL HANDLES. *TT Read More »
-
TSB #98163
LOCKS FAILED. YD Read More »
-
TSB #BC2245970501
INSTRUCTIONS FOR ENABLING/DISABLING THE AUTOMATIC LOCK FEATURE. *TW Read More »
-
TSB #BC106039705
INSTRUCTIONS ON HOW TO ENABLE AND DISABLE THE AUTO LOCK FEATURE. *TW Read More »
-
TSB #BC3141970220
VEHICLES BUILT WITH RUNNING BOARDS AFTER 1/30/97 WILL NOT HAVE SEALS ON THE LOWER EDGE OF THE FRONT AND REAR DOORS. *TW Read More »
-
TSB #BC5194961001
REVISED SWITCH BEZEL IS AVAILABLE THAT WILL MINIMIZE CARGO CONTACT W/ THE SWITCH. *TT Read More »
STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
-
TSB #BC3360972301
INOPERATIVE FLOOR MODE CONCERNS MAY BE DUE TO THE PANEL/FLOOR DOOR VACUUM ACTUATOR LINKAGE DISCONNECTING FROM THE DOOR PIVOT. *JD Read More »
-
TSB #BC1022497230
INOPERATIVE FLOOR MODE CONCERNS MAY BE DUE TO THE PANEL/FLOOR DOOR VACUUM ACTUATOR LINKAGE DISCONNECTING FROM THE DOOR PIVOT. *JD Read More »
STRUCTURE:BODY:TAILGATE
-
TSB #97050110612
RATTLE OR BUZZ IN TAILGATE TRIM PANEL AFTER REMOVAL IF THE RETAINING CLIPS ARE NOT REPLACED AFTER REPAIR. *TW Read More »
VEHICLE SPEED CONTROL
-
TSB #02193
DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES-VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE. *MJ Read More »
-
TSB #01215
A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTER OPERATING AT STEADY SPEED OR EXTENDED IDLE FOR A PERIOD OF TIME. *TT Read More »
-
TSB #5258
INFORMATION ON VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH. *TT Read More »
-
TSB #985063
SUBJECT REGARDING VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH. (REPEAT MESSAGE). *TT Read More »
-
TSB #BC3153970219
INOPERATIVE OR ERRATIC CRUISE CONTROL OPERATION ALONG WITH HARSH TRANSMISSION SHIFTS. *TW Read More »
VEHICLE SPEED CONTROL:CABLES
-
TSB #BC0600961101
ACCELERATOR CABLE CONTACTING THE POWER STEERING RESERVOIR MAY CAUSING ACCELERATOR PEDAL VIBRATION. *TW Read More »
VEHICLE SPEED CONTROL:CRUISE CONTROL
-
TSB #00261
SOME VEHICLES EQUIPPED WITH A 4.6L, 5.4L, OR 6.8L ENGINE MAY EXHIBIT A ROUGH IDLE / MISS AFTER START-UP IN COLD AMBIENT TEMPERATURES. *TT Read More »
-
TSB #6287
SOME VEHICLES MAY EXPERIENCE AN IDLE VIBRATION. *TT Read More »
-
TSB #5203
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT Read More »
-
TSB #9869
CONCERNS WITH HESITATION, STUMBLE, SURGE, MISS, ROUGH IDLE, STALL AT IDLE. *TT Read More »
TIRES
-
TSB #15794
SOME 4X2 VEHICLES EQUIPPED WITH P275/60/R17 CONTINENTAL-GENERAL TIRES MAY EXHIBIT A HIGHWAY SPEED TIRE VIBRATION. *TT Read More »
-
TSB #15727
SOME 4X2 VEHICLES EQUIPPED WITH P275/60/R17 CONTINENTAL GENERAL TIRES MAY EXHIBIT A HIGHWAY SPEED TIRE VIBRATION. *TT Read More »
-
TSB #9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC Read More »
-
TSB #BC5195961001
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT Read More »
WHEELS
-
TSB #15708
SOME VEHICLES MAY EXHIBIT WHEELS THAT SEIZE TO THE HUBS AND ARE DIFFICULT TO REMOVE DURING SERVICE. *TT Read More »
-
TSB #983302
THIS BULLETIN MENTIONS HOW SOME HUB O-RINGS MAY BE CUT DURING THE INSTALLATION OF THE WHEELS. *TT Read More »
-
TSB #9811344
SOME VEHICLES MAY EXHIBIT LOOSE LUGNUTS AND / OR BROKEN WHEEL STUDS. *TT Read More »
WHEELS:HUBCAP/COVER
-
TSB #982673
IF YOU ENCOUNTER A VEHICLE WITH A MISSING WHEEL HUB O-RING, DO NOT INSTALL A NEW O-RING. *YC Read More »
WHEELS:LUGS/NUTS/BOLTS/STUDS
-
TSB #98S14
SAFETY RECALL UPDATE TO REPLACE LOCKING LUG NUTS. *TT Read More »
TRAILER HITCHES
-
TSB #13711
SUBJECT REGARDING THE SERVICING OF TRAILER HITCHES ON VEHICLES. *MJS Read More »
SEATS
-
TSB #97050110622
REQUEST FOR INFORMATION ON CONCERNS OF LEATHER SEAT COVERS WRINKLING, FOLDING,LEATHER WEAR OR CRACKING. *TW Read More »
-
TSB #9751
INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD Read More »
SEATS:FRONT ASSEMBLY:POWER ADJUST
-
TSB #982019
CONCERNS WITH THE POWER SEAT CONTROL BUTTON ( KNOB ) MAY DETACH FROM THE SWITCH ACTUATOR. *YC Read More »
INTERIOR LIGHTING
-
TSB #17459
COURTESY RAIL LAMPS DO NOT OPERATE CORRECTLY OR CAUSE A BATTERY DRAW. *TT Read More »
-
TSB #15152
SOME VEHICLES MAY EXHIBIT COURTESY RAIL LAMPS ABOVE THE 2ND ROW SEATS THAT DO NOT OPERATE PROPERLY OR CAUSE A BATTERY DRAW. *ET Read More »
-
TSB #BC2305970501
VEHICLES MAY EXPERIENCE AN INTERMITTENT VISOR VANITY MIRROR LIGHT OPERATION. *TW Read More »
EQUIPMENT
-
TSB #5206
FOR CERTAIN VEHICLES THE OCTANE SHORTING BAR LOCATED ON THE PASSENGER SIDE OF ENGINE COMPARTMENT NEAR THE BULKHEAD IS NOT INTENDED TO BE FUNCTIONAL IN REDUCING DETONATION / SPARK KNOCK. Read More »
EQUIPMENT:ELECTRICAL
-
TSB #BC1034197020
RESETTING OF THE TRIPCOMPUTER ON EXPEDITION & NAVIGATOR WHERE THE INFORMATION IS NOT CONTAINED IN THE OWNERS GUIDE. *JD Read More »
-
TSB #BC9688961001
INFORMATION FOR WHEN DIAGNOSING CONCERNS W/ FACTORY INSTALLED CELLULAR PHONES. *TT Read More »
EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
-
TSB #7897
DIAGNOSTIC INFORMATION FOR COMPACT DISC PLAYER PROBLES, NO DISC OR CD WILL NOT EJECT. THIS INDICATES NO COMMUNICATION BETWEEN RADIO AND DISC PLAYER. Read More »
-
TSB #7929
DIAGNOSTIC INFORMATION FOR COMPACT DISC PLAYER PROBLEMS. Read More »
-
TSB #13712
INFORMATION REGARDING VEHICLES THAT EXPERIENCE THE RADIOS THAT DISPLAY NO DJ-NO DISC OR CD WILL NOT EJECT. *MJS Read More »
-
TSB #13773
INFORMATION FOR COMPACT DISC PLAYER PROBLEMS, RADIO MAY DISPLAY NO DJ- NO DUSC OR CD WILL NOT EJECT. *MJS Read More »
-
TSB #99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT Read More »
-
TSB #9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT Read More »
-
TSB #9811342
INFORMATION ON REMOVING THE RADIO CHASSIS FROM SOME VEHICLES. *TT Read More »
-
TSB #983592
SUBJECT PERTAINING TO RADIO INOPERATIVE CONDITIONS. *TT Read More »
-
TSB #BC105849705
VEHICLES WITH PREMIUM RADIOS WILL BE EQUIPPED WITH VOLUME CONTROL/ON-OFF SWITCH. *TW Read More »
-
TSB #97050110632
NEWLY DESIGNED VOLUME KNOB, INCORPORATING A MOMENTARY ON/OFF SWITCH. *TW Read More »
-
TSB #BC3140970220
INOPERATIVE CD CHANGER MAY BE DUE TO LOOSE 66 PIN CONNECTOR. *TW Read More »
EQUIPMENT:APPLIANCE:AIR CONDITIONER
-
TSB #02208
CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH Read More »
-
TSB #0018
VEHICLES EQUIPPED WITH ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) , MAY EXERIENCE THE BLOWER MOTOR STAYING ON HIGH AFTER DESIRED TEMPERATURE IS REACHED AND/ OR THE SYSTEM DOES NOT MAINTAIN SET TEMPERATURE. Read More »
-
TSB #13342
VEHICLES WITH 2.4L, 4.6L, AND 5.4L ENGINES MAY EXHIBIT AN A/C MOAN AT IDLE. *TT Read More »
-
TSB #99195
SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT Read More »
-
TSB #99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »
-
TSB #6686
SUBJECT REGARDING AIR CONDITIONER VACUUM RESERVOIR / CHECK VALVE LOCATION. *TT Read More »
-
TSB #12994
SUBJECT REGARDING A/C VACUUM RESERVOIR / CHECK VALVE LOCATION FOR THE AIR CONDITIONING SYSTEM. *TT Read More »
-
TSB #99128
SOME VEHICLES MAY EXHIBIT A WHISTLING NOISE WHILE DRIVING WITH A/C IN THE OFF POSITION AT SPEEDS ABOVE 64 KM/H (40 MPH). *TT Read More »
-
TSB #98239
EXPERIENCING NO OR INTERMITTENT AUXILLARY A/C MODE / BLOWER CONTROL ON SOME VEHICLES. *YC8 Read More »
-
TSB #BC3070970227
CONCERNS OF CONDENSATE FORMING ON OUTSIDE OF EVAPORATOR CASE. *TW Read More »
-
TSB #9735
AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD Read More »
-
TSB #BC1033797020
CONDENSATE FORMING ON THE OUTSIDE OF THE EVAPORATOR. *JD Read More »
UNKNOWN OR OTHER
-
TSB #15605
SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT Read More »
-
TSB #15504
SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT Read More »
-
TSB #01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC Read More »
-
TSB #01128
SOME VEHICLES MAY EXHIBIT A CHECK SUSPENSION LAMP ON WITH DIAGNOSTIC TROUBLE CODES B2140 OR C2140 EVEN AFTER THE AIR SUSPENSION SWITCH IN THE UPPER RH KICK PANEL HAS BEEN TURNED ON. Read More »
-
TSB #0017
SUBJECT ON THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODES MAY APPEAR. *MJS Read More »
-
TSB #99234
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT Read More »
-
TSB #99185
VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. Read More »
-
TSB #99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT Read More »
-
TSB #991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT Read More »
-
TSB #12743
EXHIBITING MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTC(S) PO351 AND / OR P0356 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT Read More »
-
TSB #98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. Read More »
-
TSB #4619
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT Read More »
-
TSB #4626
INFORMATION ON VEHICLES EXHIBITING AND O/D OFF LAMP FLASHING WITH DIAGNOSTIC TROUBLE CODE 62 / 628 / 1728. *TT Read More »
-
TSB #11781
INFORMATION ON SETTING THE CHECK ENGINE LIGHT AND SETTING DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK). *TT Read More »
-
TSB #982545
IMPORTANT SERVICE INSTRUCTIONS FOR ONP 97-B-17, EXPEDITION ONLY. *YC Read More »
-
TSB #982548
BRIEF INFORMATION GIVING THE CORRECT PART NUMBER FOR TSB 98-3-12. *YC Read More »
-
TSB #982691
CONCERNS OF ENGINE CHECKLIGHT ON AND DTC P1506 ( IDLE AIR CONTROL OVER SPEED ERROR ) AND/OR FAST IDLE. *YC Read More »
-
TSB #982733
VEHICLES WITH THE E4OD ARE ADDED TO THE FQR ( FORD QUALITY RENEWAL ) ASSEMBLY PROGRAM. *YC Read More »
-
TSB #9858
THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0503 MAY BE STORED IN MEMORY. *YC Read More »
-
TSB #98419
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC Read More »
-
TSB #090308
MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455 Read More »
-
TSB #BC2363970501
THE ONLY AUTHORIZED REPAIR FOR A FRONT FRAME BUMPER MOUNTING BRACKET NEEDING REPLACEMENT IS TO REPLACE THE FRAME. *TW Read More »
-
TSB #BC3007970501
REVISION TO THE TECHNICAL INSTRUCTIONS WHEN PERFORMING RECALL 96S60. *TW Read More »
-
TSB #BC105819705
SOME EXPEDITIONS MAY EXPERIENCE AN INTERMITTENT VISOR VANITY MIRROR LIGHT OPERATION. *TW Read More »
-
TSB #9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD Read More »
-
TSB #97626
ENGINE- CHECKING ENGINE OIL LEVEL IN OWNER'S GUIDE INCORRECT. *JD Read More »
-
TSB #96S60
REVISED TECHNICAL INSTRUCTIONS CONCERNING RECALL 96S60. *TW Read More »
-
TSB #BC3060970228
INSTRUCTIONS FOR RESETTING THE TRIP COMPUTER. *TW Read More »
-
TSB #BC3500972301
LOOKING FOR MORE DEFINITION OF VIBRATION CONCERNS ON 4X2 VEHICLES. *JD Read More »
-
TSB #BC1018197230
ENGINEERING IS LOOKING FOR MORE DEFINITION OF VIBRATION CONCERNS ON 4X2 VEHICLES. *JD Read More »
-
TSB #BC1025597230
VEHICLES EQUIPPED WITH 4-WHEEL DRIVE, ROOF RACK AND BASE SUSPENSION MAY EXPERIENCE CLEARANCE DIFFICULTIES WITH GARAGE/CARPORTS. *JD Read More »
-
TSB #962518
DOOR - POWER POINT ACCESS DOOR BREAKS - VEHICLES BUILT THROUGH 8/31/96. *TW Read More »
-
TSB #BC0843961008
INFORMATION ON REPLACING THE COMPASS ASSY FOR ERRATIC/NON-OPERATION. *TT Read More »
Browse Other Expedition Years
- 2022 Ford Expedition
- 2021 Ford Expedition
- 2020 Ford Expedition
- 2019 Ford Expedition
- 2018 Ford Expedition
- 2017 Ford Expedition
- 2016 Ford Expedition
- 2015 Ford Expedition
- 2014 Ford Expedition