Technical Service Bulletins (TSBs) for the 2001 Excursion are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
SOME VEHICLES MAY EXHIBIT HIGHER THAN NORMAL STEERING EFFORTS WHEN THE VEHICLES IS AT A VERY LOW SPEED OR STOPPED WITH THE BRAKES APPLIED. *TT Read More »
SLIGHT PURGE OF GREASE FROM THE HUB BEARING UNIT. THIS GREASE MAY BE NOTED BETWEEN THE HUB UNIT AND THE INBOARD ROTOR FLANGE AND ON THE INBOARD SIDE OF THE BEARING. 1999-2003 MODELS. *TT Read More »
VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST. OASIS. TO ALSO INCLUDE 2005 SUPER DUTY F-SERIES, EXCURSION, AND F650/750. *TT Read More »
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. Read More »
SOME 7.3L DIESEL TURBOCHARGER PEDESTALS MAY LEAK OIL AROUND THE EXHAUST BACK PRESSURE ACTUATOR (EBP). *TT THIS ARTICLE SUPERSEDES TSB 03-21-51 DATED 10/30/2003. *TT Read More »
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. Read More »
A LACK OF POWER UNDER A LOAD, AT CRUISE OR ON ACCELERATION MAY OCCUR ON SOME VEHICLES BUILT BEFORE 11/25/2000 EQUIPPED WITH THE 7.3L DIT ENGINE. *TT Read More »
NO START/REPEAT STARTER FAILURE OR A STICKING/BINDING IGNITION LOCK CYLINDER, STARTER STAYING ENGAGED AT START UP. ALSO INCLUDES 2003 SUPER DUTY F SERIES. *TT Read More »
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. Read More »
LACK OF POWER, SMOKE, OR OIL LEAKS AROUND THE CHARGE AIR COOLER (CAC). 1999-2003 SUPER DUTY/EXCURSION VEHICLES EQUIPPED WITH 7.3 OR 6.0 FORD NAVISTAR DIESEL ENGINE. *TT Read More »
DRIVEABILITY-NO START/REPEAT STARTER FAILURE-REPEAT STARTER REPLACEMENT. ELECTRICAL-STICKING OR BINDING IGNITION LOCK CYLINDER BETWEEN START AND RUN. ENGINE-STARTING-STARTER STAYING ENGAGED AT START UP. Read More »
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT Read More »
A CONDITION MAY EXIST WITH LACK OF POWER UNDER A LOAD, AT CRUISE OR ON ACCELERATION MAY OCCUR ON SOME VEHICLES BUILT BEFORE 11/25/2000 EQUIPPED WITH THE 7.3L DIT ENGINE. Read More »
FUEL QUALITY AND MOISTURE IN CERTAIN DIESEL FUELS MAY CAUSE SOME VEHICLES TO EXHIBIT A NO START, GRADUAL LOSS OF POWER, OR A ROUGH IDLE CONDITION DUE TO FUEL GELLING DURING EXTREME COLD WEATHER OPERATION. Read More »
SOME VEHICLES EQUIPPED WITH 4R100 TRANSMISSION AND 7.3L ENGINE OR WITH 4R100 6.8L MAY EXHIBIT ENGINE STALL AFTER TRANSMISSION ENGAGEMENT INTO REVERSE AND A TIP IN BACKOUT OF THE THROTTLE. Read More »
SOME VEHICLES MAY EXHIBIT A BUCK OR JERK (ALSO KNOWN AS HITCHING) DURING HIGHWAY DRIVING AT SPEEDS 40 MPH OR GREATER WITH THE CRUISE CONTROL ENGAGED. *TT Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
SOME VEHICLES BUILT AFTER 12/7/1998 EQUIPPED WITH A 7.3L DIT ENGINE MAY EXHIBIT A HOOT OR HOWLING NOISE FROM THE TURBOCHARGER. 2003 SUPER DUTY F SERIES ALSO INCLUDED. *TT Read More »
SOME VEHICLES WITH 7.3L DIT ENGINES MAY EXHIBIT LOOSE TURBO BOLTS ON THE TURBO HOUSING. TYPICAL SYMPTOMS OF LOOSE BOLTS INCLUDE LACK OF POWER AND AN OIL LEAK. *TT Read More »
SOME VEHICLES EQUIPPED WITH 5.4L OR 6.8L ENGINE BUILT THROUGH 9/10/2000 MAY EXHIBIT A MISS SOUND FROM THE EXHAUST. THIS MAY BE CUASED BY THE DESIGN OF THE EXHAUST Y-PIPE WHICH CAN CAUSE A MISS LIKE SOUND KNOWN AS IMPINGEMENT. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
SOME VEHICLES WITH 7.3L DIT ENGINES MAY EXHIBIT LOOSE TURBO BOLTS ON THE TURBO HOUSING. TYPICAL SYMPTOMS OF LOOSE BOLTS INCLUDE LACK OF POWER AND AN OIL LEAK. *TT Read More »
FUEL CONDITIONER. LOW POWER, POOR FUEL ECONOMY, FUEL GELLING IN COLD WEATHER, EXCESSIVE WHITE SMOKE ON COLD START, HARD START, OR COKING OF COMPONENTS EXPOSED TO EXHAUST. *TT Read More »
MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT Read More »
FUEL QUALITY AND MOISTURE IN CERTAIN DIESEL FUELS MAY CAUSE SOME VEHICLES TO EXHIBIT A NO START, GRADUAL LOSS OF POWER, OR A ROUGH IDLE CONDITION DUE TO FUEL GELLING DURING EXTREME COLD WEATHER OPERATION. Read More »
SOME VEHICLES EQUIPPED WITH 4R100 TRANSMISSION, HAVING A TRANSMISSION BUILD DATE BETWEEN 7/27/2000 AND 3/23/2001, MAY EXHIBIT AN INTERMITTENT, DELAYED OR NO SECOND GEAR CONDITION. Read More »
OWNER NOTIFICATION INFORMING OWNERS THAT THEIR TRANSMISSION COULD BE DAMAGED INTERNALLY AND, POTENTIALLY, COULD RESULT IN A LOSS OF SECOND GEAR OR, ULTIMATELY, AN INABILITY TO MOVE THE VEHICLE IF IT IS DRIVEN UNDER CERTAIN CONDITIONS. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH
WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT Read More »
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT Read More »
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT Read More »
VEHICLES EQUIPPED WITH A 7.3L ENGINE (AFTER SERIAL NUMBER 0661894) - UNDER VALVE COVER (UVC) HARNESS RETAINER CLIP RELEASED FOR SERVICE. INCLUDES 2003 ECONOLINE, SUPER DUTY, F650/750 AND EXCURSION. Read More »
MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. Read More »
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN ... Read More »
SOME VEHICLES EQUIPPED WITH 7.3L DI ENGINE MAY EXHIBIT FALSE DIAGNOSTIC TROUBLE CODES P1105, P1106 (UPPER AND LOWER ALTERNATOR FAULTS). *TT Read More »
SOME VEHICLES BUILT AFTER 12/4/00 AND EQUIPPED WITH A 5.4L OR 6.8L ENGINE MAY EXHIBIT INCONSISTENT SPEED OR SURGING WITH THE CRUISE CONTROL SET AT APPROXIMATELY 46, 70, OR 92 MPH. *TT Read More »
SOME VEHICLES BUILT AFTER 12/4/00 AND EQUIPPED WITH A 5.4L OR 6.8L ENGINE MAY EXHIBIT INCONSISTENT SPEED OR SURGING WITH THE CRUISE COTNROL SET AT APPROXIMATELY 46 OR 70 MPH. *TT Read More »
SOME VEHICLES WITH A 5.4 OR 6.8L ENGINE MAY EXHIBIT SLIGHTLY INCONSISTENT SPEED OR SURGING WITH THE CRUISE CONTROL SET AT APPROXIMATELY 70 MILES PER HOUR. *TT Read More »
SOME VEHICLES EQUIPPED WITH A 4R100 TRANSMISSION AND BUILT BETWEEN JANUARY 1, 2001 AND MAY 1, 2002 MAY EXHIBIT FLASHING TRANSMISSION CONTROL INDICATOR LAMP AND ANY OR ALL TORQUE CONVERTER CLUTCH DIAGNOSTIC TROUBLE CODES P0740, P0741, ... Read More »
CONCERNS WITH VEHICLES EXHIBITING THE OIL PRESSURE GAUGE REGISTERING LOW OR NO OIL PRESSURE USUALLY ON INITIAL START-UP AFTER SEVERAL HOURS OF COLD SOAK. *TT Read More »
