Technical Service Bulletins (TSBs) for the 2000 Excursion are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
SOME VEHICLES MAY EXHIBIT HIGHER THAN NORMAL STEERING EFFORTS WHEN THE VEHICLES IS AT A VERY LOW SPEED OR STOPPED WITH THE BRAKES APPLIED. *TT Read More »
SLIGHT PURGE OF GREASE FROM THE HUB BEARING UNIT. THIS GREASE MAY BE NOTED BETWEEN THE HUB UNIT AND THE INBOARD ROTOR FLANGE AND ON THE INBOARD SIDE OF THE BEARING. 1999-2003 MODELS. *TT Read More »
A SLOW RELEASE OF THE HUBS, AT TIMES, WHICH MAY BE REGARDED A NOT NORMAL BY THE OPERATOR. SLOW RELEASE OF THE HUBLOCKS IS NOT CONSIDERED ABNORMAL FOR THIS SYSTEM. Read More »
VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST. OASIS. TO ALSO INCLUDE 2005 SUPER DUTY F-SERIES, EXCURSION, AND F650/750. *TT Read More »
THE DRIVER'S SIDE REAR BRAKE CALIPER WILL BE RELOCATED BEHIND THE REAR AXLE. IN ADDITION, THESE VEHICLES WILL NO LONGER HAVE A CALIPER SHIELD ON THE DRIVERS SIDE OF THE REAR AXLE. Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS
SOME VEHICLES MAY EXHIBIT BRAKE VIBRATION OR SHUDDER WHILE BRAKING. ENGINEERING HAS RELEASED NEW BRAKE PAD WHICH IS EQUIPPED WITH A V-SPRING. *TT Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
SOME 7.3L DIESEL TURBOCHARGER PEDESTALS MAY LEAK OIL AROUND THE EXHAUST BACK PRESSURE ACTUATOR (EBP). *TT THIS ARTICLE SUPERSEDES TSB 03-21-51 DATED 10/30/2003. *TT Read More »
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. Read More »
VEHICLES EQUIPPED WITH 7.3L DIT ENGINE BUILT AFTER ENGINE SERIAL NUMBER 896812 MAY HAVE A INJECTION CONTROL PRESSURE (ICP) OIL AERATION READING THAT IS HIGHER THAN THE SPECIFICATION. Read More »
7.3L POWERSTROKE DIESEL ENGINE WITH ENGINE SERIAL NUMBER 661894 THROUGH 1311240 MAY EXHIBIT A KNOCK NOISE ABOVE THE NORMAL SOUND OF THE DIESEL COMBUSTION. THIS BULLETIN ALSO REPLACES 01146. *TT Read More »
A LACK OF POWER UNDER A LOAD, AT CRUISE OR ON ACCELERATION MAY OCCUR ON SOME VEHICLES BUILT BEFORE 11/25/2000 EQUIPPED WITH THE 7.3L DIT ENGINE. *TT Read More »
NO START/REPEAT STARTER FAILURE OR A STICKING/BINDING IGNITION LOCK CYLINDER, STARTER STAYING ENGAGED AT START UP. ALSO INCLUDES 2003 SUPER DUTY F SERIES. *TT Read More »
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. Read More »
LACK OF POWER, SMOKE, OR OIL LEAKS AROUND THE CHARGE AIR COOLER (CAC). 1999-2003 SUPER DUTY/EXCURSION VEHICLES EQUIPPED WITH 7.3 OR 6.0 FORD NAVISTAR DIESEL ENGINE. *TT Read More »
DRIVEABILITY-NO START/REPEAT STARTER FAILURE-REPEAT STARTER REPLACEMENT. ELECTRICAL-STICKING OR BINDING IGNITION LOCK CYLINDER BETWEEN START AND RUN. ENGINE-STARTING-STARTER STAYING ENGAGED AT START UP. Read More »
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT Read More »
A CONDITION MAY EXIST WITH LACK OF POWER UNDER A LOAD, AT CRUISE OR ON ACCELERATION MAY OCCUR ON SOME VEHICLES BUILT BEFORE 11/25/2000 EQUIPPED WITH THE 7.3L DIT ENGINE. Read More »
FUEL QUALITY AND MOISTURE IN CERTAIN DIESEL FUELS MAY CAUSE SOME VEHICLES TO EXHIBIT A NO START, GRADUAL LOSS OF POWER, OR A ROUGH IDLE CONDITION DUE TO FUEL GELLING DURING EXTREME COLD WEATHER OPERATION. Read More »
SOME VEHICLES EQUIPPED WITH 4R100 TRANSMISSION AND 7.3L ENGINE OR WITH 4R100 6.8L MAY EXHIBIT ENGINE STALL AFTER TRANSMISSION ENGAGEMENT INTO REVERSE AND A TIP IN BACKOUT OF THE THROTTLE. Read More »
SOME VEHICLES EQUIPPED WITH POWERSTROKE DIESEL ENGINES AFTER SERIAL NUMBER 0896812 (ENGINE BUILD DATE), MAY EXHIBIT A NOISE ABOVE THE NORMAL SOUND OF THE DIESEL COMBUSTION.*JB Read More »
SOME VEHICLES EQUIPPED WITH 7.3 DIT ENGINE MAY EXHIBIT ENGINE ROUGHNESS, MISSES, BUCK / JERK, HESITATION / STUMBLE, SURGE, LACK OF POWER, VARIOUS IDLE SYMPTOMS, MALFUNCTION INDICATOR LAMP ON, ETC. Read More »
SOME VEHICLES EQUIPPED WITH 7.3L DIT ENGINE MAY EXHIBIT AN ENGINE THAT RUNS ROUGH, MISSES, BUCK / JERK, HESITATE / STUMBLE, SURGE, LACKS POWER, VARIOUS IDLE SYMPTOMS, MALFUNCTION INDICATOR LAMP ON. Read More »
SOME VEHICLES MAY EXHIBIT A BUCK OR JERK (ALSO KNOWN AS HITCHING) DURING HIGHWAY DRIVING AT SPEEDS 40 MPH OR GREATER WITH THE CRUISE CONTROL ENGAGED. *TT Read More »
SOME VEHICLES BUILT AFTER 12/7/1998 EQUIPPED WITH A 7.3L DIT ENGINE MAY EXHIBIT A HOOT OR HOWLING NOISE FROM THE TURBOCHARGER. 2003 SUPER DUTY F SERIES ALSO INCLUDED. *TT Read More »
SOME VEHICLES WITH 7.3L DIT ENGINES MAY EXHIBIT LOOSE TURBO BOLTS ON THE TURBO HOUSING. TYPICAL SYMPTOMS OF LOOSE BOLTS INCLUDE LACK OF POWER AND AN OIL LEAK. *TT Read More »
THE VEHICLE EQUIPPED WITH 5.4L OR 6.8L GAS ENGINES MAY EXHIBIT AN OVERHEATING CONDITION DURING PREDELIVERY INSPECTION. THIS MAY BE CAUSED BY A LOW COOLANT LEVEL. Read More »
SOME VEHICLES EQUIPPED WITH 5.4L OR 6.8L ENGINE BUILT THROUGH 9/10/2000 MAY EXHIBIT A MISS SOUND FROM THE EXHAUST. THIS MAY BE CUASED BY THE DESIGN OF THE EXHAUST Y-PIPE WHICH CAN CAUSE A MISS LIKE SOUND KNOWN AS IMPINGEMENT. Read More »
SOME VEHICLES EQUIPPED WITH THE 6.8L V-10 ENGINE AND CALIFORNIA EMISSIONS MAY EXHIBIT AN EXHAUST FLUTTER NOISE. THIS NOISE MAY ALSO BE DESCRIBED AS AN ENGINE MISS OR EXHAUST LEAK. *TT Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
SOME VEHICLES WITH 7.3L DIT ENGINES MAY EXHIBIT LOOSE TURBO BOLTS ON THE TURBO HOUSING. TYPICAL SYMPTOMS OF LOOSE BOLTS INCLUDE LACK OF POWER AND AN OIL LEAK. *TT Read More »
CONCERNS WITH THE INTAKE MANIFOLD LEAKING OR WEEPING COOLANT FROM PASSENGER SIDE GASKET AT RIGHT REAR CORNER OF HEAD-TO-MANIFOLD JOINT. *JB Read More »
FUEL CONDITIONER. LOW POWER, POOR FUEL ECONOMY, FUEL GELLING IN COLD WEATHER, EXCESSIVE WHITE SMOKE ON COLD START, HARD START, OR COKING OF COMPONENTS EXPOSED TO EXHAUST. *TT Read More »
MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT Read More »
FUEL QUALITY AND MOISTURE IN CERTAIN DIESEL FUELS MAY CAUSE SOME VEHICLES TO EXHIBIT A NO START, GRADUAL LOSS OF POWER, OR A ROUGH IDLE CONDITION DUE TO FUEL GELLING DURING EXTREME COLD WEATHER OPERATION. Read More »
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM. *TT Read More »
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM. *TT Read More »
A TECHNICAL ASSISTANCE HELPLINE HAS BEEN ESTABLISHED TO HELP WITH DIAGNOSTICS AND / OR MECHANICAL CONCERNS WITH THE NEW VENTURE TRANSFER CASE ON CERTAIN VEHICLES. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT Read More »
VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. Read More »
VEHICLES MAY EXPERIENCE PARTICLE CONTAMINANTS, FROM PRIOR TRANSMISSIION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IF NOT PROPERLY FLUSHED. *MJS Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH
SOME VEHICLES EQUIPPED WITH ELECTRONIC SHIFT ON THE FLY TRANSFER CASE MAY EXHIBIT ONE OR MORE OF THE FOLLOWING CONDITIONS: FRONT HUBS WILL NOT UNLOCK / LOCK WITH MODE SWITCH, NOISE FROM THE FRONT AXLE WHILE DRIVING IN 2 WHEEL DRIVE ... Read More »
SOME VEHICLES EQUIPPED WITH 10.50-INCH RING GEAR, FULL-FLOATING REAR AXLES MAY EXHIBIT A LEAK AT THE OUTBOARD END OF THE AXLE SHAFT(S). *TT Read More »
SOME VEHICLES EQUIPPED WITH ELECTRONIC SHIFT ON THE FLY TRANSFER CASE MAY EXHIBIT FRONT HUBS THAT WILL NOT UNLOCK / LOCK WITH MODE SWITCH; NOISE FROM THE FRONT AXLE WHILE IN 2 WHEEL DRIVE MODE, AIR CONDITIONING SWITCHING TO DEFROST WHEN ... Read More »
WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT Read More »
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT Read More »
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT Read More »
VEHICLES EQUIPPED WITH A 7.3L ENGINE (AFTER SERIAL NUMBER 0661894) - UNDER VALVE COVER (UVC) HARNESS RETAINER CLIP RELEASED FOR SERVICE. INCLUDES 2003 ECONOLINE, SUPER DUTY, F650/750 AND EXCURSION. Read More »
MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. Read More »
SOME VEHICLES BUILT BETWEEN 10/24/99 AND 11/8/99 EQUIPPED WITH 7.3L POWERSTROKE ENGINE THAT HAVE CALIFORNIA EMISSIONS CERTIFIED, MAY EXHIBIT A DEAD BATTERY AND CIRCUIT BOARD CONCERNS DURING PREDELIVERY INSPECTION. Read More »
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN ... Read More »
SOME VEHICLES EQUIPPED WITH 7.3L DI ENGINE MAY EXHIBIT FALSE DIAGNOSTIC TROUBLE CODES P1105, P1106 (UPPER AND LOWER ALTERNATOR FAULTS). *TT Read More »
CUSTOMER SATISFACTION PROGRAM 06N05. CERTAIN VEHICLES EXTENDED WARRANTY - HEADLAMP SWITCH KNOB MAY FRACTURE OR FALL OFF THE HEADLAMP SWITCH. *TT HEADLAMP KNOB SWITCH - SERVICE TIP. *TT Read More »
SOME VEHICLES EQUIPPED WITH THE REVERSE PARK AID FEATURE (RPA) MAY EXHIBIT A RPA THAT EMITS SOLID TONE IMMEDIATELY AFTER REVERSE IS ENGAGED. *TT Read More »
THE VEHICLE MAY EXHIBIT A YELLOWISH STAIN ON THE DUTCH REAR DOORS UNDER THE WIPER ARM ASSEMBLY. THIS CONDITION COULD BE CAUSED BY A CHEMICAL REACTION BETWEEN THE WASHER FLUID AND 4 OF THE TUBES USED IN THE REAR WASHER SYSTEM. Read More »
SOME VEHICLES BUILT BETWEEN 8/14/99 AND 11/16/99 MAY EXHIBIT SHIFT ON THE FLY ENGAGEMENT/DISENGAGEMENT ISSUES OR HEATER/AC ONLY BLOWING OUT OF THE DEFROST MODE. *MJS Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:WINDSHIELD:ELECTRICAL HEATING ELEMENT
SOME VEHICLES EQUIPPED WITH THE REVERSE PARK AID FEATURE (RPA) MAY EXHIBIT A RPA THAT EMITS A SOLID TONE IMMEDIATELY AFTER REVERSE IS ENGAGED. *TT Read More »
SOME VEHICLES MAY EXHIBIT AN ENGINE BUCK, SURGE, OR JERK (ALSO KNOWN AS HITCHING / HESITATION) WHILE THE SPEED CONTROL IS ACTIVE THROUGH ALL ENGINE TEMPERATURES. *TT Read More »
INFORMATION ON THE IDLE KICKER FEATURE, WHICH UNDER CONDITIONS WILL AUTOMATICALLY ELEVATE THE IDLE SPEED AFTER 130 SECONDS OF IDLING AT COLD TEMPERATURES. *TT Read More »
VEHICLE EQUIPED WITH EITHER MANUAL OR ELECTRONIC SHIFT 4X4 SYSTEM MAY EXHIBIT A VIBRATION OR A RATCHETING NOISE FROM THE FRONT OF THE VEHICLE. ANOTHER SYMPTOM MAY BE DESCRIBED AS FRONT HUBLOCKS NOT RELEASING. Read More »
BACK OVER PREVENTION:WARNINGS:EXTERNAL/PEDESTRIAN ALERT
SOME VEHICLES EQUIPPED WITH THE REVERSE PARK AID FEATURE (RPA) MAY EXHIBIT A RPA THAT EMITS A SOLID TONE IMMEDIATELY AFTER REVERSE IS ENGAGED. *TT Read More »
THE VEHICLE EXHIBIT SHIF ON THE FLY ENGAGEMENT/DISENGAGEMENT ISSUES OR HEATER/AC ONLY BLOWING OUT OF THE DEFROST MODE. THESE CONDITIONS MAY BE CAUSED BY THE VACUUM PUMP. Read More »
CONCERNS WITH VEHICLES EXHIBITING THE OIL PRESSURE GAUGE REGISTERING LOW OR NO OIL PRESSURE USUALLY ON INITIAL START-UP AFTER SEVERAL HOURS OF COLD SOAK. *TT Read More »
A CONDITION MAY EXIST WHERE THE MALFUNCTION INDICATOR LAMP IS ON WITH DIAGNOSTIC TROUBLE CODE P0340 (CAMSHAFT POSITION (CMP) SENSOR A CIRCUIT) STORED, ACCOMPANIED WITH A DRIVEABILITY CONCERN. Read More »
SOME VEHICLES MAY PRODUCE A MALFUNCTION INDICATOR LAMP ILLUMINATED, ROUGH IDLE, A CHECK ENGINE LIGHT, AND DIAGNOSTIC TROUBLE CODES (DTCS) P0350 - P0360 STORED IN MEMORY. *TT Read More »
THERE HAVE BEEN SOME INQUIRIES AS TO WHETHER CERTAIN VEHICLES CAN BE USED FOR SNOWPLOWING. THIS BULLETIN STATES THAT UNDER NO CIRCUMSTANCE SHOULD A SNOWPLOW BE ATTACHED TO CERTAIN VEHICLES. Read More »
