Technical Service Bulletins (TSBs) for the 2004 E-150 are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
INTERMITTENT CRANK NO START DUE TO AN EGR THROTTLE PLATE THAT IS STUCK CLOSED. THE ENGINE MAY SEEM LIKE IT HAS NO COMPRESSION DUE TO A FASTER THAN NORMAL CRANKING SPEED OF GREATER THAN 200 RPM. Read More »
LACK OF POWER OR RUNS ROUGH CONDITION, AND/OR THE MALFUNCTION INDICATOR LIGHT ON WITH EGR RELATED DIAGNOSTIC TROUBLE CODES (P0401, P0402, P0403, P0404, P0405, OR P0406). *TT Read More »
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. Read More »
LOW ENGINE RPM AND/OR OTHER DRIVEABILITY CONCERNS WHEN PERFORMING A LONG DECELERATION IN MANUAL SECOND OR THIRD GEAR. CUT-AWAY/CHASSIS CAB VEHICLES EQUIPPED WITH A 6.0L DIESEL ENGINE BUILT BEFORE 2/27/2004. Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
FORD: ON SOME TRUCKS, THERE IS A NO CRANK SITUATION AND IF VOLTAGE ON TRANSMISSION RANGE SENSOR AT PIN 21, IS LESS THAN 5 VOLTS, DISCONNECT THE ENGINE COOLING FAN CLUTCH, ELECTRONICALLY, AND RECHECK VOLTAGE. Read More »
FUEL CONDITIONER. LOW POWER, POOR FUEL ECONOMY, FUEL GELLING IN COLD WEATHER, EXCESSIVE WHITE SMOKE ON COLD START, HARD START, OR COKING OF COMPONENTS EXPOSED TO EXHAUST. *TT Read More »
LOW/REVERSE GEAR SET PINION SHAFT(S) THAT MAY WALK OUT, CAUSING METALLIC PARTICLE CONTAMINATION. CUSTOMER SATISFACTION PROGRAM 04B24. TRANSMISSION REVERSE PLANET REPLACEMENT. *TT SUPPLEMENT #1 AND #2. *TT SUPPLEMENT #3. Read More »
When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all versions of MERCON SP and can be used going forward. Mixing MERCON LV and MERCON SP in the same transmission is acceptable. Read More »
FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. Read More »
TORQSHIFT TRANSMISSION - INTERMITTENT CLUNK WHEN SHIFTING FROM REVERSE GEAR OR DRIVE GEAR TO PARK. MULTIPLE VEHICLES. FORD OASIS. TO INCLUDE 2006 FORD F-53. *TT Read More »
FORD: ON SOME TRUCKS, THERE IS A NO CRANK SITUATION AND IF VOLTAGE ON TRANSMISSION RANGE SENSOR AT PIN 21, IS LESS THAN 5 VOLTS, DISCONNECT THE ENGINE COOLING FAN CLUTCH, ELECTRONICALLY, AND RECHECK VOLTAGE. Read More »
VARIOUS DRIVEABILITY CONCERNS SUCH AS HARD START, NO START, HESITATION, RUNS ROUGH, ERRATIC SHIFTS, AND THE MALFUNCTION INDICATOR LAMP ON WITH A VARIETY OF DIAGNOSTIC TROUBLE CODES. WIRING HARNESS CHAFING. Read More »
