Technical Service Bulletins (TSBs) for the 2000 Crown Victoria are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
ON SOME VEHICLES THE REAR SUSPENSION UPPER CONTROL ARM BRACKETS ON THE FRAME MAY DEVELOP MINOR CRACKS WHEN SUBJECTED TO SEVERE DUTY SERVICE. *JB Read More »
SUBJECT PERTAINING TO COSMETIC CRACKS IN FRAME AT THE REAR UPPER CONTROL ARM ACCESS OPENING WHEN SUBJECTED TO SEVERE DUTY OPERATING CONDITIONS. *JB Read More »
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. Read More »
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. Read More »
SOME DEDICATED CNG VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS DUE TO A LOSS OF INJECTOR PERFORMANCE, RESULTING FROM FUEL QUALITY. Read More »
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. Read More »
VEHICLES BUILT UP TO DECEMBER OF 1999 MAY EXHIBIT A CLUNK NOISE FROM THE REAR OF THE VEHICLE WHEN DRIVING OVER SPEED BUMPS. THIS MAY BE CAUSED BY THE FILL-LIMITING VALVE INSIDE THE FUEL TANK. Read More »
ON SOME VEHICLES, THE ENGINE MOUNTS MAY NOT EXHIBIT SATISFACTORY DURABILITY UNDER SEVERE OPERATING CONDITIONS THAT MAY BE ENCOUNTERED BY POLICE, TAXI OR LIMO / LIVERY VEHICLES SUCH AS EXTENDED IDLING AT HIGH AMBIENT TEMPERATURES. Read More »
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »
SOME VEHICLES EQUIPPED WITH THE ROMEO BUILT 4.6L 2V ENGINE MAY EXHIBIT AN ENGINE OIL LEAK OR OIL WEEPAGE FROM THE CYLINDER HEAD GASKET AT THE RIGHT HAND REAR OR THE LEFT HAND FRONT OF THE ENGINE. Read More »
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT Read More »
SOME VEHICLES MAY EXHIBIT ANY OF P0350 THROUGH P0358 COIL DIAGNOSTIC TROUBLE CODES, CHECK ENGINE LIGHT ON AND ROUGH IDLE UNDER COLD START CONDITIONS. *TT Read More »
FORD: CERTAIN 1999-2001 MODEL YEAR VEHICLES UP TO 6000 LB GVWR REGISTERED IN NEW YORK AND CERTAIN 2001 VEHICLES UP TO 6000 LB GVWR REGISTERED IN THE STATE OF MAINE, CERTIFIED FOR SALE IN CALIFORNIA-FEDERAL EMISSION WARRANTY REFUND. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
EXTENDED COVERAGE PROGRAM 05N04 - EXTENDED COVERAGE FOR COMPOSITE INTAKE MANIFOLD. THIS PROGRAM IS BEING PROVIDED AS A SETTLEMENT TO A CLASS ACTION LAWSUIT. Read More »
FORD/LINCOLN MERCURY: CERTAIN 1992-2001 MODEL YEAR CROWN VICTORIA, GRAND MARQUIS, AND TOWN CAR VEHICLES REGISTERED IN THE STATES OF WISCONSIN AND CONNECTICUT UPGRADE MODIFICATIONS FOR HIGH SPEED REAR IMPACTS. Read More »
VEHICLES BUILT UP TO DECEMBER OF 1999 MAY EXHIBIT A CLUNK NOISE FROM THE REAR OF THE VEHICLE WHEN DRIVING OVER SPEED BUMPS. THIS MAY BE CAUSED BY THE FILL-LIMITING VALVE INSIDE THE FUEL TANK. Read More »
SOME OF THE COMPOSITE INTAKE MANIFOLDS USED ON 4.6L SOHC ENGINES MAY DEVELOP FATIGUE CRACKS AT THE COOLANT CROSSOVER DUCT. THIS CONDITION COULD RESULT IN ENGINE COOLANT LEAKAGE WHICH, IF NOT SERVICED, MAY CAUSE ENGINE OVERHEATING. Read More »
SOME VEHICLES MAY EXHIBIT A HOOT NOISE AT IDLE COMING FROM THE INDUCTION SYSTEM. POSSIBLE ADDITIONAL SYMPTOMS MAY INCLUDE DIAGNOSTIC TROUBLE CODE P1506 AND A HIGHER THAN NORMAL IDLE. Read More »
OWNER NOTIFICATION PROGRAM REGARDING ADDITIONAL COVERAGE ON CERTAIN 4.6L SOHC INTAKE MANIFOLDS. SOME OF THE COMPOSITE INTAKE MANIFOLDS MAY DEVELOP FATIGUE CRACKS AT THE COOLANT CROSSOVER DUCT. Read More »
FORD/LINCOLN MERCURY: CERTAIN 1992-2001 MODEL YEAR CROWN VICTORIA, GRAND MARQUIS, AND TOWN CAR VEHICLES REGISTERED IN THE STATES OF WISCONSIN AND CONNECTICUT UPGRADE MODIFICATIONS FOR HIGH SPEED REAR IMPACTS. Read More »
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH
ON SOME VEHICLES, THE BRAKE SHIFT INTERLOCK MAY BE INOPERATIVE, NOW ALLOWING THE OPERATOR TO MOVE THE SHIFT LEVER FROM THE PARK POSITION. STOP LAMP OPERATION MAY ALSO BE AFFECTED. *TT Read More »
SOME POLICE AND TAXI VEHICLES MAY EXHIBIT EITHER UNDERBODY SHEETMETAL CRACKING IN THE DRIVESHAFT TUNNEL AT THE REAR SEAT KICKUP AND / OR DRIVESHAFT CONTACT WITH THE UNDERBODY. *TT Read More »
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT Read More »
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN ... Read More »
SOME VEHICLES MAY EXHIBIT A TURN SIGNAL FAST FLASH CONDITION WITH THE ENGINE RUNNING AND THE TEMPERATURE CONTROL BLOWER SPEED AT THE FULL HOT OR FULL COLD SETTING. *SLC Read More »
SOME VEHICLES EQUIPPED WITH A ONE-TOUCH DOWN MODULE OR A DRIVERS DOOR MOUDLE MAY EXHIBIT A CONDITION WHERE THE DRIVERS WINDOW MOVES DOWN WHEN ONE OF THE OTHER WINDOWS IS OPERATED. *TT Read More »
SOME VEHICLES BUILT 04/15/2000 OR EARLIER EQUIPPED WITH A KEYLESS ENTRY SYSTEM MAY EXHIBIT AN INOPERATIVE DOOR-MOUNTED KEYPAD, INTERIOR AND EXTERIOR LAMPS THAT SELF-ACTIVATE AND A WEAK OR DISCHARGED VEHICLE BATTERY. Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:WINDSHIELD:ELECTRICAL HEATING ELEMENT
ON SOME VEHICLES THE SEAT BELT MINDER INDICATOR WILL FLASH AND THE CHIME WILL SOUND IF THE VEHICLE IS DRIVEN WITH THE DRIVERS SEAT BELT NOT FASTENED. *TT Read More »
This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint ... Read More »
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Read More »
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Read More »
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Read More »
SOME VEHICLES MAY EXHIBIT STATIC NOISE THROUGH THE AUDIO SYSTEM SPEAKERS WITH THE RADIO TUNED TO THE AM BAND WHEN THE REAR WINDOW DEFROSTER IS OPERATING. *TT Read More »
EXHIBITING STATIC NOISE THROUGH THE AUDIO SYSTEM SPEAKERS WITH THE RADIO TUNED TO THE AM BAND WHEN THE REAR WINDOW DEFROSTER IS OPERATING. *TT Read More »
SOME VEHICLES MAY EXHIBIT STATIC NOISE THROUGH THE AUDIO SYSTEM SPEAKERS WITH THE RADIO TUNED TO THE LOWER AM BAND WHEN THE REAR WINDOW DEFROSTER IS OPERATING. *TT Read More »
SOME VEHICLES MAY EXHIBIT STATIC NOISE THROUGH THE AUDIO SYSTEM SPEAKERS WITH THE RADIO TUNED TO THE LOWER AM BAND WHEN THE REAR WINDOW DEFROSTER IS OPERATING. *MJS Read More »
SOME VEHICLES MAY EXHIBIT STATIC NOISE THROUGH THE AUDIO SYSTEM SPEAKERS WITH THE RADIO TUNED TO THE LOWER AM BAND WHEN THE REAR WINDOW DEFROSTER IS OPERATING. *MJS Read More »
SOME VEHICLES MAY EXHIBIT STATIC NOISE THROUGH THE AUDIO SYSTEM SPEAKERS WITH THE RADIO TUNED TO THE LOWER AM BAND WHEN THE REAR WINDOW DEFROSTER IS OPERATING. *TT Read More »
SOME VEHICLES BUILT BETWEEN AUGUST 1999 AND OCTOBER 1999 HAVE INCORRECT INFORMATION ABOUT THE BELTMINDER FEATURE IN THE OWNERS MANUAL. *MJS Read More »
LACK OF AIR CONDITIONER (A/C) COOLING AND RESTRICTED/REDUCED AIR FLOW THROUGH THE A/C VENTS TYPICALLY DURING EXTENDED IDLING CONDITIONS. *TT Read More »
EXPERIENCING A THUMP NOISE FROM THE AIR CONDITIONER SYSTEM APPROXIMATELY 5-10 SECONDS AFTER INITIAL AIR CONDITIONER COMPRESSOR ENGAGEMENT. *TT Read More »
SOME VEHICLES MAY EXHIBIT A THUMP NOISE FROM THE AIR CONDITIONER SYSTEM APPROXIMATELY 5-6 SECONDS AFTER INITIAL AIR CONDITIONER COMPRESSOR ENGAGEMENT. *TT Read More »
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »
CONCERNS WITH VEHICLES EXHIBITING THE OIL PRESSURE GAUGE REGISTERING LOW OR NO OIL PRESSURE USUALLY ON INITIAL START-UP AFTER SEVERAL HOURS OF COLD SOAK. *TT Read More »
SOME VEHICLES MAY PRODUCE A MALFUNCTION INDICATOR LAMP ILLUMINATED, ROUGH IDLE, A CHECK ENGINE LIGHT, AND DIAGNOSTIC TROUBLE CODES (DTCS) P0350 - P0360 STORED IN MEMORY. *TT Read More »
INCORRECT INFORMATION ABOUT THE BELTMINDER FEATURE IN THE OWNER'S MANUAL. THE MANUAL INCORRECTLY DESCRIBES THE BELTMINDER FEATURE AS BEING DEPENDENT ON VEHICLE MOTION. Read More »
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT Read More »
