Technical Service Bulletins (TSBs) for the 1999 Crown Victoria are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
ON SOME VEHICLES THE REAR SUSPENSION UPPER CONTROL ARM BRACKETS ON THE FRAME MAY DEVELOP MINOR CRACKS WHEN SUBJECTED TO SEVERE DUTY SERVICE. *JB Read More »
SUBJECT PERTAINING TO COSMETIC CRACKS IN FRAME AT THE REAR UPPER CONTROL ARM ACCESS OPENING WHEN SUBJECTED TO SEVERE DUTY OPERATING CONDITIONS. *JB Read More »
SOME VEHICLES EQUIPPED WITH TEVES FOUR WHEEL ANTI-LOCK BRAKES (4WABS) MAY EXHIBIT A YELLOW ANTI-LOCK BRAKE LAMP ILLUMINATED WITH NO DIAGNOSTIC TROUBLE CODES IN MEMORY. *TT Read More »
ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. Read More »
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. Read More »
SOME DEDICATED CNG VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS DUE TO A LOSS OF INJECTOR PERFORMANCE, RESULTING FROM FUEL QUALITY. Read More »
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. Read More »
VEHICLES BUILT UP TO DECEMBER OF 1999 MAY EXHIBIT A CLUNK NOISE FROM THE REAR OF THE VEHICLE WHEN DRIVING OVER SPEED BUMPS. THIS MAY BE CAUSED BY THE FILL-LIMITING VALVE INSIDE THE FUEL TANK. Read More »
ON SOME VEHICLES, THE ENGINE MOUNTS MAY NOT EXHIBIT SATISFACTORY DURABILITY UNDER SEVERE OPERATING CONDITIONS THAT MAY BE ENCOUNTERED BY POLICE, TAXI OR LIMO / LIVERY VEHICLES SUCH AS EXTENDED IDLING AT HIGH AMBIENT TEMPERATURES. Read More »
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »
SOME VEHICLES EQUIPPED WITH THE ROMEO BUILT 4.6L 2V ENGINE MAY EXHIBIT AN ENGINE OIL LEAK OR OIL WEEPAGE FROM THE CYLINDER HEAD GASKET AT THE RIGHT HAND REAR OR THE LEFT HAND FRONT OF THE ENGINE. Read More »
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT Read More »
SOME CROWN VICTORIA POLICE VEHICLES ENGINE MAY STALL DURING BRAKING OVER RUMBLE STRIPS, THESE VIBRATIONS MAY OPEN THE INERTIA FUEL SWITCH. *MJS Read More »
ON SOME VEHICLES, THE ENGINE MAY BE OVERFILLED WITH OIL. THIS MAY BE CAUSED BY MISINTERPRETATION OF THE OIL LEVEL INDICATOR (DIPSTICK) MARKINGS. *TT Read More »
SOME VEHICLES MAY EXHIBIT AN EXHAUST MOAN / ROAR HEARD ON SLIGHT ACCELERATION AND AT SPEEDS NEAR 42 MPH FOR SINGLE EXHAUST AND NEAR 62 MPH ON DUAL EXHAUST CARS. *TT Read More »
FORD: CERTAIN 1999-2001 MODEL YEAR VEHICLES UP TO 6000 LB GVWR REGISTERED IN NEW YORK AND CERTAIN 2001 VEHICLES UP TO 6000 LB GVWR REGISTERED IN THE STATE OF MAINE, CERTIFIED FOR SALE IN CALIFORNIA-FEDERAL EMISSION WARRANTY REFUND. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
EXTENDED COVERAGE PROGRAM 05N04 - EXTENDED COVERAGE FOR COMPOSITE INTAKE MANIFOLD. THIS PROGRAM IS BEING PROVIDED AS A SETTLEMENT TO A CLASS ACTION LAWSUIT. Read More »
FORD/LINCOLN MERCURY: CERTAIN 1992-2001 MODEL YEAR CROWN VICTORIA, GRAND MARQUIS, AND TOWN CAR VEHICLES REGISTERED IN THE STATES OF WISCONSIN AND CONNECTICUT UPGRADE MODIFICATIONS FOR HIGH SPEED REAR IMPACTS. Read More »
VEHICLES BUILT UP TO DECEMBER OF 1999 MAY EXHIBIT A CLUNK NOISE FROM THE REAR OF THE VEHICLE WHEN DRIVING OVER SPEED BUMPS. THIS MAY BE CAUSED BY THE FILL-LIMITING VALVE INSIDE THE FUEL TANK. Read More »
SOME POLICE VEHICLES MAY STALL DURING BRAKING OVER RUMBLE STRIPS. THESE VIBRATIONS MAY OPEN THE INERTIA FUEL SWITCH. ENGINEERING IS INVESTIGATING CONCERN. *TT Read More »
SOME OF THE COMPOSITE INTAKE MANIFOLDS USED ON 4.6L SOHC ENGINES MAY DEVELOP FATIGUE CRACKS AT THE COOLANT CROSSOVER DUCT. THIS CONDITION COULD RESULT IN ENGINE COOLANT LEAKAGE WHICH, IF NOT SERVICED, MAY CAUSE ENGINE OVERHEATING. Read More »
OWNER NOTIFICATION PROGRAM REGARDING ADDITIONAL COVERAGE ON CERTAIN 4.6L SOHC INTAKE MANIFOLDS. SOME OF THE COMPOSITE INTAKE MANIFOLDS MAY DEVELOP FATIGUE CRACKS AT THE COOLANT CROSSOVER DUCT. Read More »
FORD/LINCOLN MERCURY: CERTAIN 1992-2001 MODEL YEAR CROWN VICTORIA, GRAND MARQUIS, AND TOWN CAR VEHICLES REGISTERED IN THE STATES OF WISCONSIN AND CONNECTICUT UPGRADE MODIFICATIONS FOR HIGH SPEED REAR IMPACTS. Read More »
EMISSION RECALL FOR VEHICLES THAT WERE BUILT WITH A FUEL FILLER-VALVE WHICH COULD LEAK WHILE THE VEHICLE IS BEING OPERATED WHICH CAN EXCEED EVAPORATIVE EMISSIONS STANDARDS. *TT Read More »
SONE POLICE VEHICLES AND OTHER VEHICLES WITH 4R70W MAY EXHIBIT A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE FROM SUSTAINED HIGH SPEED OPERATION. *TT Read More »
INFORMATION ON USING THE SERVICE BAY TECHNICAL SYSTEM (SBTS) AND NEW GENERATION STAR (NGS) TESTER, AND TO UPDATE THE POWERTRAIN CONTROL MODULE (PCM) INFORMATION CHARTS. *TT Read More »
SUBJECT REGARDING ALL VEHICLES REQUIRES A PARAMETER RESET TO BE PERFORMED ON THE PASSIVE ANTI-THEFT SYSTEM MODULE (PATS / VIC / HEC) WHEN THE POWERTRAIN CONTROL MODULE (PCM) IS REPLACED. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH
ON SOME VEHICLES, THE BRAKE SHIFT INTERLOCK MAY BE INOPERATIVE, NOW ALLOWING THE OPERATOR TO MOVE THE SHIFT LEVER FROM THE PARK POSITION. STOP LAMP OPERATION MAY ALSO BE AFFECTED. *TT Read More »
SOME POLICE AND TAXI VEHICLES MAY EXHIBIT EITHER UNDERBODY SHEETMETAL CRACKING IN THE DRIVESHAFT TUNNEL AT THE REAR SEAT KICKUP AND / OR DRIVESHAFT CONTACT WITH THE UNDERBODY. *TT Read More »
SONE POLICE VEHICLES AND OTHER VEHICLES WITH 4R70W MAY EXHIBIT A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE FROM SUSTAINED HIGH SPEED OPERATION. *TT Read More »
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC Read More »
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN ... Read More »
SOME VEHICLES EQUIPPED WITH A ONE-TOUCH DOWN MODULE OR A DRIVERS DOOR MOUDLE MAY EXHIBIT A CONDITION WHERE THE DRIVERS WINDOW MOVES DOWN WHEN ONE OF THE OTHER WINDOWS IS OPERATED. *TT Read More »
SOME VEHICLES BUILT 04/15/2000 OR EARLIER EQUIPPED WITH A KEYLESS ENTRY SYSTEM MAY EXHIBIT AN INOPERATIVE DOOR-MOUNTED KEYPAD, INTERIOR AND EXTERIOR LAMPS THAT SELF-ACTIVATE AND A WEAK OR DISCHARGED VEHICLE BATTERY. Read More »
SOME VEHICLES EQUIPPED WITH A KEYLESS ENTRY SYSTEM, MAY EXHIBIT A CONDITION WHERE ALL THE KEYLESS ENTRY FUNCTIONS ARE INOPERATIVE, INCLUDES REMOTE KEY FOB'S , POWER DOOR LOCKS, EXPRESS DOWN WINDOW AND REMOTE TRUNK RELEASE, VEHICLES BUILT ... Read More »
SOME VEHICLES BUILT IN JUNE 1999, MAY EXHIBIT THE AUTOLOCK FEATURE INOPERATIVE OR THE RADIO BUTTON ILLUMINATION / DIMMING FEATURE INOPERATIVE. *TT Read More »
EXHIBITING AN INTERMITTENT CONCERN WHERE THE WINDOW ONE TOUCH DOWN FEATURE WILL OPERATE FROM WINDOW SWITCH LOCATIONS OTHER THAN THE DRIVER'S DOOR. *TT Read More »
SOME VEHICLES MAY EXPERIENCE A CONDITION WHERE ALL THE KEYLESS ENTRY FUNCTIONS ARE INOPERATIVE (I.E., KEY FOBS, POWER DOOR LOCKS, EXPRESS DOWN WINDOW, AND REMOTE TRUNK RELEASE). *TT Read More »
SOME VEHICLES MAY DEVELOP COSMETIC CRACKS IN THE FRAME AT THE REAR UPPER CONTROL ARM ACCESS OPENING WHEN OPERATED UNDER SEVERE DUTY CONDITIONS. *TT Read More »
SOME VEHICLES BUILT BEFORE JANUARY 1, 1999 AND EQUIPPED WITH A KEYLESS ENTRY SYSTEM, MAY EXHIBIT A CONDITION WHERE ALL THE KEYLESS ENTRY FUNCTIONS ARE INOPERATIVE. *MJS Read More »
FOR ALL VEHICLES WITH DRIVERS DOOR MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING. *TT Read More »
SOME VEHICLES MAY EXPERIENCE A LIGHT SPARK KNOCK / DETONATION OCCURRING WHILE ACCELERATING IN AMBIENT TEMPERATURES GREATER THAN 32 DEGREES C (90 DEGREES F). *TT Read More »
SOME POLICE VEHICLES, EQUIPPED WITH FULL SIZE WHEEL COVERS, MAY EXHIBIT A CONCERN WITH THE WHEEL COVERS BECOMING LOOSE AFTER BEING REMOVED AND REPLACED SEVERAL TIMES. *TT Read More »
SOME POLICE VEHICLES, EQUIPPED WITH FULL SIZE WHEEL COVERS, MAY EXHIBIT A CONCERN WITH THE WHEEL COVERS BECOMING LOOSE AFTER BEING REMOVED AND REPLACED SEVERAL TIMES. *TT Read More »
SOME POLICE VEHICLES, EQUIPPED WITH FULL SIZE WHEEL COVERS, MAY EXHIBIT A CONCERN WITH THE WHEEL COVERS BECOMING LOOSE AFTER BEING REMOVED AND REPLACED SEVERAL TIMES. *TT Read More »
SUBJECT REGARDING POLICY VEHICLES EQUIPPED WITH FULL SIZE WHEEL COVERS EXHIBITING A CONCERN WITH THE WHEEL COVERS BECOMING LOOSE AFTER BEING REMOVED AND REPLACED SEVERAL TIMES. *TT Read More »
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT Read More »
SUBJECT PERTAINING TO THE SERVICE MANUAL NOT HAVING A PINPOINT TEST FOR "DEGRADED AM RECEPTION OR CONTINUOUS SEEK IN AM" IN THE DIAGNOSIS AND TESTING PORTION OF THE AUDIO CHAPTER. *TT Read More »
EXPERIENCING A THUMP NOISE FROM THE AIR CONDITIONER SYSTEM APPROXIMATELY 5-10 SECONDS AFTER INITIAL AIR CONDITIONER COMPRESSOR ENGAGEMENT. *TT Read More »
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »
CONCERNS WITH VEHICLES EXHIBITING THE OIL PRESSURE GAUGE REGISTERING LOW OR NO OIL PRESSURE USUALLY ON INITIAL START-UP AFTER SEVERAL HOURS OF COLD SOAK. *TT Read More »
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT Read More »
VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. Read More »
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. Read More »
