Anytime I put a half a tank in gas in car it smells bad in truck so when this does happen I look in the truck, there's this foam in the back that's co bed with gas, N the small is bad.I don't let me kids in the gas, ntil its gone..will it catch in 🔥.it happens all the time since I bought the car.help plz

- Ft Mccoy, FL, USA

Under normal driving conditions at approximately 25 mph I began to smell a sweet burning scent that I quickly recognized as coolant. I pulled over & inspected the engine compartment. The first thing I observed after removing the plastic facia from the top of the engine was a crack in the water temperature sensor housing right in front on the top passenger side of the intake manifold. I was less than a block from my home so I drove home and had it towed into harvey's auto the next day. [xxx] has told me that there was a recall on this intake manifold and as the original owner I should have been notified about this recall. I was never informed of any recalls. [xxx] placed a temporary weld which has held up just fine, however he said that there are several other issues with the structural integrity of Ford original design and that ultimately the manifold will fail at these weak points with time. I don't put heavy miles on my vehicle & only have 41,102 miles on it now. All services have been performed at 3000 mile intervals from authorized mechanics. I have all receipts of my service records and feel that the only reason I didn't experience a failure earlier is because of my diligent efforts to follow the recommended service intervals set forth in the vehicles maintenance log. I feel that it was and still is the responsibility of Ford to seek out all owners until each vehicle has been repaired. The of recall expired in 2009 according to Ford customer service but I feel that there should have been more effort by Ford motors to inform all owners of this defect. I would appreciate it if Ford would accept responsibility for selling a known faulty item and extend and honor their original recall reparations for my vehicle. I did my part in following all service requirements and they should as well. Thank you for your assistance and time. Information redacted pursuant to the Freedom Of Information Act (FOIA), 5 U.S.C. 552(B)(6).

- Corona, CA, USA

My parents picked my daughter up from the school bus and proceeded down my driveway slowly. The vehicle suddenly accelerated even as my father had both feet on the brake. There were visible signs of the front wheels dragging up debris as the front wheels were locking up. He attempted to shift into neutral and turn the key but was unable to do so as the vehicle must have reached a speed in excess of 50 mph before he slammed it into park and then ran head on into a tree. Both parent were injured severely even with the air bags deploying. The car was destroyed.

- Conowingo, MD, USA