Is your defective Ford Bronco actually a LEMON?

Find out in 30 SECONDS or less if it qualifies for a REFUND or a CASH SETTLEMENT.

Print this page

9.6

really awful
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
936 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2023 Ford Bronco engine problems

engine problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2023 Ford Bronco:

Unsubscribe any time. We don't sell/share your email.

2023 Ford Bronco Owner Comments

problem #14

Jun 012023

Bronco

  • miles

A D V E R T I S E M E N T S

My engine has had a knocking problem since 3000 miles. Everytime I take it to Ford they agreed it has a knock but won't fix the problem stating it's normal and some engine knock more than others. The engine knocks at low rpm when stepping on the accelerator then smooths out about 1500 to 2000 rpm. One mechanic said it's an issue but they won't fix it unless it has a catastrophic failure this is unacceptable to me as they just want the vehicle to fall out of warranty when the engine finally gives way and doesn't turn on anymore. There are multiple Ford vehicles that have this issue and Ford does not seem to look into it and fix it please investigate the issues with knocking on all the Ford vehicles with the EcoBoost engines.

- Glendale, CA, USA

problem #13

Nov 082024

Bronco

  • miles
My vehicle has the 2.7L V6 Ecoboost engine. This engine apparently has a design defect that results in repeated cam phaser failure. My engine recently had cam phaser failure and I had them replaced. A week later I was driving at speed on a highway when my engine completely died. I had to pull to the side of the road and could not restart my engine. I ended up being towed to a dealership and am awaiting diagnosis.

- Edwards, CO, USA

problem #12

Oct 032024

Bronco

  • miles
We installed new tires and wheels on our vehicle and it immediately started having engine problems and the check engine light comes on. We took it to the dealer and after several days back and forth Ford told the deal that it's a known problem with the 2.3L version of the Ford Bronco however they had no fix and no timeline to fix the problem. This creates a safety hazard as the engine program can't be updated and could cause damage to the engine and cause it to fail. The dealer then stated that they could not return the vehicle to us with the new tires and wheels we purchased and we had to put our old tires and wheels on. We counted on the old tires for a spare since we already blew one tire out. So in addition to a safety hazard we are currently out $2,500 we spent on new tires and wheels, and now have to purchase another tire of the exact same original size to have a spare, costing us another $300.

- Boerne, TX, USA

problem #11

Apr 192024

Bronco

  • miles

A D V E R T I S E M E N T S

When driving or breaking at slower speeds, the car feels as if the transmission is -??slipping-?? and the car jerks forward. The same thing happens when braking the car.

- Apopka, FL, USA

problem #10

Mar 242024

Bronco

  • miles
My 2023 Bronco with 6k miles died without any warning back in late January 2024. Ford service dept said it was a failed catalytic converter. After it was in the shop for a 1.5 months, waiting on the back ordered part, we picked up our truck around March 10. Fast forward to today, truck has 7k miles. We were southbound on the interstate in bumper to bumper traffic heading to Disney World when the truck-??s engine died, yet again. Luckily we were not traveling typical interstate speed and we safely maneuvered the vehicle to the side of the road and contacted Ford roadside assistance and a tow truck was quickly dispatched. The truck is currently sitting at a Ford dealership on a Sunday, 485 miles from home and a lot of money tied up in our vacation plans. Just thankful nobody was hurt, but waiting for this to happen a third time just to file a lemon law is reckless to customers and everyone else on the road, for that matter.

- Wetumpka, AL, USA

problem #9

Jan 052023

Bronco

  • miles
I have a 2023 Ford bronco that has the 2.3 L engine and seven speed manual transmission. It was originally purchased in January 2023. I live in Colorado so it is cold and on cold mornings, since I have received delivery of the vehicle, It has made and continues to make a grinding, scraping sound when the vehicle is in neutral, or the transmission is not engaged. The grinding, scraping sound will occur when driving in first, second, and third gear. If the weather is warm, as over last summer, it does not make the grinding, scraping sound. It has been consistently documented amongst other owners of this particular vehicle, the new sixth generation Ford bronco full-size vehicle with the 2.3 L engine and seven speed manual transmission, that these transmissions make this grinding, scraping sound. I have had it investigated by my local Ford dealership on two separate occasions, and although the tech on site at the dealership states that he can hear the grinding sound and agrees that it is an abnormal sound for a vehicle transmission to make, the Ford motor company has refused to do any type of repair or modification, or replacement of the transmission in my particular vehicle to correct the problem. However, when discussing this problem with other Ford bronco owners, Ford motor company-??s response has been very irregular, one friend, in particular, has had his transmission replaced. I am very concerned that as transmissions tend to suffer with wear and tear, that should this transmission fail early due to the grinding, scraping sound, ford motor company will not replace it under warranty, stating that it was my fault or expected wear and tear, that the transmission failed early, when, in reality, it is just as likely that the early failure would be due to this abnormal, grinding, scraping sound.

- Fort Collins, CO, USA

problem #8

Mar 052024

Bronco

  • miles

A D V E R T I S E M E N T S

While driving the vehicle began to misfire and became unsafe to drive. It was towed to the local dealer where error codes confirmed that cylinder 4 had misfired. Ford was unable to duplicate the issue nor where they able to find any issues that would have caused the misfire after trouble shooting.

- Cedarburg , WI, USA

problem #7

Jan 232024

Bronco

  • miles
I was driving uphill in a neighborhood going about 15 mph when my Bronco suddenly lost power. I was not able to restart and had to manually restart the truck using the fob to ignition method. It started back up, but a terrible sulfur smell was coming from the vehicle. I brought it into our nearest Ford dealership and they claimed there was nothing they could do because no code was reported from the truck. I continued to drive it for another day and the check engine light came on. My Ford Pass relayed a message claiming that the issue was the catalytic converter. I took it to my Ford dealership who claims this could take months to fix because the parts are on back order. My 2023 Ford Bronco, 2.7 liter V6 had less than 6k miles.

- Wetumpka, AL, USA

problem #6

Nov 152023

Bronco

  • miles
Engine service light came on indicating reduced power/power failure. Called Ford dealership and they said to bring it in asap. After diagnosis the Ford dealership said there was a problem with the wastegate. The dealership has no eta on when the part will be available.

- Cumming, GA, USA

problem #5

Jul 272023

Bronco

  • 12,000 miles
The contact owns a 2023 Ford Bronco. The contact stated that while driving at 70 MPH and attempting to brake, the brake pedal traveled all the way to the floorboard and all the lights had flashed on the instrument panel. The contact stated that after restarting the vehicle the entire dashboard shook uncontrollably. Several unknown warning lights were illuminated. The vehicle was towed to a dealer to be diagnosed. The contact was informed that the failure was due to a faulty cam phaser. The vehicle had not been repaired. The manufacturer was made aware of the failure and determined that the VIN was not included in a recall. The failure mileage was approximately 12,000

- Dayton, OH, USA

problem #4

Jun 052023

Bronco

  • 1,100 miles

A D V E R T I S E M E N T S

The contact owns a 2023 Ford Bronco. The contact stated while driving 65 MPH, the power train and service engine soon had warning lights illuminated. The vehicle was taken to the dealer to be diagnosed. The contact was informed that there was bad gasoline in the vehicle, and gasoline needed to be drained from the fuel tank. The fuel tank was drained and refilled; however, the failure recurred. The vehicle was taken to another dealer and diagnosed with a faulty turbocharger. The contact was informed that the turbocharger needed to be replaced. The vehicle was repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 1,100.

- Burbank, CA, USA

problem #3

Jun 022023

Bronco

  • miles
My engine in 2023 Ford Bronco with approximately 2900 miles failed in lunch time traffic. The dealership is saying they have to order me a new engine. This is borderline criminal.

- Cecil, AL, USA

problem #2

May 012023

Bronco

  • miles
We have had two major issues with this new Vehicle. It has less 1,872 miles on it and it is only about 2 months old. Within a week of owning it, the stabilizer bar went out and render the vehicle un drive able. We have a second issue that is even larger safety issue. The Vehicle is now dying and leaving you stranded on the side of the road. We have now had this happened to us three times on separate occasions. Once was on a trip back from Oklahoma to Dallas and the highway is under repair/construction and there are miles that there are only two lanes with no shoulder or exit to get off in case of auto problems. We found ourself at night that our Bronco lost total power and would not start back up. The vehicle has some kind of timer that will allow you to attempt to start it so many times in a period and then disable the ability to crank the engine. It gives you an error of "Cranking Time Exceeded" So where ever you are "Stuck on the highway in traffic, off the road on in your driveway, you will not be able to attempt to restart your motor if you exceed this time limit. This is a very dangerous issue and I feel many people could lose their life if they are in an situation where they can not attempt to start their motor and try to move to a safer location if the engin can be restarted.

- Plano, TX, USA

problem #1

Mar 272023

Bronco

  • miles
While at a stop with vehicle running, the vehicle sputters and stalls when trying to accelerate/start moving. This has happened multiple times when stopped at an intersection and creating a safety hazard for the occupants of the vehicle. Multiple attempts to restart it have to be made and it eventually gets going again but this is very dangerous to be stalled at a busy intersection. Vehicle is going into the dealer to be checked out this week. The only message we have seen is "Manual Restart Required" on the instrument panel.

- East Walpole, MA, USA

Not what you are looking for?