Technical Service Bulletins (TSBs) for the 2004 Ram 2500 are official communications between Dodge & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
If replacing the steering linkage or drag link inner tie rod assembly at the pitman arm on a vehicle built before Febuary 14 th, 2008, verify that the pitman arm part number is 68039930AA. The part number is embossed on the pitman arm. Read More »
DODGE: BULLETIN PROVIDING ALIGNMENT PROCEDURES FOR TIE ROD BALL STUD HOUSING FOR THE RIGHT AND LEFT. MODEL YRS FOR CAB CHASSIS (REG AND MEGA PICKUPS AND 4X4) 2003-2011. *PE Read More »
If replacing the steering linkage or drag link inner tie rod assembly at the pitman arm on a vehicle built before Febuary 14 th, 2008, verify that the pitman arm part number is 68039930AA. The part number is embossed on the pitman arm. Read More »
Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Read More »
Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Read More »
68069384A$, R8069384A$, 68086182A$, R8027067A$, RL002012A$ - Gasket, Cylinder Head Cover Before replacing injectors for Diagnostic Trouble Codes P0201, P0202, P0203, P0204, P0205, and/or P0206, please make sure that the wiring loom ... Read More »
GENERIC CUMMINS ENGINE CONTROL MODULE (PCM) PROCEDURE. *TT THIS BULLETIN REPLACED 18-030-03. *TT THIS BULLETIN REPLACED 18-030-03A DATED 10/17/03. TO ALSO INCLUDE 2005 RAM TRUCK. *TT Read More »
SOME TRUCKS EQUIPPED WITH CUMMINS DIESEL ENGINES WERE BUILT WITH ENGINE BLOCK FREEZE PLUGS, WHICH MAY NOT HAVE SUFFICIENT INTERFERENCE FIT TO THE BLOCK. *TT Read More »
THE CAMSHAFT SPROCKET RETAINING BOLTS MAY NOT HAVE BEEN PROPERLY TIGHTENED. A LOOSE CAM SPROCKET BOLT CAN BACK OUT AND CAUSE SIGNIFICANT ENGINE DAMAGE. CUSTOMER SATISFACTION NOTIFICATION NO. D19. Read More »
DODGE: ELECTRONIC FUEL CONTROL ACTUATOR (FCA) AVAILABLE FOR SERVICE/NEW DIAGNOSTICS AVAILABLE FOR DTC P0251. ENGINE SURGES AT IDLE OR MIL ILLUMINATION. FURTHER INVESTIGATION MAY IDENTIFY DTC P0251-CP3 PUMP REGULATOR CONTROL-DIESEL. Read More »
SOME TRUCKS EQUIPPED WITH THE NEW HIGH OUTPUT DIESEL ENGINE MAY HAVE BEEN BUILT WITH EXHAUST CLAMPS WITH WELDS THAT COULD CRACK AND SEPARATE. RAPID RESPONSE TRANSMITTAL 04-001. *TT Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
DODGE: ELECTRONIC FUEL CONTROL ACTUATOR (FCA) AVAILABLE FOR SERVICE/NEW DIAGNOSTICS AVAILABLE FOR DTC P0251. ENGINE SURGES AT IDLE OR MIL ILLUMINATION. FURTHER INVESTIGATION MAY IDENTIFY DTC P0251-CP3 PUMP REGULATOR CONTROL-DIESEL. Read More »
CUSTOMER SATISFACTION NO. C44. TRANSMISSION COOLER LINE ON CERTAIN VEHICLES CAN TRANSMIT HIGH PRESSURE PULSES WHEN THE VEHICLE IS OPERATED AT HEAVY LOADS. *TT Read More »
THE AXLES ARE LOCATED CONSIDERABLY HIGHER THAT THE ACTUAL FLUID LEVEL. FILLING THE AXLE UNTIL THE FLUID COMES OUT OF THE FILL HOLE WILL OVER FILL THE AXLE, WHICH COULD CAUSE FLUID FOAMING. Read More »
CERTAIN 2004 TRUCKS EQUIPPED 8-1/4 IN. OR 9-1/4 IN. REAR AXLES MAY HAVE BEEN BUILT WITH CONTAMINATED AXLE FLUID. RAPID RESPONSE TRANSMITTAL. *TT Read More »
CERTAIN 2004 TRUCKS EQUIPPED 8-1/4 IN. OR 9-1/4 IN. REAR AXLES MAY HAVE BEEN BUILT WITH CONTAMINATED AXLE FLUID. RAPID RESPONSE TRANSMITTAL SUPPLEMENT A. *TT Read More »
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are ... Read More »
56045489A$ - Neutral Safety Switch - Trans Assy 06036369AA Screw and Washer is now available as a service part , 2 required to attach Neutral Start Switch Read More »
68069384A$, R8069384A$, 68086182A$, R8027067A$, RL002012A$ - Gasket, Cylinder Head Cover Before replacing injectors for Diagnostic Trouble Codes P0201, P0202, P0203, P0204, P0205, and/or P0206, please make sure that the wiring loom ... Read More »
56045489A$ - Neutral Safety Switch - Trans Assy 06036369AA Screw and Washer is now available as a service part , 2 required to attach Neutral Start Switch Read More »
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. Read More »
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. Read More »
56045489A$ - Neutral Safety Switch - Trans Assy 06036369AA Screw and Washer is now available as a service part , 2 required to attach Neutral Start Switch Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. Read More »
Part Description: Insulator in Lever Assembly - Valve Body - Trans Issue Description: The manual valve insulator, attaching rivet and an instruction sheet are now available as a kit. Read More »
MUD OR DIRT MAY ACCUMULATE ON THE ROCKER PANEL CAUSING CUSTOMERS TO COMPLAIN THAT THEIR CLOTHING GETS DIRTY WHEN THEY ENTER OR EXIT THE VEHICLE. *TT Read More »
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are ... Read More »
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Part Description: Insulator in Lever Assembly - Valve Body - Trans Issue Description: The manual valve insulator, attaching rivet and an instruction sheet are now available as a kit. Read More »
68069384A$, R8069384A$, 68086182A$, R8027067A$, RL002012A$ - Gasket, Cylinder Head Cover Before replacing injectors for Diagnostic Trouble Codes P0201, P0202, P0203, P0204, P0205, and/or P0206, please make sure that the wiring loom ... Read More »
THE CERTIFICATION LABEL ON CERTAIN VEHICLES COMPLIES WITH FEDERAL REGULATIONS, BUT DOES NOT LIST THE MINIMUM TIRE/RIM SIZE AND INFLATION PRESSURE INFORMATION. CUSTOMER SATISFACTION NOTIFICATION NO. D23. Read More »
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington ... Read More »
