Technical Service Bulletins (TSBs) for the 1999 Caravan are official communications between Dodge & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
EXPERIENCING A KNOCKING / CLUNKING SOUND COMING FROM THE FRONT SWAY BAR LINK HEARD INSIDE AND OUTSIDE THE VEHICLE WHEN DRIVING OVER ROUGH ROADS. *TT Read More »
ON SOME VEHICLES, WHILE DRIVING THROUGH DEEP OR BLOWING SNOW / WATER, THE SNOW / WATER MAY ENTER THE REAR BRAKE DRUMS CAUSING RUST TO DEVELOP ON THE REAR BRAKE DRUM AND SHOE FRICTION SURFACES. Read More »
A CONDITION MAY EXIST WHERE A LOW FREQUENCY HOWL / MOAN NOISE IS HEARD FROM THE REAR BRAKE AREA DURING LOW SPEED AND / OR LOW SPEED TURNS SUCH AS A PARKING LOT MANEUVER, WITH NO BRAKE PEDAL PRESSURE APPLIED. Read More »
Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Read More »
RIGHT SIDE HALF SHAFT CV BOOT IS MADE OF A SPECIAL HIGH TEMPERATURE RESISTANT MATERIAL THAT CAN SHOW HEAVY GREASE SEPAGE-ENOUGH TO FORM DROPLETS ON THE BOOT CONVOLUTES. *AK Read More »
RIGHT SIDE HALF SHAFT CV BOOT IS MADE OF A SPECIAL HIGH TEMPERATURE RESISTANT MATERIAL THAT CAN SHOW HEAVY GREASE SEPAGE-ENOUGH TO FORM DROPLETS ON THE BOOT CONVOLUTES. *AK Read More »
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are ... Read More »
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. Read More »
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. Read More »
COSMETIC CORROSION OR PERFORATION AT UPPER STRUT TOWER/S USUALLY BETWEEN THE STRUT AND UPPER LOAD PATH BEAM INNER PANEL (INNER FENDER). *TT Read More »
A CONDITION EXIST WHERE THE ROOF PANEL SURFACE EXHIBITS WAVINESS OR DEPRESSION(S) NEAR THE FRONT OF THE CHARACTER FEATURES OR SKID STRIP FOR ROOF RACK EQUIPPED VEHICLES. *TT Read More »
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are ... Read More »
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Child Seat Tether Anchor Installation This bulletin describes procedures to install Child Seat Tether Anchors based on Customer Request. Retrofits are subject to part availability. Read More »
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. Read More »
SERVICE ACTION REGARDING AN INCORRECT VEHICLE EMISSIONS CONTROL INFORMATION (VECI) AND MONRONEY LABELS INSTALLED ON VEHICLES EQUIPPED WITH CALIFORNIA EMISSION. *TT Read More »
Child Seat Tether Anchor Installation This bulletin describes procedures to install Child Seat Tether Anchors based on Customer Request. Retrofits are subject to part availability. Read More »
SOME VEHICLES MAY EXHIBIT INTERMITTENT MALFUNCTION INDICATOR LIGHT (MIL) ILLUMINATION WITH HEX CODE $1B (P0123) THROTTLE POSITION SENSOR (TPS) VOLTAGE HIGH. *TT Read More »
