Technical Service Bulletins (TSBs) for the 1997 Caravan are official communications between Dodge & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
DURING HIGH HUMIDITY CLIMATE CONDITIONS, SOME VEHICLES MAY EXPERIENCE A MOMENTARY LOSS OF POWER ASSIST FOR THE STEERING WHEN TURNING CORNERS WITH THE A/C OR DEFROST Read More »
ON SOME VEHICLES, WHILE DRIVING THROUGH DEEP OR BLOWING SNOW / WATER, THE SNOW / WATER MAY ENTER THE REAR BRAKE DRUMS CAUSING RUST TO DEVELOP ON THE REAR BRAKE DRUM AND SHOE FRICTION SURFACES. Read More »
A CONDITION MAY EXIST WHERE A LOW FREQUENCY HOWL / MOAN NOISE IS HEARD FROM THE REAR BRAKE AREA DURING LOW SPEED AND / OR LOW SPEED TURNS SUCH AS A PARKING LOT MANEUVER, WITH NO BRAKE PEDAL PRESSURE APPLIED. Read More »
CONDITION WITH UNDERHOOD NOISE DUE TO SERPENTINE BELT OUTBOARD RIBS FRAYING OR SPLITTING FROM THE MAIN PORTION OF THE BELT AND COTACTING OTHER ENGINE COMPONENTS. *YC Read More »
VEHICLES BUILT ON OR AFTER NOV 6, 1996 (MDH 1106XX) HAVE TWO 1/4IN FOAM PADS ATTACHED TO THE TOP OF THE FUEL TANK, ONE AT THE FRONT AND ONE AT THE REAR. *JD Read More »
CONDITION WITH TRANAXLE SHUDDER DURING A 3RD GEAR TO 3RD GEAR PARTIAL EMCC ( ELECTRONICALLY MODULATED CONVERTER CLUTCH) ENGAGEMENT, 3RD GEAR PARTIAL EMCC TO 4TH GEAR PARTIAL EMCC ENGAGEMENT, OR 4TH GEAR TO 4TH GEAR EMCC ENGAGEMENT. Read More »
THIS BULLETIN INVOLVES VIBRATION/DRONE AT ALL VEHICLE SPEEDS AND/OR SLIGHT JERK DURING INITIAL ACCELERATION AND/OR COMING TO A FULL STOP. *NLM Read More »
RIGHT SIDE HALF SHAFT CV BOOT IS MADE OF A SPECIAL HIGH TEMPERATURE RESISTANT MATERIAL THAT CAN SHOW HEAVY GREASE SEPAGE-ENOUGH TO FORM DROPLETS ON THE BOOT CONVOLUTES. *AK Read More »
RIGHT SIDE HALF SHAFT CV BOOT IS MADE OF A SPECIAL HIGH TEMPERATURE RESISTANT MATERIAL THAT CAN SHOW HEAVY GREASE SEPAGE-ENOUGH TO FORM DROPLETS ON THE BOOT CONVOLUTES. *AK Read More »
INFORMATION ON DIAGNOSTIC / DRIVEABILITY IMPROVEMENTS, TRANSAXLE THAT INCORPORATES A TRANSMISSION RANGE SENSOR (TRS) ONLY. REDUCES A SHUDDER CONDITION THAT MAY BE EXPERIENCED DURING LIGHT THROTTLE 1-2 UPSHIFT. Read More »
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are ... Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. Read More »
COSMETIC CORROSION OR PERFORATION AT UPPER STRUT TOWER/S USUALLY BETWEEN THE STRUT AND UPPER LOAD PATH BEAM INNER PANEL (INNER FENDER). *TT Read More »
A CONDITION EXIST WHERE THE ROOF PANEL SURFACE EXHIBITS WAVINESS OR DEPRESSION(S) NEAR THE FRONT OF THE CHARACTER FEATURES OR SKID STRIP FOR ROOF RACK EQUIPPED VEHICLES. *TT Read More »
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are ... Read More »
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Child Seat Tether Anchor Installation This bulletin describes procedures to install Child Seat Tether Anchors based on Customer Request. Retrofits are subject to part availability. Read More »
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. Read More »
CHILD SAFETY SEAT VIDEO AND HARNESS CLIPS FOR MINIVANS EQUIPPED WITH INTEGRATED CHILD SEATS. SOME OWNERS EXPERIENCED DIFFICULTY WITH RELEASE OF THE HARNESS STRAPS AND REMOVAL OF THEIR CHILDREN FROM THE SEATS IN THE ABOVE MENTIONED ... Read More »
CHILD SEAT:TETHER: CONNECTOR/CLIP (SECURES TOP OF CHILD SEAT TO VEHICLE)
Child Seat Tether Anchor Installation This bulletin describes procedures to install Child Seat Tether Anchors based on Customer Request. Retrofits are subject to part availability. Read More »
