Official recalls have been issued for the 2004 Chevrolet Silverado 3500 by the NHTSA. The complete details of all recalls are listed below, along with what they cover and the recommended solutions.
Recalls don't cost you anything to get fixed, but most are time-limited, so if your car is affected you should call your local Chevrolet service department immediately!
If the passenger sensing system malfunctions, the front air bag on the passenger side may be disabled when it should be enabled, or enabled when it should be disabled. In either case, in the event of a crash that requires air bag deployment, a front passenger's level of injury may be ... Read more »
This condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. In the presence of an ignition source, a fire could occur. Read more »
A lap portion of the seat belt routing that is not low and snug on the hips can allow the lap belt to ride up on an occupant's abdomen instead of fitting low around their hipbones, and therefore, can expose them to more risk of abdominal and internal organ ... Read more »
If a separation occurred and the hood of the vehicle were open, fragments from the accumulator could cause injury to people in the immediate area. The presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. The loss of fluid would cause ... Read more »
The standard requires child seat lower anchorages in two seating positions for vehicles with three rear seating positions. The standard cab and cargo van vehicles, which only have front seating positions, have an air bag off switch to disable the front passenger air bag and do not have child restraint lower anchorages ... Read more »
Anyone sitting or standing on the horizontal surface of the tailgate when both cables fractured could be injured by falling from the tailgate. On vehicles that have had the bumper removed, the tailgate may drop even lower. Additionally, if there is cargo on the tailgate the cargo may fall off if the support cables ... Read more »
Consequently, the valve O-ring seal may fracture. Steering efforts may be slightly increased while braking or parking. Under certain driving conditions, a fractured seal may require a slight increase in the applied brake pedal effort to achieve the same vehicle deceleration rate as prior to the seat fracture. ... Read more »
