11/09/04 I had to replace differential assembly: Overhaul/rebuild front, replace brake pad (bendix)3/10/05 replaced idler arm. 3/23/05 replaced pitman arm. 10/25/05 6.5 liter diesel electronic pump (pmd) failure. Truck was moving on it's on, jerking, black smoke came from tail pipe and tires would spin then it cut off and wouldn't start. Called wrecker and had it taken to auto shop. He replaced pmd module kit with a note to leave plastic cover off engine because of heat build up. 6/25/06 same thing happened. Called wrecker and had it taken to auto shop. This time he replaced fuel pump on frame rail. 6/29/06 fuel filter rings blew off, it started pouring fuel onto highway, jerking, truck moving on it's on, black smoke coming from tail pipe wouldn't stop had to hold break to floor until it stalled. Almost hit a building.

- Spartanburg, SC, USA

I purchased this truck used with slightly over 26,000 miles on it with the remainder of the original 3yr/36,000 mile bumper to bumper warranty. Since the purchase there has been a popping and ratcheting sound coming from the rear end. The differential unit was improperly operating. Tried for 22,000 miles to get the dealer to replace the differential unit but was told several times that the unit was fine and the noise was to be expected. When the truck reached 40,000 mile the differential became completely inoperable. Just over 27,000 miles later the differential exploded destroying the entire internal axle assembly. The dealer still refuses to help. The dealer refused to fix the problem for the orignal owner and is still refusing to fix the problem. I have contacted Chevrolet customer service and they are trying to resolve this problem. I really did not appreciate the way the dealer has treated me this entire time. They treated me like I was some dum punk kid that just walked in off the street. I should not have been treated this way nor should I or anyone else have to put up with this kind of service.

- Lee' Summit, MO, USA

ABS light came on while driving also, when engine was shut off fan kept going. Dealer replaced ABS motor. The rear window on passenger side leaks water. Driver side window rattles when closing door. Driver door squeaks when opening and closing. The front seat belt locks up. The front end was leaking due to front differential vent failure. Wiper blades failed. Driver?S seat would not move due to seat adjuster failure. The ABS light came on because the ABS motor was defective. Transmission was leaking. The battery was leaking and was replaced. The coolant light came on due to a leaking water pump.

- Omaha, NE, USA

Without any indication, front end of vehicle locked up, causing consumer to lose control of vehicle. Dealer was contacted, and stated that subframe needed to be replaced. The front differential was torqued sideways and broken apart, causing the frame to have 2 breaks, this caused the front to lock up, also prior to this consumer complained of a delay between the forward and reverse, when a bump was felt when accelerating, consumer also heard a clunk noise, dealer drained and replaced the transfer case fluid twice. The engine sputters in 4 wheel low and there is a whine noise or pulley noise from the engine. The front seat arm rest fell off. The left front daytime lamp was full of water due to the assembly being improperly sealed at the factory. The brakes pulsated and pedal felt soft, dealer stated the right rear caliper was sticking and the front and rear rotors were corroded badly, causing the brake pads to wear. The electric brake was inoperable, dealer installed a new plug, the wiring harness was badly damaged. The power windows were inoperable. The left door creaks due to front door link being loose. Consumer was informed that he was supposed to sign a waiver because of the plow being placed onto the extended cab, this was because the installation was not recommended, however the consumer was never informed of this until after the installation and the problems with the vehicle.

- Peru, ME, USA

Front end has been vibrating since purchase of vehicle, dealer has replaced front end twice/ dashboard twice, and transfer case 3 times. Went to different dealers 11 times. Could not remedy problems. Chevrolet first agreed to buy vehicle back, then changed mind. Independent mechanic felt that problem had to do with driveline. Vehicle was at dealer 85 days first year. Please add additional information.

- Phoenix, AZ, USA

There is a grinding and clunking noise from differential area.

- Simi Valley, CA, USA

No summary listed for abov evehicle.

- Dimondale, MI, USA

No summary listed for above vehicle.

- Dimondale, MI, USA

I am planning on turning this vehicle in on the lemon law. No safety defect listed witin summary.

- Puyallup, WA, USA

Onsumer is not satisfied with this vehicle. Dealership had vehicle for thirty days over two month period. Consumer heard a grinding noise underneath the hood. Front four wheel drive differential was replaced. Also, steering wheel had a lot of play, and was replaced with upper and lower shaft/ transmission wouldn't shift into second and third gears. Dealership reprogramed PCM, and the transmission still doesn't operate at all. The back window flew open from the third door.

- Burlington, IA, USA

New vehicles need more testing before they are sold to the public.

- Mesa, AZ, USA

Date of purchase: 10/14/1998. Check engine light appeared first day of pick up. Kightlinger motors put new part on the next week. December 28, 1998: Took to dealer stating something wrong with front diff. Said nothing wrong. 1/17/99: Front differential snapped, gear box broke. Would not warranty! paid 3700 to fix. Next week, knocking noise. Took in said nothing wrong. Took to different dealer. One bolt holding gear box, front diff. In. 6/21/99 brakes metal to metal. Took to kight. Said stone caught. Took to different dealer, replaced brakes and rotors. Front end needs replacing 7/3/99: No brakes-fluid leaks.( dot number: 0000 tire size: 265R7516 )

- Coudersport, PA, USA