Vehicle loosing coolant. Determined cylinder head defect, tsb #06-06-01-019B. Cylinder head embossed with castech logo developed a porosity crack in a very specific area.

- Monterey, TN, USA

The consumer complained about several problems. While driving he had trouble shifting from first gear. The dealer reprogrammed the engine control module and the transmission module control. The vehicle was still shifting hard, and the rpms revved. The replacement of the aforementioned did not remedy the transmission problem. The second problem was with the brake light coming on the cluster assembly. The service dealer replaced it, and it seemed to work well at this time. The third problem was with a noise in the rear of the vehicle. The dealer replaced the gear kit, two gaskets, case, the rear differential carrier assembly, carrier gears, and shims. The noise was still heard. The dealer recommended that the contact install carpet to cut down on the noise. The final problem was with a loss of rear traction. The dealer has been unsuccessful in identifying the root of the traction problem. The cruise control stopped working. Updatd 11/29/05.

- Wheelersburg, OH, USA

When braking at any speed brake pedal would go to the floor, and there would be extended stopping distance. Dealership was notified, but did not resolve the problem. ABS displayed brake system failure. The consumer stated that the brakes failed on inclines. The consumer stated that there was an electrical short. The odometer failed and added extra mileage. The tires started separating after 300 miles. The radio became hot and shorted out. The air conditioner shorted out. The consumer stated that the new vehicle checklist was not filled out nor reviewed with him. The consumer stated that the engine knocks. The consumers fingers were burned by the radio after it got hot. The consumer stated that he heard a growling noise in the power steering. The consumer heard a buzzing noise in the transmission. The consumer had to use the emergency brake to stop the vehicle coming down a hill. The right headlight went out and turned black. The headlight was replaced with the wrong high beam light. The cd player will not take the cd. The speedometer will only go to 20 mph at times.

- North Little Rock, AR, USA

While driving at any speed vehicle stalled. Consumer restarted the vehicle and drove it to the dealer for inspection. However, mechanic could not duplicate the problem.

- Jacksonville, FL, USA

Engine makes a tapping sound when cold or warm. Dealer said it was called a piston slap. Dealer also said that there was no fix for the situation at this time and that it would not hurt the performance of the engine. I should not have to hear engine noise on a new vehicle.

- Palmdale, CA, USA

Vehicle was parked in the driveway when smoke and flames emitted from under the hood.

- Princeton, TX, USA

Ticking sound coming from engine after engine warms up, occurs at idle.

- Hinesville, GA, USA