While the vehicle was being serviced for regular maintenance, the mechanic noticed the rotors on the vehicle were rusted and pitted, all 4 four rotors were replaced.

- Mahopac, NY, USA

I have had a problem with the rotors on my 2000 Chevrolet truck. After 18,600 miles all four rotors have stated to fall apart. The surface were the pad contact have great amount of corrosion and the rotor material flaked off. Some had voids about two inches in diameter and deep enough that the pads no longer made contact with the surface of the rotor. The material that rusted off got imbedded into the pads so they were less effective on the remaining surface material of the rotor. I found out about the problem when the truck did not want to stop properly. I had my local garage check the brakes and they informed me about the rotors. They rebuilt the rear brakes. I then took the truck to the local Chevy garage and they replaced the front at no cost.

- Hopwood, PA, USA

Had to have brakes replaced on 2000 Chevy Silverado. Rotors were rusted out. Have never had rotors rust out on a vehicle. Vehicle had only approx. 35,000 miles on it. Cost me four times as much as I expected for the brake job.

- Hackettstown, NJ, USA

While driving the consumer applied the brakes and they failed completely without warning. The dealer diagnosed that all rotors were chipped off and completely rusted through.

- Middletown, IN, USA

When the brakes were applied, the vehicle vibrated. It was discovered the rotors were worn.

- Ansted, WV, USA

Consumers front and rear rotors are warning causing extended stopping distance.

- Bethel Park, PA, USA

All four rotors failed at 13,000 miles.

- Trafford, PA, USA

The rotors which are part of the braking system had begun operating improperly, causing the vehicle to vibrate while driving and to have increased vibration when the brakes were applied, especially at high speeds. The problem which caused the rotors to stop performing properly may have been caused by incorrect tightening/torqueing when the tires had been rotated shortly prior to the rotor problem happening. The dealer would not replace the rotore, even though the vehicle is still under full warranty. The informed me that the manufacturer would not allow replacement. This means that I now have rotors on the vehicle that have only a half-life remaining on them and the vehicle is still under warranty. Thus, if, after the warranty period, the rotors again stop performing, I will have to bear the cost of replacement. I contend that the problem was either caused by improper dealer maintenance, or that the rotors were defective. This scenario can be logical, as this vehicle required several major replacements of essential parts after only being sold to me for the period of one week. It is not unreasonable to me that the rotor could also have been defective, and I maintain that the manufacturer should have allowed the dealer to replace the rotors, rather than turning them.

- Laurel, MD, USA