Technical Service Bulletins (TSBs) for the 2007 Silverado are official communications between Chevrolet & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
BUICK/CADILLAC/CHEVROLET/GMC/OLDSMOBILE AND HUMMER: INFORMATION ON PITMAN ARM SHAFT SEAL SERVICE KIT. DO NOT REPLACE ENTIRE STEERING GEAR FOR PITMAN SEAL LEAK. Read More »
GENERAL MOTORS: THE LEFT AND/OR RIGHT STEERING WHEEL LOWER (SPOKE) COVER IS WARPED, LOOSE, DISCOLORED OR JUST FITS POORLY IN THE STEERING WHEEL. THE PAINT FINISH SEEMS TO BE PEELING. Read More »
CADILLAC/CHEVROLET/GMC: WILL HAVE INOPERATIVE CRUISE CONTROL; INOPERATIVE OR UNWANTED ACTIVATION OF RADIO CONTROLS; BACKLIGHTING FLASHES, FLICKERS OR INOPERATIVE DUE TO POSSIBLE SHORT TO GROUND ON STEERING WHEEL COIL CONNECTOR X2. Read More »
GENERAL MOTORS: THE LEFT AND/OR RIGHT STEERING WHEEL LOWER (SPOKE) COVER IS WARPED, LOOSE, DISCOLORED OR JUST FITS POORLY IN THE STEERING WHEEL. THE PAINT FINISH SEEMS TO BE PEELING. Read More »
STEERING WHEEL OFF CENTER WHILE DRIVING STRAIGHT, CLUNK NOISE WHILE TURNING, EARLY FRONT TIRE WEAR (PERFORM TORQUE TO TIGHTEN ANALYSIS AND REPAIR AS NECESSARY) *NJ UPDATED 2/25/08. *NJ Read More »
CLUNKING NOISE UNDER HOOD AND CAN BE FELT IN STEERING WHEEL AND/OR STEERING COLUMN (REPLACE UPPER INTERMEDIATE STEERING SHAFT [I-SHAFT] ASSEMBLY). *PE Read More »
BUICK/CADILLAC/CHEVROLET/GMC/OLDSMOBILE AND HUMMER: INFORMATION ON PITMAN ARM SHAFT SEAL SERVICE KIT. DO NOT REPLACE ENTIRE STEERING GEAR FOR PITMAN SEAL LEAK. Read More »
BUICK/CADILLAC/CHEVROLET/GMC/PONTIAC/ SATURN: THERE IS FLUID LEAKING FROM POWER STEERING SYSTEM, ALONG A FLUID LEAK IN FRONT OF VEHICLE UNDERNEATH AND SHOULD BE INSPECTED, CLEANED AND IDENTIFIED BEFORE REPAIRING OR REPLACING. Read More »
GMC: HYDRAULIC POWER STEERING LEAK AT HOSE CONNECTION TO STEERING RACK. ALL POTENTIAL LEAKS SHOULD BE COMPLETELY CLEANED AND INDENTIFIED BEFORE ATTEMPTING TO REPAIR OR REPLACE ANY POWER STEERING COMPONENTS. *JS UPDATED 4/22/13. Read More »
POWER STEERING, STEERING WHEEL SHUDDER/VIBRATION DURING LOW SPEED PARKING MANEUVERS (REPLACE POWER STEERING ASSEMBLY HOSE) EXCLUDING PICKUP MODELS WITH 4.3L V6 ENGINE (VIN X - RPO LU3) BUILT PRIOR TO 5/30/07. *NJ UPDATED 5/19/08. Read More »
STEERING:HYDRAULIC POWER ASSIST:POWER STEERING FLUID
BUICK/CADILLAC/CHEVROLET/GMC/PONTIAC/ SATURN: THERE IS FLUID LEAKING FROM POWER STEERING SYSTEM, ALONG A FLUID LEAK IN FRONT OF VEHICLE UNDERNEATH AND SHOULD BE INSPECTED, CLEANED AND IDENTIFIED BEFORE REPAIRING OR REPLACING. Read More »
CHEVROLET/GMC: A CLUNKING NOISE COMING FROM THE REAR OF THE VEHICLE. UPON FURTHER INVESTIGATION, THE TECHNICIAN MAY DIAGNOSE THE NOISE COMING FROM THE REAR SUSPENSION LEAF SPRING AREA. *PE UPDATED 6/30/2011. Read More »
CHEVROLET/GMC: A CLUNKING NOISE COMING FROM THE REAR OF THE VEHICLE. UPON FURTHER INVESTIGATION, THE TECHNICIAN MAY DIAGNOSE THE NOISE COMING FROM THE REAR SUSPENSION LEAF SPRING AREA. *PE UPDATED 6/30/2011. Read More »
GMC/CHEVROLET/CADILLAC: INSTRUMENT PANEL MESSAGES REGARDING STABILITRAK MESSAGE, TRACTION CONTROL MESSAGE, SERVICE BRAKE SYSTEM MESSAGE, IS OFF AND GAUGES, IN VARIOUS MODULES LOW SPEED SETTINGS, ARE INOPERATIVE. Read More »
DIAGNOSTIC INFORMATION ON MIL/SES WITH DTC P0171 (FUEL TRIM SYSTEM LEAN BANK 1) AND/OR P0174 (FUEL TRIM SYSTEM LEAN BANK 2) AFTER BRAKE MASTER CYLINDER REPLACEMENT. *NJ Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
CHEVROLET/CADILLAC/GMC: CERTAIN VEHICLES EXPERIENCING ERRATIC OR INOPERATIVE SPEEDOMETER OR ANTI-LOCK BRAKE SYSTEM MESSAGE OR MALFUNCTIONING INDICATOR LIGHT DISPLAYING IN DRIVER'S INFORMATION CENTER. Read More »
CHEVROLET/CADILLAC/GMC: CERTAIN VEHICLES EXPERIENCING ERRATIC OR INOPERATIVE SPEEDOMETER OR ANTI-LOCK BRAKE SYSTEM MESSAGE OR MALFUNCTIONING INDICATOR LIGHT DISPLAYING IN DRIVER'S INFORMATION CENTER. Read More »
GMC/CADILLAC/CHEVROLET: AIR BAG READINESS LIGHT ON, SERVICE AIR BAG MESSAGE, INFLATABLE RESTRAINT SENSING AND DIAGNOSTIC MODULE (SDM) CORROSION (REPLACE SDM/CUT AND REMOVE CARPET PAD). Read More »
CADILLAC/CHEVROLET/GMC: ON SOME VEHICLES AND/OR TRUCKS, INSTRUMENT CLUSTER WILL ILLUMINATE, AFTER AN OIL CHANGE, INDICATING LOW OIL PRESSURE AND/OR SES LAMP WILL ILLUMINATE. Read More »
GMC/CHEVROLET: ENGINES, WITH EGR SYSTEM, HAS LEAKAGE FROM EGR COOLER ENGINE COOLANT INTO THE COMBUSTION CHAMBER. MODEL 2002-15 SILVERADO, SIERRA, 2004-09 KODIAK C4500-C5500, TOPKICK C4500-C5500, 2006-15 EXPRESS, SAVANA. Read More »
GENERAL MOTORS: AN OPTIONAL ENGINE BLOCK HEATER PLUG IN FOR ONBOARD AC POWER AND WITH CONTINUOUS USAGE WILL RESULT IN SHORTING OF WIRES, OVER HEATING SYSTEM, ELECTRICAL FAILURE AND COMPARTMENT ENGINE FIRES. Read More »
GENERAL MOTORS: LOW ENGINE OIL PRESSURE, NO OIL PRESSURE, AND/OR ENGINE NOISE. THIS COULD BE THE RESULT OF A STICKING OIL PUMP PRESSURE RELIEF VALVE. *KB Read More »
BUICK/CADILLAC/CHEVROLET/GMC/HUMMER/PONTIAC/SAAB: OIL CONSUMPTION AND/OR EXHAUST SMOKE-POSSIBLE PCV BAFFLE OR LIFTER CONCERN. UPON INSPECTION, OBVIOUS OIL WILL BE FOUND IN THE INTAKE MANIFOLD AND/OR PCV VACUUM TUBE. Read More »
CHEVROLET/GMC: CHECK ENGINE LIGHT ON, FUEL TANK HARD TO FILL, DTCS P0442, P0446, P0455 OR P0449 SET (REPLACE EVAPORATIVE EMISSION (EVAP) VENT VALVE SOLENOID ASSEMBLY AND ADD/RELOCATE FILETER BOX USING SERVICE KIT). Read More »
PONTIAC/SATURN/BUICK/GMC/CHEVROLET/CADILLAC/HUMMER: VEHICLE START AND STALLS AFTER THEFT DETERRENT MODULE REPLACEMENT. MODEL YEARS 2006-2011. DOES NOT APPLY TO VEHICLES WITH KEYLESS ACCESS SYSTEM. Read More »
LOSS OF HIGH SPEED GMLAN COMMUNICATIONS, INTERMITTENT NO CRANK, IPC GAUGE FLUCTUATION, INTERMITTENT DOOR LOCK CYCLING, TRANSMISSION MAY NOT SHIFT, DTCS U0073, U0100, U0101, U0102, U0121, U0140 SET (REPAIR BACKED OUT TERMINAL IN ... Read More »
CADILLAC/CHEVROLET/GMC: LOCATIONS OF HIGH SPEED GMLAN WIRING CONCERNS. GAUGES INOPERATIVE, NO CRANK, HARSH TRANSMISSION SHIFTING, NO TRANSMISSION SHIFTING, DOOR LOCKS CYCLING AND INDICATORS ON. *PE UPDATED 11/17/10. Read More »
SOME CUSTOMERS WHOSE VEHICLES ARE OPERATED IN DUSTY TYPE ENVIRONMENTS, SUCH AS FARMING OR MINING OFF-ROAD TYPE APPLICATIONS, MAY COMMENT ABOUT THE ILLUMINATION OF THE INSTRUMENT PANEL SES LIGHT, WITH DIAGNOSTIC TROUBLE CODE P0446 SET. Read More »
CHEVROLET/GMC: SNOW OR ICE INGESTION INTO AIR CLEANER ELEMENT, MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED, ENGINE POWER IS REDUCED MESSAGE DISPLAYED, DTC P0101 SET (PERFORM REPAIR AS OUTLINED). Read More »
CHEVROLET SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ECM EEPROM - REPROGRAM ECM. ALL 2007 AND CERTAIN 2008 CHEVEROLET SILVERADO AND EXPRESS AND GMC SIERRA AND SAVANA EQUIPPED WITH 6. Read More »
LOSS OF HIGH SPEED GMLAN COMMUNICATIONS, INTERMITTENT NO CRANK, IPC GAUGE FLUCTUATION, INTERMITTENT DOOR LOCK CYCLING, TRANSMISSION MAY NOT SHIFT, DTCS U0073, U0100, U0101, U0102, 70140 (REPAIR BACKED OUT TERMINAL IN TRANSMISSION HARNESS ... Read More »
GMC: OIL LEAK AT TURBOCHARGER AIR INTAKE PIPE. INITIAL INSPECTION MA REVEAL A LEAK THAT LOOKS AS IT IS COMING FROM THE REAR OF THE ENGINE. *PE Read More »
GM: AN 'ENGINE POWER IS REDUCED' MESSAGE APPEARS AND THERE IS A STORED TROUBLE CODE. THIS IS CAUSED BY WEAR OF THE INTERNAL FUEL INJECTOR. *RM Read More »
BUICK/CHEVROLET/GMC/PONTIAC/SAAB: EXCESSIVE OIL CONSUMPTION AND/OR BLUE EXHAUST SMOKE-INVESTIGATION UPDATE. IN MOST CASES DID NOT START UNTIL THE ENGINE ACCUMULATED APPROXIMATELY 30,000 MILES OR MORE. Read More »
CHEVROLET/GMC: SNOW OR ICE INGESTION INTO AIR CLEANER ELEMENT, MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED, ENGINE POWER IS REDUCED MESSAGE DISPLAYED, DTC P0101 SET (PERFORM REPAIR AS OUTLINED). Read More »
GENERAL MOTORS: LBZ, LLY, LMM MIL/SES LIGHT N DTC P0087-FUEL RAIL PRESSURE (FRP) TOO LOW, LACK OF PERFORMANCE, NO POWER, ENGINE RUNS ROUGH, NO START (DIAGNOSE FUEL SYSTEM COMPONENTS). *PE UPDATED 3/1/10. Read More »
GMC/CHEVROLET: ENGINE COOLANT SENSOR DTCS P011A, P2184, AND P2185. DEALER MAY ENCOUNTER CONCERN OF SES LIGHT ON OR DTCS P011A, P2184 AND P2185. DIESEL ENGINES HAVE 2 ECT (ENGINE COOLANT TEMPERATURE) SENSORS. Read More »
GMC/CHEVROLET: DTC P0101 WITH NON GM AIR FILTER. MAY ENCOUNTER CONCERN OF REDUCED POWER AND SES LIGHT ON. DIAGNOSTICS MAY REVEAL MAF (MASS AIR FLOW) SENSOR DTC P0101. Read More »
LMM, CLEAN EXHAUST FILTER LIGHT ILLUMINATED, MIL/SES LIGHT ILLUMINATED WITH DTC(S) P244B AND/OR P2463 SET (PERFORM ALL SI DIAGNOSTICS FOR DTC(S) SET, IF NTF, REPLACE AIR FILTER). VEHICLES WITH 6.6L DURAMAX DIESEL ENGINE. Read More »
SES LIGHT ON DUE TO DTC P0101 AND/OR P0106 - INSPECT AIR FILTER AND/OR MAP SENSOR . WITH 6.6L DIESEL ENGINE (RPO, LBZ, LLY, OR LMM). *NJ UPDATED 5/13/08. *NJ Read More »
GMC: OIL LEAK AT TURBOCHARGER AIR INTAKE PIPE. INITIAL INSPECTION MA REVEAL A LEAK THAT LOOKS AS IT IS COMING FROM THE REAR OF THE ENGINE. *PE Read More »
GMC: CORRECT FRONT AXLE VENT HOSE ROUTING. THE FRONT AXLE VENT HOSE IS MOUNTED IN THE LEFT SIDE OF THE ENGINE COMPARTMENT, AND MAY NOT BE CORRECTLY ROUTED. *PE UPDATED ON 5/1/2012. *KB Read More »
BUICK/CHEVROLET/GMC/PONTIAC/SAAB: EXCESSIVE OIL CONSUMPTION AND/OR BLUE EXHAUST SMOKE-INVESTIGATION UPDATE. IN MOST CASES DID NOT START UNTIL THE ENGINE ACCUMULATED APPROXIMATELY 30,000 MILES OR MORE. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
CHEVROLET/GMC: CHECK ENGINE LIGHT ON, FUEL TANK HARD TO FILL, DTCS P0442, P0446, P0455 OR P0449 SET (REPLACE EVAPORATIVE EMISSION (EVAP) VENT VALVE SOLENOID ASSEMBLY AND ADD/RELOCATE FILETER BOX USING SERVICE KIT). Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
BUICK/CADILLAC/CHEVROLET/GMC/HUMMER/PONTIAC/SAAB: OIL CONSUMPTION AND/OR EXHAUST SMOKE-POSSIBLE PCV BAFFLE OR LIFTER CONCERN. UPON INSPECTION, OBVIOUS OIL WILL BE FOUND IN THE INTAKE MANIFOLD AND/OR PCV VACUUM TUBE. Read More »
GMC/CHEVROLET: ENGINES, WITH EGR SYSTEM, HAS LEAKAGE FROM EGR COOLER ENGINE COOLANT INTO THE COMBUSTION CHAMBER. MODEL 2002-15 SILVERADO, SIERRA, 2004-09 KODIAK C4500-C5500, TOPKICK C4500-C5500, 2006-15 EXPRESS, SAVANA. Read More »
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
CHEVROLET/GMC: CHECK ENGINE LIGHT ON, FUEL TANK HARD TO FILL, DTCS P0442, P0446, P0455 OR P0449 SET (REPLACE EVAPORATIVE EMISSION (EVAP) VENT VALVE SOLENOID ASSEMBLY AND ADD/RELOCATE FILETER BOX USING SERVICE KIT). Read More »
GMC: FUEL RAIL PRESSURE SENSOR PERFORMANCE DTC P0191. MAY SET DUE TO ACTUAL FUEL RAIL PRESSURE NOT DROPPING QUICKLY ENOUGH WHEN THE ENGINE IS SHUT OFF. *PE Read More »
GMC/CHEVROLET/CADILLAC: VEHICLE FUEL GAUGE INACCURATE BELOW 1/4 TANK. ON RARE OCCASIONS, THE VEHICLE HAS AN INACCURATE FUEL GAUGE READING AT 1/4 OR A 1/8 OF A TANK. *PE Read More »
GM: SLIPS IN REVERSE OR THIRD, DELAYED REVERSE OR DRIVE ENGAGEMENT, DTC P0776, P2715, P2723, HARSH 2-3 SHIFTS (INSPECT 1-2-3-/ 3-5-R HOUSING AND PUMP SEAL RINGS). THIS CONDITION MAY BE CAUSED BY A CRACKED 1-2-3-4/ 3-5-R CLUTCH HOUSING. Read More »
CHEVROLET/GMC: DELAYED OR NO DRIVE AND DELAYED OR NO REVERSE WITH DTC'S, RANGE INHIBIT. MODEL YEARS 2001-2013. *PE UPDATED ON 06/08/2011. *KB UPDATED ON 06/16/2011. *KB UPDATED 11/26/12. Read More »
CADILLAC/CHEVROLET/GMC/HUMMER/PONTIAC: THERE IS SLIPPING OR HAVE NO FOURTH, FIFTH OR SIXTH GEAR AND MALFUNCTION INDICATOR LAMP (MIL) WOULD BE ON, WITH DIAGNOSTIC TROUBLE CODE (DTC) P0796 FOUND AS ACTIVE. Read More »
GM: TICK OR RATTLE NOISE FROM FRONT OF DASH, TRANSMISSION FILLER TUBE CRACKED OR BROKEN (INSPECT FILLER TUBE, REPLACE TUBE AS NECESSARY). *JS UPDATED 05/3/2013 *JS Read More »
CADILLAC/CHEVROLET/GMC/HUMMER: SOME SUVS AND TRUCKS ARE EXHIBITING A CONDITION WHERE BY GRINDING/RATCHETING TYPE NOISE COMING FROM AUTOMATIC TRANSMISSION WHEN SHIFTING INTO PARK WHILE IN 4WD LOW (4LO) RANGE. Read More »
CHEVROLET\GMC SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ENHANCED CALIBRATION FOR TRANSMISSION OVERHEAT IN EXTREME COLD AIR TEMPERATURES. Read More »
LOSS OF HIGH SPEED GMLAN COMMUNICATIONS, INTERMITTENT NO CRANK, IPC GAUGE FLUCTUATION, INTERMITTENT DOOR LOCK CYCLING, TRANSMISSION MAY NOT SHIFT, DTCS U0073, U0100, U0101, U0102, U0121, U0140 SET (REPAIR BACKED OUT TERMINAL IN ... Read More »
CADILLAC/CHEVROLET/GMC: LOCATIONS OF HIGH SPEED GMLAN WIRING CONCERNS. GAUGES INOPERATIVE, NO CRANK, HARSH TRANSMISSION SHIFTING, NO TRANSMISSION SHIFTING, DOOR LOCKS CYCLING AND INDICATORS ON. *PE UPDATED 11/17/10. Read More »
GMC: FLARE AND OR HARSH 2-3 SHIFTS. THIS CONDITION MAY BE CAUSED BY LEAKING 1-2-3-4 AND 3-5-R CLUTCH FLUID SEAL RINGS (230). MODELS CADILLACS, CHEVROLETS, GMC, HUMMERS, PONTIACS. Read More »
4L60-E/4L65-E/4L70-E AUTOMATIC TRANSMISSION FLUID LEAK FROM OIL PUMP OR BELL HOUSING AREA (REPLACE TORQUE CONVERTER HUB-TO-OIL PUMP SEAL ASSEMBLY). ATTN: THIS BULLETIN APPLIES TO VEHICLES BUILT PRIOR TO DECEMBER 2007. Read More »
DIAGNOSTIC INFORMATION ON MH1, MN8, MT1, M15 TRANSMISSION SLIPS, WILL NOT SHIFT OR MAY OVERHEAT, SES/MIL MAY BE ILLUMINATED, DTCS P0218, P0894 SET. *PE UPDATED 8/12/08. *PE Read More »
ENGINE SURGE OR STALL AT STOP AND/OR DTC P0742 POSSIBLE TCC APPLIED. EQUIPPED WITH ALLISON LCT1000 TRANSMISSION RPO M74 OR MW7. *NJ UPDATED 4/22/13. *PE Read More »
GM: LOSS OF HIGH SPEED GMLAN COMMUNICATIONS, INTERMITTENT NO CRANK, IP GAGE FLUCTUATION, INTERMITTENT DOOR LOOK CYCLING, INTERMITTENT CHIME OPERATION, VARIOUS IP WARNING LAMPS ILLUMINATED, TRANSMISSION MAY NOT SHIFT, COMMUNICATION DTCS ... Read More »
CHEVROLET\GMC SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ENHANCED CALIBRATION FOR TRANSMISSION OVERHEAT IN EXTREME COLD AIR TEMPERATURES. Read More »
LOSS OF HIGH SPEED GMLAN COMMUNICATIONS, INTERMITTENT NO CRANK, IPC GAUGE FLUCTUATION, INTERMITTENT DOOR LOCK CYCLING, TRANSMISSION MAY NOT SHIFT, DTCS U0073, U0100, U0101, U0102, U0121, U0140 SET (REPAIR BACKED OUT TERMINAL IN ... Read More »
CHEVROLET\GMC SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. TRANSMISSION OVERHEAT IN EXTREME COLD AMBIENT TEMPERATURES - REPROGRAM TCM. LOCATED IN ALASKA AND MINNESOTA; CANADIAN YUKON AND NORTHWEST TERRITORIES ONLY. Read More »
LOSS OF HIGH SPEED GMLAN COMMUNICATIONS, INTERMITTENT NO CRANK, IPC GAUGE FLUCTUATION, INTERMITTENT DOOR LOCK CYCLING, TRANSMISSION MAY NOT SHIFT, DTCS U0073, U0100, U0101, U0102, 70140 (REPAIR BACKED OUT TERMINAL IN TRANSMISSION HARNESS ... Read More »
GMC/CHEVROLET: BULLETIN PROVIDES INFORMATION ON THE SEAL REVISION AND THE TRANSFER CASE OUTPUT SHAFT SLINGER FOR CERTAIN MODEL YEAR TRUCKS. *PE Read More »
TRANSFER CASE WILL NOT SHIFT POSSIBLE DTC'S C0387 AND/OR C0569. ON VEHICLES EQUIPPED WITH A MAGNA TRANSFER CASE RPO NQF. *NJ UPDATED 3/15/10. *PE UPDATED ON 6/27/2011. Read More »
4 WHEEL DRIVE INOPERATIVE FRONT AXLE WILL NOT ENGAGE - KEYWORDS CLUNK GRIND GROWL K2 K3 EQUIPPED WITH A 9.25 FRONT DIFFERENTIAL. *NJ UPDATED 2/27/08. *NJ Read More »
CADILLAC/CHEVROLET/GMC: WILL HAVE INOPERATIVE CRUISE CONTROL; INOPERATIVE OR UNWANTED ACTIVATION OF RADIO CONTROLS; BACKLIGHTING FLASHES, FLICKERS OR INOPERATIVE DUE TO POSSIBLE SHORT TO GROUND ON STEERING WHEEL COIL CONNECTOR X2. Read More »
CHEVROLET/CADILLAC/GMC: CERTAIN VEHICLES EXPERIENCING ERRATIC OR INOPERATIVE SPEEDOMETER OR ANTI-LOCK BRAKE SYSTEM MESSAGE OR MALFUNCTIONING INDICATOR LIGHT DISPLAYING IN DRIVER'S INFORMATION CENTER. Read More »
GM: J-35616-64B TERMINAL TEST PROBE AND REPLACEMENT TERMINAL. ALSO INCLUDED MODELS VERANO, REGAL, LACROSSE, CTS, SRX, VOLT, SONIC, MALIBU, IMPALA, EQUINOX, CRUZE, AVALANCHE, TAHOE SUBURBAN, SILVERADO, SIERRA, YUKON, AND TERRAIN FOR ... Read More »
GM: THERE MAY BE MULTIPLE ELECTRICAL ISSUES SUCH AS: NO START, STARTER STAYS ENGAGED, FOG LAMPS WON'T TURN ON, WASHING FLUID NOT SPRAYING, PARK AND REVERSE LIGHTS STAY ON, BATTERY GOES DEAD, AND A BUZZ NOISE UNDERNEATH THE DASH. Read More »
GENERAL MOTORS: DURING NORMAL DIAGNOSTICS AND/OR REPAIR VERIFICATION THE ABS LIGHT, TRACTION CONTROL AND/OR STABILITRAK INDICATORS MAY BE ON WITH NO DTC'S DISPLAYED BY THE EBCM. *PE UPDATED 11/17/10. *PE UPDATED 3/14/11. Read More »
CHEVROLET/GMC: INSPECT FOR WIRE HARNESS CHAFES NEAR CONNECTOR X108. DEALER MAY ENCOUNTER A CONCERN OF THE SES LIGHT ON WITH REDUCED POWER. DIAGNOSTICS MAY REVEAL DTC'S P0193, P0522 AND/OR P0652. Read More »
GMC/CHEVROLET: SEE DOCUEMTN SEARCH BUTTON FOR OWNER LETTER. AUXILIARY BATTERY FEED MAY CAUSE FUSIBLE LINK TO MELT AND OPEN CIRCUIT TO PREVENT DAMAGE OR FIRE IN WIRING HARNESS, DUE TO ELECTRICAL OVER LOAD. Read More »
GM: THERE MAY BE MULTIPLE ELECTRICAL ISSUES SUCH AS: NO START, STARTER STAYS ENGAGED, FOG LAMPS WON'T TURN ON, WASHING FLUID NOT SPRAYING, PARK AND REVERSE LIGHTS STAY ON, BATTERY GOES DEAD, AND A BUZZ NOISE UNDERNEATH THE DASH. Read More »
GMC/CHEVROLET/CADILLAC: SIR MIL ON WITH DTC B1325 SYM 03. DURING A LOW BATTERY/VOLTAGE CONDITION THE PASSENGER PRESENCE SYSTEM MAY SET A B1325 SYM 03 ALONG WITH OTHER FAULTS THAT ARE CAUSED BY THE LOW BATTER/VOLTAGE CONDITION. Read More »
GMC: INTERMITTENT NO CRANK AND/OR DISCHARGED BATTERY. COULD BE CAUSED BY A LOOSE CONNECTION AT THE 175 AMP MEGA FUSE LOCATED ON THE PASSENGER SIDE OF THE COWL. *PE Read More »
GMC: INTERMITTENT NO CRANK AND/OR DISCHARGED BATTERY. COULD BE CAUSED BY A LOOSE CONNECTION AT THE 175 AMP MEGA FUSE LOCATED ON THE PASSENGER SIDE OF THE COWL. *PE Read More »
CHEVROLET/GMC: SERVICE TRAILER BRAKE MESSAGE WITH DTC(S) C1115, C1116, C1117, AND/OR C1118 (INSPECT WIRING NEAR PARKING BRAKE PEDAL). THIS CONCERN MAY BE VERY INTERMITTENT AND CAN OCCUR WITH OR WITHOUT A TRAILER CONNECTED TO TRUCK. Read More »
GMC/CHEVROLET: CHECK TRAILER WIRING MESSAGE IN DIC POOR CONNECTIONS AT 7-WAY). THIS CONCERN COULD BE CAUSED BY A POOR CONNECTION AT THE 7-WAY TRAILER CONNECTOR. Read More »
CHEVROLET/GMC: INSPECT FOR WIRE HARNESS CHAFES NEAR CONNECTOR X108. DEALER MAY ENCOUNTER A CONCERN OF THE SES LIGHT ON WITH REDUCED POWER. DIAGNOSTICS MAY REVEAL DTC'S P0193, P0522 AND/OR P0652. Read More »
VARIOUS ELECTRICAL CONCERNS - INTERMITTENTLY FUNCTIONING OR INOPERATIVE COMPONENT, IP WARNING LIGHT ON, DIC MESSAGE DISPLAYED, DTC SET, NO CRANK/START (REPAIR IP WIRING HARNESS) *NJ Read More »
ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL
CHEVROLET/GMC: SERVICE TRAILER BRAKE MESSAGE WITH DTC(S) C1115, C1116, C1117, AND/OR C1118 (INSPECT WIRING NEAR PARKING BRAKE PEDAL). THIS CONCERN MAY BE VERY INTERMITTENT AND CAN OCCUR WITH OR WITHOUT A TRAILER CONNECTED TO TRUCK. Read More »
GMC/CHEVROLET: CHECK TRAILER WIRING MESSAGE IN DIC POOR CONNECTIONS AT 7-WAY). THIS CONCERN COULD BE CAUSED BY A POOR CONNECTION AT THE 7-WAY TRAILER CONNECTOR. Read More »
GMC: INTERMITTENT NO CRANK AND/OR DISCHARGED BATTERY. COULD BE CAUSED BY A LOOSE CONNECTION AT THE 175 AMP MEGA FUSE LOCATED ON THE PASSENGER SIDE OF THE COWL. *PE Read More »
GM: THERE MAY BE MULTIPLE ELECTRICAL ISSUES SUCH AS: NO START, STARTER STAYS ENGAGED, FOG LAMPS WON'T TURN ON, WASHING FLUID NOT SPRAYING, PARK AND REVERSE LIGHTS STAY ON, BATTERY GOES DEAD, AND A BUZZ NOISE UNDERNEATH THE DASH. Read More »
CADILLAC/CHEVROLET/GMC: ON SOME VEHICLES AND/OR TRUCKS, INSTRUMENT CLUSTER WILL ILLUMINATE, AFTER AN OIL CHANGE, INDICATING LOW OIL PRESSURE AND/OR SES LAMP WILL ILLUMINATE. Read More »
CHEVROLET/CADILLAC/GMC: CERTAIN VEHICLES EXPERIENCING ERRATIC OR INOPERATIVE SPEEDOMETER OR ANTI-LOCK BRAKE SYSTEM MESSAGE OR MALFUNCTIONING INDICATOR LIGHT DISPLAYING IN DRIVER'S INFORMATION CENTER. Read More »
LOSS OF HIGH SPEED GMLAN COMMUNICATIONS, INTERMITTENT NO CRANK, IPC GAUGE FLUCTUATION, INTERMITTENT DOOR LOCK CYCLING, TRANSMISSION MAY NOT SHIFT, DTCS U0073, U0100, U0101, U0102, U0121, U0140 SET (REPAIR BACKED OUT TERMINAL IN ... Read More »
CADILLAC/CHEVROLET/GMC: LOCATIONS OF HIGH SPEED GMLAN WIRING CONCERNS. GAUGES INOPERATIVE, NO CRANK, HARSH TRANSMISSION SHIFTING, NO TRANSMISSION SHIFTING, DOOR LOCKS CYCLING AND INDICATORS ON. *PE UPDATED 11/17/10. Read More »
LOSS OF HIGH SPEED GMLAN COMMUNICATIONS, INTERMITTENT NO CRANK, IPC GAUGE FLUCTUATION, INTERMITTENT DOOR LOCK CYCLING, TRANSMISSION MAY NOT SHIFT, DTCS U0073, U0100, U0101, U0102, 70140 (REPAIR BACKED OUT TERMINAL IN TRANSMISSION HARNESS ... Read More »
ONE OF THE FOLLOWING CONCERNS WHEN PROGRAMMING THE MILEAGE OR THE HOURS INTO AN EXCHANGE INSTRUMENT PANEL CLUSTER THAT IS RECEIVED FROM AN ELECTRONIC SERVICE CENTER (ESC). *NJ Read More »
GENERAL MOTORS: DURING NORMAL DIAGNOSTICS AND/OR REPAIR VERIFICATION THE ABS LIGHT, TRACTION CONTROL AND/OR STABILITRAK INDICATORS MAY BE ON WITH NO DTC'S DISPLAYED BY THE EBCM. *PE UPDATED 11/17/10. *PE UPDATED 3/14/11. Read More »
GM: LOW BEAM HEADLAMP BULB DIAGNOSIS/ REPLACEMENT (INSPECT BULB AND CONNECTOR). DO NOT REPLACE THE ENTIRE HEADLAMP ASSEMBLY FOR THIS CONDITION. REPLACE THE BULB AND INSPECT THE CONNECTOR. *JS UPDATED 4/7/15. Read More »
GMC: BMC FAILURE AFTER WINDSHIELD WIPER OPERATION-KEYWORDS: AJAR DOOR DOME DRIVER DIMMER FLASHER FOG HAUL HEADLIGHT HEAD HIGH HAZARD INOP INOPERATIVE LAMP LIGHT LOCK LOW NOT ON OFF POWER PARK RADIO RAP REPEAT SIGNAL SHUT SPEED STAY SWITCH ... Read More »
GMC: BMC FAILURE AFTER WINDSHIELD WIPER OPERATION-KEYWORDS: AJAR DOOR DOME DRIVER DIMMER FLASHER FOG HAUL HEADLIGHT HEAD HIGH HAZARD INOP INOPERATIVE LAMP LIGHT LOCK LOW NOT ON OFF POWER PARK RADIO RAP REPEAT SIGNAL SHUT SPEED STAY SWITCH ... Read More »
GMC: BMC FAILURE AFTER WINDSHIELD WIPER OPERATION-KEYWORDS: AJAR DOOR DOME DRIVER DIMMER FLASHER FOG HAUL HEADLIGHT HEAD HIGH HAZARD INOP INOPERATIVE LAMP LIGHT LOCK LOW NOT ON OFF POWER PARK RADIO RAP REPEAT SIGNAL SHUT SPEED STAY SWITCH ... Read More »
GMC: STOP LAMPS INTERMITTENTLY TURN OFF AFTER COMING TO A COMPLETE STOP WHILE STILL HAVING PRESSURE ON BRAKE PEDAL (REPLACE STOP LAMP SWITCH). *PE UPDATED 3/1/10. *PE Read More »
INFORMATION ON BCM CALIBRATIONS AVAILABLE TO RESTORE BULB OUTAGE DETECTION ON VEHICLES PRODUCED BY A SECOND STAGE MANUFACTURER, TURN SIGNALS FLASH FAST AFTER FACTORY BOX REMOVED (UPFITTER). Read More »
GENERAL MOTORS: BCM CALIBRATIONS AVAILABLE TO RESTORE BULB OUTAGE DETECTION ON VEHICLES PRODUCED BY A SECOND STATE MANUFACTURER, TURN SIGNALS FLASH FAST AFTER FACTORY BOX REMOVED (UPFITTER). Read More »
GENERAL MOTORS: BCM CALIBRATIONS AVAILABLE TO RESTORE BULB OUTAGE DETECTION ON VEHICLES PRODUCED BY A SECOND STATE MANUFACTURER, TURN SIGNALS FLASH FAST AFTER FACTORY BOX REMOVED (UPFITTER). Read More »
GMC: BMC FAILURE AFTER WINDSHIELD WIPER OPERATION-KEYWORDS: AJAR DOOR DOME DRIVER DIMMER FLASHER FOG HAUL HEADLIGHT HEAD HIGH HAZARD INOP INOPERATIVE LAMP LIGHT LOCK LOW NOT ON OFF POWER PARK RADIO RAP REPEAT SIGNAL SHUT SPEED STAY SWITCH ... Read More »
GMC: BMC FAILURE AFTER WINDSHIELD WIPER OPERATION-KEYWORDS: AJAR DOOR DOME DRIVER DIMMER FLASHER FOG HAUL HEADLIGHT HEAD HIGH HAZARD INOP INOPERATIVE LAMP LIGHT LOCK LOW NOT ON OFF POWER PARK RADIO RAP REPEAT SIGNAL SHUT SPEED STAY SWITCH ... Read More »
GMC: BMC FAILURE AFTER WINDSHIELD WIPER OPERATION-KEYWORDS: AJAR DOOR DOME DRIVER DIMMER FLASHER FOG HAUL HEADLIGHT HEAD HIGH HAZARD INOP INOPERATIVE LAMP LIGHT LOCK LOW NOT ON OFF POWER PARK RADIO RAP REPEAT SIGNAL SHUT SPEED STAY SWITCH ... Read More »
GMC: BMC FAILURE AFTER WINDSHIELD WIPER OPERATION-KEYWORDS: AJAR DOOR DOME DRIVER DIMMER FLASHER FOG HAUL HEADLIGHT HEAD HIGH HAZARD INOP INOPERATIVE LAMP LIGHT LOCK LOW NOT ON OFF POWER PARK RADIO RAP REPEAT SIGNAL SHUT SPEED STAY SWITCH ... Read More »
GMC: BMC FAILURE AFTER WINDSHIELD WIPER OPERATION-KEYWORDS: AJAR DOOR DOME DRIVER DIMMER FLASHER FOG HAUL HEADLIGHT HEAD HIGH HAZARD INOP INOPERATIVE LAMP LIGHT LOCK LOW NOT ON OFF POWER PARK RADIO RAP REPEAT SIGNAL SHUT SPEED STAY SWITCH ... Read More »
GM: DIAGNOSE AND REPAIR HVAC BLOWER FUNCTION. MAY NOT BE ANY AIR FLOW FROM THE HVAC VENTS. ONE POSSIBLE OF THIS CONDITION MAY BE THE CONTACTS IN THE HVAC JUNCTION BLOCK(S) LOCATED AT THE RIGHT SIDE OF THE INSTRUMENTAL PANEL. Read More »
GENERAL MOTORS: DIAGNOSTIC INFORMATION FOR INTERMITTENT RESTRAINTS, AIR BAG (SIR) INDICATOR/LAMP ON WITH DTC(S) B0012, B0013, B0016, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 OR B0044 SET. Read More »
GMC/CADILLAC/CHEVROLET: AIR BAG READINESS LIGHT ON, SERVICE AIR BAG MESSAGE, INFLATABLE RESTRAINT SENSING AND DIAGNOSTIC MODULE (SDM) CORROSION (REPLACE SDM/CUT AND REMOVE CARPET PAD). Read More »
GM: THERE ARE SEAT BELT PROBLEMS: DIFFICULTY LATCHING AND UNLATCHING BUCKLE. BUCKLE RELEASE BUTTON IS STICKING. SEAT BELT WARNING LIGHT ILLUMINATED. LIKELY CAUSED BY STICKY BEVERAGES THAT ARE SPILLED INTO THE BUCKLE ASSEMBLY. Read More »
GM: THERE ARE SEAT BELT PROBLEMS: DIFFICULTY LATCHING AND UNLATCHING BUCKLE. BUCKLE RELEASE BUTTON IS STICKING. SEAT BELT WARNING LIGHT ILLUMINATED. LIKELY CAUSED BY STICKY BEVERAGES THAT ARE SPILLED INTO THE BUCKLE ASSEMBLY. Read More »
CADILLAC\CHEVROLET\GMC SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPECIAL COVERAGE ADJUSTMENT-FRONT AND REAR CHROME INTERIOR DOOR HANDLE LEVER. Read More »
GM: THE CHROME OUTSIDE DOOR HANDLE IS CRACKED OR LOOSE AT THE SCREW WHERE IT ATTACHES. GREASE MAY HAVE CAUSE THE SCREW TO DEGRADE OR THE TORQUE WAS TOO HIGH. *RM Read More »
UNABLE TO DISABLE AUTO DOOR LOCKS. THIS INCLUDES 05 CHEVROLET GMC CADILLAC FULL SIZE TRUCKS AND UTILITIES. *EH ALSO INCLUDES AVALANCE, SILVERADO SUBURBAN TAHOE; GMC SIERRA, YUKON, DENALI, YUKON XL, DENALI XL. UPDATED 8/26/08. Read More »
GM: THE FRONT OR REAR DOOR MAY NOT OPEN FROM THE INSIDE OR OUTSIDE HANDLE, THE DOOR WILL NOT UNLOCK WITH ANY METHOD. THE PROBABLY CAUSE AN INCORRECT INSTALLATION OF A HANDLE COMPONENT. *RM UPDATED ON 7/26/2013. Read More »
UNABLE TO DISABLE AUTO DOOR LOCKS. THIS INCLUDES 05 CHEVROLET GMC CADILLAC FULL SIZE TRUCKS AND UTILITIES. *EH ALSO INCLUDES AVALANCE, SILVERADO SUBURBAN TAHOE; GMC SIERRA, YUKON, DENALI, YUKON XL, DENALI XL. UPDATED 8/26/08. Read More »
LOSS OF HIGH SPEED GMLAN COMMUNICATIONS, INTERMITTENT NO CRANK, IPC GAUGE FLUCTUATION, INTERMITTENT DOOR LOCK CYCLING, TRANSMISSION MAY NOT SHIFT, DTCS U0073, U0100, U0101, U0102, U0121, U0140 SET (REPAIR BACKED OUT TERMINAL IN ... Read More »
CADILLAC/CHEVROLET/GMC: LOCATIONS OF HIGH SPEED GMLAN WIRING CONCERNS. GAUGES INOPERATIVE, NO CRANK, HARSH TRANSMISSION SHIFTING, NO TRANSMISSION SHIFTING, DOOR LOCKS CYCLING AND INDICATORS ON. *PE UPDATED 11/17/10. Read More »
GMC: BMC FAILURE AFTER WINDSHIELD WIPER OPERATION-KEYWORDS: AJAR DOOR DOME DRIVER DIMMER FLASHER FOG HAUL HEADLIGHT HEAD HIGH HAZARD INOP INOPERATIVE LAMP LIGHT LOCK LOW NOT ON OFF POWER PARK RADIO RAP REPEAT SIGNAL SHUT SPEED STAY SWITCH ... Read More »
LOSS OF HIGH SPEED GMLAN COMMUNICATIONS, INTERMITTENT NO CRANK, IPC GAUGE FLUCTUATION, INTERMITTENT DOOR LOCK CYCLING, TRANSMISSION MAY NOT SHIFT, DTCS U0073, U0100, U0101, U0102, 70140 (REPAIR BACKED OUT TERMINAL IN TRANSMISSION HARNESS ... Read More »
CADILLAC/GMC/CHEVROLET: INFORMATION ON CRUISE CONTROL BEING INOPERATIVE DUE TO BPP CIRCUIT SIGNAL AND/OR TCC/CRUISE BRAKE PEDAL PARAMETERS, WHEN BRAKE PEDAL IS RELEASED BUT SHOWS APPLIED. Read More »
GM: THE DRIVER OR PASSENGER HEATED SEAT ARE INOPERATIVE. THEY ARE SLOW TO WARM OR MAY SHUT OFF. THERE ARE TROUBLE CODES SET RELATED TO THE GROUND TERMINAL HARNESS. *RM Read More »
GMC/CHEVROLET/CADILLAC: INSTRUMENT PANEL MESSAGES REGARDING STABILITRAK MESSAGE, TRACTION CONTROL MESSAGE, SERVICE BRAKE SYSTEM MESSAGE, IS OFF AND GAUGES, IN VARIOUS MODULES LOW SPEED SETTINGS, ARE INOPERATIVE. Read More »
GENERAL MOTORS: DURING NORMAL DIAGNOSTICS AND/OR REPAIR VERIFICATION THE ABS LIGHT, TRACTION CONTROL AND/OR STABILITRAK INDICATORS MAY BE ON WITH NO DTC'S DISPLAYED BY THE EBCM. *PE UPDATED 11/17/10. *PE UPDATED 3/14/11. Read More »
GMC/CHEVROLET/CADILLAC: INSTRUMENT PANEL MESSAGES REGARDING STABILITRAK MESSAGE, TRACTION CONTROL MESSAGE, SERVICE BRAKE SYSTEM MESSAGE, IS OFF AND GAUGES, IN VARIOUS MODULES LOW SPEED SETTINGS, ARE INOPERATIVE. Read More »
GMC: BMC FAILURE AFTER WINDSHIELD WIPER OPERATION-KEYWORDS: AJAR DOOR DOME DRIVER DIMMER FLASHER FOG HAUL HEADLIGHT HEAD HIGH HAZARD INOP INOPERATIVE LAMP LIGHT LOCK LOW NOT ON OFF POWER PARK RADIO RAP REPEAT SIGNAL SHUT SPEED STAY SWITCH ... Read More »
GM: THE CARPET IS CURLING AT THE TOP FRONT EDGE. THE CARPET WAS FOLDED PRIOR TO INSTALLATION AND WHEN INSTALLED IT CURLS BACK UP. 2007-2012 SILVERADO/SIERRA. *RM Read More »
GENERAL MOTORS: DURING NORMAL DIAGNOSTICS AND/OR REPAIR VERIFICATION THE ABS LIGHT, TRACTION CONTROL AND/OR STABILITRAK INDICATORS MAY BE ON WITH NO DTC'S DISPLAYED BY THE EBCM. *PE UPDATED 11/17/10. *PE UPDATED 3/14/11. Read More »
GMC: BMC FAILURE AFTER WINDSHIELD WIPER OPERATION-KEYWORDS: AJAR DOOR DOME DRIVER DIMMER FLASHER FOG HAUL HEADLIGHT HEAD HIGH HAZARD INOP INOPERATIVE LAMP LIGHT LOCK LOW NOT ON OFF POWER PARK RADIO RAP REPEAT SIGNAL SHUT SPEED STAY SWITCH ... Read More »
SOME CUSTOMERS MAY COMMENT ON VARIOUS HVAC CONCERNS INCLUDING TEMPERATURE DOORS DEFAULTING TO FULL HOT POSITION OR UNABLE TO OBTAIN DEFROST POSITION. *PE Read More »
GM: THE CARPET IS CURLING AT THE TOP FRONT EDGE. THE CARPET WAS FOLDED PRIOR TO INSTALLATION AND WHEN INSTALLED IT CURLS BACK UP. 2007-2012 SILVERADO/SIERRA. *RM Read More »
CADILLAC/CHEVROLET/GMC: ORIGINAL STYLE BLOWER MOTOR ASSEMBLY IS NO LONGER AVAILABLE. A REVISED HVAC BLOWER MOTOR ASSEMBLY FOR FULL SIZE TRUCKS IS REQUIRED, WITH MODIFICATIONS, TO FUNCTION PROPERLY. *PE UPDATED 2/25/13. Read More »
GENERAL MOTORS SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THE HVAC BLOWER MAY NOT WORK AT CERTAIN FUNCTIONS OR MAY BECOME INOPERABLE. THERE COULD BE A BURNING SMELL OR SMOKE. *RM UPDATED 4/6/12. Read More »
SOME CUSTOMERS WHOSE VEHICLES ARE OPERATED IN DUSTY TYPE ENVIRONMENTS, SUCH AS FARMING OR MINING OFF-ROAD TYPE APPLICATIONS, MAY COMMENT ABOUT THE ILLUMINATION OF THE INSTRUMENT PANEL SES LIGHT, WITH DIAGNOSTIC TROUBLE CODE P0446 SET. Read More »
