2005 Chevrolet Silverado
331 Technical Service Bulletins (TSBs)
TSB List for the 2005 Chevrolet Silverado
Technical Service Bulletins (TSBs) for the 2005 Silverado are official communications between Chevrolet & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
STEERING
-
TSB #SB-10-02-33-001
BUICK/CADILLAC/CHEVROLET/GMC/OLDSMOBILE AND HUMMER: INFORMATION ON PITMAN ARM SHAFT SEAL SERVICE KIT. DO NOT REPLACE ENTIRE STEERING GEAR FOR PITMAN SEAL LEAK. Read More »
-
TSB #000235003
CLUNKING NOISE UNDER HOOD AND CAN BE FELT IN STEERING WHEEL. *EH UPDATED *EH UPDATED. *KB Read More »
-
TSB #050235003A
EI05061 - INTERMEDIATE STEERING SHAFT CLUNK NOISE OR STICK-SLIP (FOLLOW STRATEGY BASED DIAGNOSTICS). 05-02-35-003 AND 05-02-35-003A NOT YET RECEIVED. *TT Read More »
-
TSB #060232001
INCREASED STEERING AND BRAKE EFFORT. *TT Read More »
-
TSB #03102005
STEERING GEAR WHISTLE NOISE ON TURNS. *EH Read More »
-
TSB #0502118002
DIAGNOSTIC TROUBLE CODE C0455, SERVICE REAR WHEEL STEERING, SYSTEM JUMPS FROM 4-WHEEL STEER TO 2-WHEEL STEER. *TT Read More »
-
TSB #0502118001
QUADRASTEER INTERMITTENT SERVICE 4-WHEEL STEER MESSAGE. *TT Read More »
-
TSB #3057
SERVICE 4 WHEEL STEER MESSAGE WITH DIAGNOSTIC TROUBLE CODE C0455. *EH Read More »
STEERING:COLUMN
-
TSB #000235003N
CLUNKING NOISE UNDER HOOD AND CAN BE FELT IN STEERING WHEEL AND/OR STEERING COLUMN (REPLACE UPPER INTERMEDIATE STEERING SHAFT [I-SHAFT] ASSEMBLY). *PE Read More »
STEERING:GEAR BOX:SHAFT PITMAN
-
TSB #SB-10-02-33-001
BUICK/CADILLAC/CHEVROLET/GMC/OLDSMOBILE AND HUMMER: INFORMATION ON PITMAN ARM SHAFT SEAL SERVICE KIT. DO NOT REPLACE ENTIRE STEERING GEAR FOR PITMAN SEAL LEAK. Read More »
STEERING:HYDRAULIC POWER ASSIST SYSTEM
-
TSB #3386
LACK OF STEERING ASSIST OR SHUDDER DURING PARKING LOT TYPE MANEUVERS. *TT Read More »
STEERING:HYDRAULIC POWER ASSIST:PUMP
-
TSB #050232008
GEAR BOX POWER STEERING PUMP, P/S PERFORMANCE CONCERNS. *NJ UPDATED ON 6/30/2011. *KB Read More »
STEERING:LINKAGES:ARM:IDLER AND ATTACHMENT
-
TSB #3499
STEERING IDLER ARM INSPECTION PROCEDURE. *TT Read More »
SUSPENSION
-
TSB #3009
SUSPENSION VIBRATION OR FRAME BEAMING AT 40 - 60 MPH. *KB UPDATED 8/25/08. *PE Read More »
-
TSB #010310010
INSPECTION OF TIRE AND WHEEL SIZE PRIOR TO DIAGNOSIS OF TRANSMISSION SHIFTS, POOR PERFORMANCE, SPEEDOMETER, CRUISE CONTROL CONCERNS. *KB Read More »
-
TSB #060310003
INFORMATION ON P245/75R16 GOODYEAR WRANGLER ST TIRE USAGE/IDENTIFICATION. *TT Read More »
-
TSB #030310006
REFERENCE GUIDE FOR THE TECHNICIAN TO UPGRADE A VEHICLE FROM FACTORY WHEELS AND TIRES TO 20 INCH WHEELS AND TIRES, WHICH ARE AVAILABLE THROUGH GMSPO. *TT Read More »
-
TSB #050307006
REVISED WHEEL ALIGNMENT SPECIFICATIONS. *TT Read More »
-
TSB #020307002
REVISED FRONT CASTER AND CAMBER ADJUSTMENT PROCEDURE. ORIGINAL NOT YET RECEIVED. *TT Read More »
-
TSB #050310002
AVAILABILITY OF NEW FUNCTIONAL NUT CAPS FOR STEEL WHEELS. *TT Read More »
-
TSB #010310010C
INSPECTION OF TIRE AND WHEEL SIZE PRIOR TO DIAGNOSIS OF TRANSMISSION SHIFTS, POOR PERFORMANCE, SPEEDOMETER, CRUISE CONTROL CONCERNS. BULLETIN 01-03-10-010B NOT RECEIVED. *TT Read More »
-
TSB #3379
8.625 AXLE PHASING, GROWL, CYCLIC, NOISE WHILE DRIVING. *TT Read More »
SUSPENSION:FRONT:SPRINGS:LEAF SPRING ASSEMBLY:U-BOLT, LEAF SPRING TO AXLE
-
TSB #3340
LEFT FRONT AXLE SHAFT DIFFICULT TO REMOVE. AXLE DIFFERENTIAL LEAK SEAL SHAFT. *KB Read More »
SUSPENSION:FRONT:CONTROL ARM:UPPER ARM
-
TSB #060308002
REVISED UPPER CONTROL ARM REPLACEMENT. *TT Read More »
SUSPENSION:FRONT:WHEEL BEARING
-
TSB #3078
GREASE LEAK FROM FRONT HUB BEARING. *TT UPDATE. *TT Read More »
SUSPENSION:FRONT:HUB
-
TSB #609
FRONT HUB BEARING GREASE LEAK. *SC Read More »
SUSPENSION:REAR
-
TSB #PIP4054A
EATON LOCKING DIFFERENTIAL CHATTER SHUDDER NOISE ON TURNS, EQUIPPED WITH A LOCKING REAR DIFFERENTIAL RPO G80. *NJ UPDATED 7/17/2008. *PE Read More »
-
TSB #3000A
REAR AXLE LOCKING DIFFERENTIAL CHATTER SHUDDER NOISE ON TURNS. *MJ Read More »
SUSPENSION:REAR:AXLE:SPINDLE
-
TSB #050420001
REAR AXLE FLUID LEVEL MAY APPEAR TO BE LOWER THAN PUBLISHED SPECIFICATION. *EH Read More »
SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY
-
TSB #060417002
REAR DRIVE AXLE WHINE NOISE (REPLACE SLIP YOKE ASSEMBLY). *KB Read More »
-
TSB #3569
SERVICE VME - 8.6 INCH REAR AXLE WHICH EXHIBIT A GEAR WHINE CONDITION (UNTIL DECEMBER 23, 2005). *TT Read More »
SERVICE BRAKES, HYDRAULIC
-
TSB #702
BRAKE TWANG NOISE. GM TECH LINKS. *TT Read More »
-
TSB #3559
LOW BRAKE FLUID LEVEL SOURCE OF LEAK UNKNOWN. *SC Read More »
-
TSB #612
SERVICE ENGINE SOON LIGHT ILLUMINATED. DIAGNOSTIC TROUBLE CODE (DTC) P0171 AND/OR P0174 (LEAN FUEL TRIM) MAY BE SET. MASTER CYLINDER O-RING DAMAGED. GM TECH LINK. *TT Read More »
-
TSB #3156
REAR PARK BRAKE CABLE MAY NOT BE PROPERLY CONNECTED. *TC GM ADMINISTRATIVE MESSAGE. *TT Read More »
-
TSB #3092
BRAKE DUST ACCUMULATION. *SC Read More »
-
TSB #3568A
SERVICE BRAKE BOOSTER MESSAGE. *TT Read More »
-
TSB #3685
BRAKE DRAG OR HIGHWAY SPEED VIBRATION. *TT Read More »
-
TSB #3326
CREAK/TWANG NOISE ON BRAKE PEDAL APPLY ORE RELEASE. *TT Read More »
-
TSB #3728
SERVICE VME - BRAKE PULSATION DUE TO ROTOR CORROSION. *TT Read More »
-
TSB #3779
SQUEAK NOISE ON BRAKE APPLY. *TT Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
-
TSB #SB-13-05-22-001
CHEVROLET/GMC/CADILLAC: ANYTIME HYDRAULIC BRAKE PIPES ASSEMBLY NEED REPLACING, PRE-FORMED AND PRE-FLARED BRAKE PIPES ARE AVAILABLE, EXCEPT REAR AXLE CROSSOVER PIPE. Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
-
TSB #SB-13-05-22-001
CHEVROLET/GMC/CADILLAC: ANYTIME HYDRAULIC BRAKE PIPES ASSEMBLY NEED REPLACING, PRE-FORMED AND PRE-FLARED BRAKE PIPES ARE AVAILABLE, EXCEPT REAR AXLE CROSSOVER PIPE. Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
-
TSB #030525007
ANTILOCK BRAKE (ABS) ACTIVATION AT LOW SPEEDS (CLEAN WHEEL SPEED SENSOR MOUNTING SURFACE). *TT UPDATED 10/23/09. *PE Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
-
TSB #040525002B
ANTI-LOCK BRAKE SYSTEM (ABS) LIGHT ON, DIAGNOSTIC TROUBLE CODES (DTCS) C0265, C0201, U1041 SET AND/OR LOSS OF COMMUNICATION WITH BRAKE MODULE. *TT UPDATE. *TT Read More »
SERVICE BRAKES, AIR
-
TSB #4024
REAR BRAKE PULSATION CHECK DRUM TO AXLE CLEARANCE, WITH RPO JF3 OR JF7. *KB Read More »
-
TSB #3250
SERVICE ENGINE SOON LIGHT ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0171 OR P0174 SET. THE ROOT CAUSE MAY BE A DAMAGED OR MISSING SEAL FROM THE MASTER CYLINDER TO THE BRAKE BOOSTER. *EH Read More »
-
TSB #3568
SERVICE BRAKE BOOSTER MESSAGE. *KB Read More »
SERVICE BRAKES, AIR:DRUM
-
TSB #3958
REAR DRUM BRAKES EXCESSIVE WEAR, DRAG, AND AGGRESSIVE. *KB Read More »
SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT
-
TSB #040525002
ABS LIGHT ON, DTC'S C0265, C0201, U1041 SET AND/OR LOSS OF COMMUNICATION WITH BRAKE MODULE. (REGROUND EBCM GROUND). *KB Read More »
PARKING BRAKE:CONVENTIONAL:MECHANICAL:LINKAGE AND CABLE
-
TSB #040526002
PARKING BRAKE MAY NOT HOLD. *TT Read More »
ENGINE (PWS)
-
TSB #SB-080604003-C
GMC/CHEVROLET: ENGINES, WITH EGR SYSTEM, HAS LEAKAGE FROM EGR COOLER ENGINE COOLANT INTO THE COMBUSTION CHAMBER. MODEL 2002-15 SILVERADO, SIERRA, 2004-09 KODIAK C4500-C5500, TOPKICK C4500-C5500, 2006-15 EXPRESS, SAVANA. Read More »
ENGINE AND ENGINE COOLING
-
TSB #PIP-4138K
GM: THE SERVICE ENGINE SOON LIGHT IS ON, THERE IS ALSO A MISFIRE OR ENGINE NOISE. THERE ARE MULTIPLE POSSIBLE CAUSES. *RM Read More »
-
TSB #3187
ENGINE LOW POWER WILL NOT GO OVER 2300 RPMS. *EH UPDATED 6/11/10. *PE Read More »
-
TSB #3317
HARD START / NO START OUTSIDE TEMPERATURES BELOW FREEZING. *TT UPDATED 7/13/09. *PE Read More »
-
TSB #030604036
INFORMATION ON SERVICING FUEL INJECTORS TO AVOID CONTAMINATION. *EH UPDATED 03-19-07. *KB Read More »
-
TSB #050849026
LOW OIL PRESSURE MESSAGE DISPLAY AND CHIMES ACTIVATED WHILE DRIVING FOLLOWING HYBRID (HP2) LM7 ENGINE AUTO-START (REPROGRAM THE PCM). *TS Read More »
-
TSB #050601034
ENGINE OIL LEAK AT REAR COVER ASSEMBLY AREA. *TT Read More »
-
TSB #0509610018
ACCESSORY DRIVE BELT CHIRP, SQUEAL, OR SQUEAK TYPE NOISE AT COLD IDLE. *TT Read More »
-
TSB #050603001
REVISED ENGINE ELECTRICAL AND AUTOMATIC TRANSMISSION - 4L60E/4L65E SUBSECTIONS - NEW CAUTION STATEMENTS ADDED. *TT Read More »
-
TSB #050604023
REVISED DIAGNOSTIC TROUBLE CODE (DTC) P2563. *TT Read More »
-
TSB #050604024
REVISED DIAGNOSTIC TROUBLE CODE (DTC) P1172 AND DTC P2636. *TT Read More »
-
TSB #050090001
INFORMATION ON THE PROPER AIR FILTER FOR THE DURAMAX DIESEL. *EH Read More »
-
TSB #020601023C
OIL LEAK AT COOLER TO ENGINE BLOCK MATING SURFACE. *EH Read More »
-
TSB #07282004
STOP DELIVERY OF CERTAIN VEHICLES EQUIPPED WITH A 5.3 LITER ENGINE. *EH Read More »
-
TSB #3160
GAS ENGINES EXHAUST BUZZ OR RATTLE NOISE. *TC Read More »
-
TSB #3121
EXHAUST VIBRATION RESONANCE OR MOAN. (2004-2005 GMC DENALI) *SC Read More »
-
TSB #3107
P0420 AND P0430 DTSC IN THE DETROIT, MICHIGAN AREA WITH GEN III V-8 ENGINES. *SC Read More »
-
TSB #3193
EXCESSIVE OIL CONSUMPTION. *EH Read More »
-
TSB #3204
COOLANT LEAK AT ENGINE MOUNT BOLT. *EH Read More »
-
TSB #3011B
ENGINE OIL LEAK AT MAIN BERING SIDE BOLT. *EH Read More »
-
TSB #3087
CRANK NO START, STALL, HARD START, AND NO CRANKING RPM. *EH Read More »
-
TSB #3068B
TURBO AIR CHARGE COOLER HOSES OIL SEEPAGE OR BLOWS OFF ON ACCELERATION. THIS ALSO INCLUDES 2004-2005 LLY C2 C3 C4 C5 K2 K3 D4 D5 E4 E5 MODELS. *EH Read More »
-
TSB #3212A
FUEL LEAKING FROM BODY OF INJECTOR. THIS ALSO INCLUDES 2004-2005 LLY C2 C3 C4 C5 K2 K3 D4 D5 E4 E5 MODELS. *EH Read More »
-
TSB #3227
BROKEN #2 AND #7 INJECTOR CONNECTOR TERMINALS. THIS ALSO INCLUDES LLY 6.6 C2 C3 C4 C5 K2 K3 D4 D5 E4 E5. *EH Read More »
-
TSB #3230
DIESEL OIL LEAK AT RIGHT REAR OF ENGINE. THIS INCLUDES LLY C2 C3 C4 C5 D4 D5 E4 E5 K2 K3 MODELS. *EH Read More »
-
TSB #3238C
FUEL INJECTOR DRIVER CIRCUIT CODES P0201 THROUGH P0208. THIS ALSO INCLUDES 2004 2005 LLY C2 C3 C4 C5 E4 E5 D4 D5 K2 K3 MODELS. *EH UPDATED *EH Read More »
-
TSB #3292
DIESEL ENGINE BALANCE RATES ALL SHOWING ZERO. *EH Read More »
-
TSB #3375
ROUGH IDLE, SERVICE ENGINE SOON (SES)LIGHT, UNSTABLE IDLE, HESITATION, SURGE OR STALLING. WITH DIAGNOSTIC TROUBLE CODES P0300, P0335 OR P0336. *TT Read More »
-
TSB #3328A
SURGE AT IDLE OR 1100 TO 1400 RPM. *EH Read More »
-
TSB #3639
OIL PRESSURE GAUGE READING LOW OR NEAR RED ZONE. *TT Read More »
-
TSB #3100C
SES LIGHT DUE TO DTC P0116. *TT Read More »
ENGINE AND ENGINE COOLING:ENGINE
-
TSB #UIB-117
GENERAL MOTORS: AN OPTIONAL ENGINE BLOCK HEATER PLUG IN FOR ONBOARD AC POWER AND WITH CONTINUOUS USAGE WILL RESULT IN SHORTING OF WIRES, OVER HEATING SYSTEM, ELECTRICAL FAILURE AND COMPARTMENT ENGINE FIRES. Read More »
-
TSB #PIP-4492P
BUICK/CADILLAC/CHEVROLET/GMC/HUMMER/PONTIAC/SAAB: OIL CONSUMPTION AND/OR EXHAUST SMOKE-POSSIBLE PCV BAFFLE OR LIFTER CONCERN. UPON INSPECTION, OBVIOUS OIL WILL BE FOUND IN THE INTAKE MANIFOLD AND/OR PCV VACUUM TUBE. Read More »
-
TSB #3317
HARD START / NO START OUTSIDE TEMPERATURES BELOW FREEZING. *TT UPDATED 7/13/09. *PE Read More »
-
TSB #05-06-04-047
SERVICE ENGINE SOON (SES) LIGHT ON WITH REDUCTION IN ENGINE POWER, DIAGNOSTIC TROUBLE CODES P0202 AND P2146 OR P0207 AND P2149 SET. *TT ADD DTC P1294. Read More »
-
TSB #060139002
FRONT BLOWER MOTOR INOPERATIVE OR MAY NOT SHUT OFF IN EXTREMELY LOW AMBIENT TEMPERATURE CONDITIONS. *KB Read More »
-
TSB #040604001
VARIOUS INTERMITTENT DRIVEABILITY CONDITIONS - HESITATION, LACK OF POWER, ETC. *TT Read More »
-
TSB #060604026
INTERMITTENT SES/MIL LAMP ILLUMINATED, REDUCED ENGINE POWER, FUEL INJECTOR DRIVER CIRCUIT. DTC'S P0201, P0202, P0203, P0204, P0205, P0206, P0207, P0208. CYLINDER BANK SHUT DOWN DTC'S P2146, OR P2149. Read More »
-
TSB #030693001
DIAGNOSTIC INFORMATION ON TURBOCHARGER MALFUNCTION DUE TO LACK OF ENGINE OIL FOR LBZ, LB7, AND LLY DURAMAX DIESEL ENGINE. *KB Read More »
-
TSB #050604077
LACK OF POWER LU3 ENGINE) AT HIGH AMBIENT TEMPERATURES ONLY (IF NECESSARY, REPROGRAM PCM WITH NEW SERVICE CALIBRATION).*AK Read More »
-
TSB #050604063
LM7, L59 OR L33 ENGINES WITH COLD START ROUGH OR INCORRECT IDLE, MISFIRE, MALFUNCTION INDICATOR LAMP (MIL) OR FLASHING REQUIRING O2 SENSOR REPLACEMENT. *TT Read More »
-
TSB #050601029
INFORMATION ON 4.3L ENGINE FRONT CRANKSHAFT PULLEY APPEARING TO BE OUT OF ROUND (NORMAL CONDITION). *TT Read More »
-
TSB #040604070
INFORMATION ON THE REVISED FUEL FILTER FOR THE 6.6L DURAMAX DIESEL. *TT Read More »
-
TSB #040602006
ENGINE OVERHEATING. *TT Read More »
-
TSB #050601014
OIL LEAK UNDER EXTREME COLD TEMPERATURES (-34 DEGREES C) (-30 DEGREES F) OR COLDER). *TT Read More »
-
TSB #050604008
DIAGNOSTIC TROUBLE CODE (DTC) P1172 OR P2636, FUEL GAUGE READS EMPTY, SERVICE ENGINE SOON (SES) LIGHT ON. *TT Read More »
-
TSB #702
DURAMAX AIR FILTER. GM TECH LINKS. *TT Read More »
-
TSB #040601027
MIS-MACHINED ENGINE OIL GALLERY - INSPECT/REPLACE ENGINE. VARIOUS 2005 MODELS INCLDING CHEVROLET EXPRESS. *NM ACTUAL SERVICE BULLETIN. *TT Read More »
-
TSB #3004
4.8L 5.3L 6.6L 8.1L P1285 P1286 OR P2133 AFTER REPLACING APP SENSOR. *MJ Read More »
-
TSB #3087
CRANK NO START WITH NO CRANKING RPM SPARK OR INJECTOR PULSE. *TT Read More »
-
TSB #3055
SERVICE ENGINE SOON LIGHT WITH A P0300 MISFIRE DUE TO MISFIRES MAINLY ON CYLINDER 7. *TT Read More »
-
TSB #3056
CHECK ENGINE LIGHT WITH A P0300 DUE TO 2-4 CYLINDERS MISFIRING ON THE SAME BANK OF THE ENGINE. *TT Read More »
-
TSB #3282
ENGINE OVERHEAT ON VEHICLES EQUIPPED WITH RPO VYU SNOWPLOW PREP PACKAGE. *TT Read More »
-
TSB #3293
P0622 OR CHARGE INDICATOR ON AFTER CALIBRATING ENGINE CONTROL MODULE (ECM). *TT Read More »
-
TSB #3346
THERE HAS BEEN A HIGH PERCENTAGE OF NO TROUBLE FOUND (NTF) 6.6 LLY ENGINE CONTROL MODULES (ECMS) BEING RETURNED TO THE WARRANTY PARTS CENTER. Read More »
-
TSB #3232
1999 - 2005 GEN II COLD ENGINE MISFIRE AT IDLE WITH POSSIBLE P0171 AND/OR P0174. *TT Read More »
-
TSB #3479C
ENGINE KNOCK NOISE HEARD AT ALL TIMES. *TT Read More »
-
TSB #3394
6.6 LLY INJECTOR DRIVER CODES. MISFIRE, ROUGH RUNNING, AND THE MIL/SES LIGHT ON. *SC Read More »
-
TSB #3479A
LOWER END ENGINE KNOCK NOISE. *SC Read More »
-
TSB #3267
DIAGNOSTIC TROUBLE CODE P0128 OR ENGINE WILL NOT REACH OPERATING TEMPERATURE. *SC Read More »
-
TSB #3258
6.6L LLY ENGINE OIL LEAK AT REAR HOUSING COVER BOLT. *TT Read More »
-
TSB #3343
ENGINE OIL DIPSTICK UNSEATED OR OIL LEAK. *TT Read More »
-
TSB #3484A
INTERMITTENT STALL, LOW POWER, AND HARD RESTART WHEN THE VEHICLE IS USED DURING HIGH AMBIENT TEMPERATURES AND IN HIGH ALTITUDES. *TT Read More »
-
TSB #3691B
GENERATION III V8 ENGINE PISTON REPAIRS. *TT Read More »
-
TSB #4231
SERVICE VME. SUPPLEMENT TO 00-02-35-003L. UPDATE ON NEW I-SHAFT. *KB Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
-
TSB #020601027
INFORMATION ON HIGHER THAN EXPECTED OIL CONSUMPTION. NLM Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
-
TSB #3436
ACCESSORY DRIVE BELT NOISE ON COLD START - REPOSITION POWER STEERING PUMP PULLEY. *TT Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
-
TSB #10292004
THIS IS IN REGARDS TO THE UNNECESSARY CHANGING OF TURBOCHARGERS DUE TO OIL SEEPAGE. *TT Read More »
-
TSB #3068
OIL SEEPAGE FROM TURBO AIR CHARGE COOLER HOSES OR HOSE BLOWING OFF DURING ACCELERATION. POSSIBLE DIAGNOSTIC TROUBLE CODE P0299. *TT UPDATED 04-24-07. *KB Read More »
-
TSB #3348
NOISE, SERVICE ENGINE SOON (SES) LIGHT, OR LOW POWER. DEALER MAY FIND TURBINE (EXHAUST SIDE) WHEEL RUB DAMAGE, A BROKEN TURBINE SHAFT, OR TURBO BEARING CONCERN. *TT Read More »
-
TSB #3401
TURBOCHARGER OIL FEED LINE KINKED OR RESTRICTED. *TT Read More »
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
-
TSB #PIP-3504C
GM: THERE IS A DIESEL ENGINE HARD START WHEN HOT. STARTS FINE WHEN COLD. THERE WILL BE NO INTERNAL TROUBLE CODES. *RM Read More »
-
TSB #PIP-4629
CHEVROLET/GMC: DIESEL ENGINE TURBO DTC P2563 OR P003A. MAY ENCOUNTER A CONCERN OF SES LIGHT, REDUCED POWER, LOW POWER. *PE Read More »
-
TSB #070601009
DIESEL ENGINE CYLINDER HEAD GASKET MISSING THICKNESS GRADE MARKINGS. *KB Read More »
-
TSB #030693001A
DIAGNOSTIC INFORMATION FOR TURBO FAILURE DUE TO LACK OF OIL OR REPEAT TURBO FAILURES. *TT Read More »
-
TSB #3504
HARD START HOT ONLY AFTER THE ENGINE HAS REACHED OPERATING TEMPERATURE AND THEN SHUT OFF. *TT Read More »
-
TSB #3450
DURAMAX DIESEL HESITATION OR BACKFIRE. *TT Read More »
-
TSB #3225A
01-05 6.6 LLY LB7 DURAMAX DIESEL ENGINE AIR FILTER USAGE. *SC Read More »
-
TSB #3328B
ENGINE RPM SURGE AT 1100 TO 1400 RPM. THIS CONDITION MAY BE NOTICED MORE WHEN TOWING. *TT Read More »
ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER
-
TSB #PIP-4629
CHEVROLET/GMC: DIESEL ENGINE TURBO DTC P2563 OR P003A. MAY ENCOUNTER A CONCERN OF SES LIGHT, REDUCED POWER, LOW POWER. *PE Read More »
-
TSB #01896
6.6 LLY DURAMAX DIESEL ENGINE TURBOCHARGER LEARN PROCEDURE. *MR Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM
-
TSB #3121
EXHAUST VIBRATION RESONANCE OR MOAN IN VEHICLES WITH GEN III V8 ENGINES. *TC Read More »
-
TSB #3413
COOLANT LEAK. EARLY INDICATIONS POINT TO A CORROSION STRESS CRACK ON THE UPPER CLAMP AT THE LOWER RADIATOR HOSE TO THE WATER PUMP CONNECTION. ENGINEERNG IS TESTING....*TT Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
-
TSB #3431A
SERVICE VME - COOLANT LEAK FROM RADIATOR SURGE TANK. *TT Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
-
TSB #PIP-4492P
BUICK/CADILLAC/CHEVROLET/GMC/HUMMER/PONTIAC/SAAB: OIL CONSUMPTION AND/OR EXHAUST SMOKE-POSSIBLE PCV BAFFLE OR LIFTER CONCERN. UPON INSPECTION, OBVIOUS OIL WILL BE FOUND IN THE INTAKE MANIFOLD AND/OR PCV VACUUM TUBE. Read More »
-
TSB #PIP3343
POSSIBLE ENGINE OIL LEAK DUE TO PCV FREEZE-UP, EQUIPPED WITH THE 4.8, 5.3, 6.0, AND 6.2 V-8 ENGINES. *NJ Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
-
TSB #SB-080604003-C
GMC/CHEVROLET: ENGINES, WITH EGR SYSTEM, HAS LEAKAGE FROM EGR COOLER ENGINE COOLANT INTO THE COMBUSTION CHAMBER. MODEL 2002-15 SILVERADO, SIERRA, 2004-09 KODIAK C4500-C5500, TOPKICK C4500-C5500, 2006-15 EXPRESS, SAVANA. Read More »
-
TSB #3256A
VEHICLE MAY BE BROUGHT IN FOR SERVICE ENGINE SOON (SES) OR MALFUNCTION INDICATOR LAMP (MIL) LIGHT ON. *TT Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
-
TSB #3119
ENGINEERING INVESTIGATION - CATALYTIC CONVERTER REPLACEMENT. *SC Read More »
FUEL SYSTEM, GASOLINE
-
TSB #07302004
ENGINE FUEL RAIL CROSSOVER TUBE RETAINER SCREW WERE NOT MANUFACTURED TO SPECIFICATIONS AND MAY BREAK. *EH Read More »
-
TSB #3129A
SMOKE, FUEL KNOCK, SURGING, AND HIGH INJECTOR BALANCE RATES. *TC TO INCLUDE 2005 CHEVROLET KODIAK AND GMC TOPKICK. *TT Read More »
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
-
TSB #3422
DURAMAX DIESEL PILOT TO MAIN INJECTION FUEL KNOCK NOISE. *TT Read More »
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS
-
TSB #3280
RUST FOUND IN THE INJECTOR INLET FILTER DURING INJECTOR REPAIRS. *TT Read More »
-
TSB #3525
SERVICE VMX - DURAMAX INJECTOR WIRING HARNESS SUPPORT BRACKET KIT. *TT Read More »
-
TSB #3400
ROUGH IDLE, FUEL KNOCK OR SMOKE WHILE DRIVING, COMBUSTION LEAK TYPE NOISE, OR A MISFIRE. 6.6 LLY INJECTOR KNOCK, HEAVY SMOKE DURING WARM UP CYCLE. *TT Read More »
FUEL SYSTEM, DIESEL
-
TSB #3394C
DURAMAX DIESEL INJECTOR DRIVER CODES. MISFIRE, ROUGH RUNNING, AND THE MALFUNCTION INDICATOR LAMP (MIL) / SERVICE ENGINE SOON (SES) LIGHT ON. *TT Read More »
FUEL SYSTEM, OTHER
-
TSB #701
FUEL FILTER REPLACEMENT. GM TECH LINK. *TT Read More »
-
TSB #3702
INTERMITTENTLY FUEL FILTER LIFE DISPLAYS 0%. *TT Read More »
-
TSB #3491
HIGHWAY SPEED EXCESSIVE SMOKE AND FUEL KNOCK. *TT Read More »
-
TSB #3616
SERVICE VME - 2006 DURAMAX DIESEL ENGINE FUEL SYSTEM COMPONENTS ARE NOT INTERCHANGEABLE WITH EARLIER YEAR MODEL VEHICLES. *TT Read More »
FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM
-
TSB #3630
INACCURATE FUEL GAUGE READINGS/REAR FLOAT ARM STUCK. *TT UPDATED 03-01-07. *KB UPDATED 3/15/10. *PE Read More »
-
TSB #PIT-3046E
GMC: FUEL GAUGE FLUCTUATION IN PARK OR NEUTRAL, CAUSING THE LOW FUEL LIGHT TO ILLUMINATE. *PE Read More »
-
TSB #08136
CHEVROLET\GMC SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ON-BOARD DIAGNOSTICS (OBD)-FUEL LEVEL SENDER-REPROGRAM ENGINE CONTROL MODULE (ECM). CSC WAS RECEIVED. *PE Read More »
-
TSB #4150
DUAL TANKS FUEL GAUGE DEFAULTS TO EMPTY - NEW CALIBRATIONS. STALL START TANK TRANSFER. VEHICLES WITH 6.6L RPO LB7 OR LLY ENGINES. *KB Read More »
-
TSB #3616A
FUEL GAUGE INOPERATIVE OR INACCURATE, THE SERVICE ENGINE SOON MALFUNCTION INDICATOR LAMP ON, OR FRONT FUEL TANK IS OVER FILLED WITH FUEL, TO THE TOP OF THE FILLER CAP. *TT Read More »
-
TSB #3630A
FUEL GAUGE IS INACCURATE OR READS EMPTY ON DIESEL EQUIPPED CHASSIS CAB WITH DUAL TANKS. *TT Read More »
-
TSB #3616
FUEL GAUGE INACCURATE/ DIAGNOSTIC TROUBLE CODE P0461 AND OR P2636/ TRANSFER PUMP WILL NOT SHUT OFF. *TT Read More »
POWER TRAIN
-
TSB #040731006
EXCESSIVE SHIFTER AND/OR ENGINE VIBRATION, BEARING GROWL AND/OR RATTLE TYPE NOISE WHILE DEPRESSING OR RELEASING CLUTCH PEDAL. *TT Read More »
-
TSB #3054
REPLACEMENT FLEXPLATE MAY HAVE LARGER BOLT HOLES THAN THE ORIGINAL FLEXPLATE. *TT Read More »
-
TSB #3092
ALLISON LCT 1000 BUZZ NOISE FEEL ON TCC APPLY. *SC Read More »
-
TSB #00837
ALLISON LCT1000 OVERDRIVE DISABLE LAMP INOPERATIVE AFTER INSTALLATION OF INSTRUMENT PANEL (IP). *TT Read More »
-
TSB #3151
ALLISON LCT1000 TRANSMISSION HARD TO REMOVE FROM PARK. *TT Read More »
-
TSB #3083
M74 ALLISON LCT1000 PTO GEAR APPLICATIONS. *TT Read More »
-
TSB #3105C
PING, POP, SNAP, OR CLICK NOISE FROM THE PROPELLER SHAFT. *SC Read More »
-
TSB #3156
261 TRANSFER CASE DRIVELINES GROWL 1100-1200 RPM. *TT Read More »
-
TSB #3205
ALLISON LCT1000 PUMP SEPARATOR PLATE CHANGE DISREGARD ADDITIONAL VALVE. *TT Read More »
-
TSB #3303
TRANSMISSION FLUID LEAK FROM THE FRONT OF THE TRANSMISSION. *TT Read More »
-
TSB #3347
HIGH-SPEED 1ST ORDER PROPSHAFT VIBRATION. *TT Read More »
-
TSB #3352
SERVICE 4WD LIGHT ON WITH EITHER A VARIETY OF DIAGNOSTIC TROUBLE CODES OR NO COMMUNICATION WITH THE TRANSFER CASE CONTROL MODULE. *TT Read More »
-
TSB #3335A
INVESTIGATION OF PUMP AREA LEAKS. *TT Read More »
-
TSB #3363
4L60E/4L65E NO REVERSE. *TT Read More »
-
TSB #3369
TO BETTER UNDERSTAND SPRAG DAMAGE AN ENGINEERING INVESTIGATION IS BEING CONDUCTED. TYPICAL SYMPTOMS INCLUDE NO FORWARD MOVEMENT IN D4 OR D3 SHIFT LEVER POSITION. MOVEMENT CAN BE OBTAINED IN D2, D1 OR REVERSE. Read More »
-
TSB #3475A
BULLETIN-SIT-BULLETIN-NO FORWARD, SLIPS, DTC P0875 P0876. *SC Read More »
-
TSB #3440
CLUTCH CHATTER ON TRANSMISSION ENGAGEMENT, HARD TO SHIFT, GEAR CLASH. *TT Read More »
-
TSB #3439
NO DRIVE IN D4 OR D3. TO INCLUDE 2005 GMC JIMMY. *TT Read More »
-
TSB #3260
4L80E/4L85E HARSH SHIFT OR SLIP NO TCC APPLY. *TT Read More »
-
TSB #3320
4L65E (RPO M32) TRANSMISSION ACCUMULATOR SPRING USAGE. *TT Read More »
-
TSB #3105
PING, POP, SNAP OR CLICK NOISE FROM THE PROPELLER SHAFT. *TT Read More »
-
TSB #3609A
HARSH 1-2 SHIFT, MALFUNCTION INDICATOR LAMP ILLUMINATED, DIAGNOSTIC TROUBLE CODE P0894 STORED IN PCM. *TT Read More »
POWER TRAIN:CLUTCH ASSEMBLY
-
TSB #3870
CLUTCH PEDAL FADE OR CLUTCH WILL NOT DISENGAGE TYPICALLY WHEN TOWING. *TT Read More »
POWER TRAIN:MANUAL TRANSMISSION
-
TSB #3136
SLIP CONDITION IN 2ND, 3RD, OR 4TH. DAMAGED 2-4 OR 3-4 CLUTCH. *KB UPDATED 10/31/07. *NJ Read More »
-
TSB #4144
ALLISON LCT1000 HARSH 3-2, 2-1 DOWNSHIFT, AND ABS MAY ACTIVATE. *KB Read More »
POWER TRAIN:MANUAL TRANSMISSION:SHIFT PATTERN INDICATOR
-
TSB #05023
SHIFT LEVER POSITION INDICATOR ILLUMINATION RECALL CAMPAIGN. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION
-
TSB #PIP-3366-B
CADILLAC/CHEVROLET/GMC/HUMMER: SOME SUVS AND TRUCKS ARE EXHIBITING A CONDITION WHERE BY GRINDING/RATCHETING TYPE NOISE COMING FROM AUTOMATIC TRANSMISSION WHEN SHIFTING INTO PARK WHILE IN 4WD LOW (4LO) RANGE. Read More »
-
TSB #3927
ENGINE WITH A REPEAT CRACKED FLYWHEEL. *KB Read More »
-
TSB #020730004
NEW PRODUCT INFORMATION, GRADE BRAKE FEATURE OF ALLISON 1000 SERIES TRANSMISSION. *SLC THIS BULLETIN REPLACES 02-07-30-004. *TT Read More »
-
TSB #050730017
4L60-E/4L65-E AUTOMATIC TRANSMISSION/TORQUE CONVERTER CLUTCH (TCC) SHUDDER, WATER IN TRANSMISSION. *TT Read More »
-
TSB #050730013
4L60-E/4L65-E AUTOMATIC TRANSMISSION SECOND GEAR START, LACK/LOSS OF POWER WHEN ACCELERATING FROM A STOP. *TT Read More »
-
TSB #050730012
4L60-E/4L65-E AUTOMATIC TRANSMISSION 2-3 SHIFT CLUNK. *TT Read More »
-
TSB #050730002
NEW ESSENTIAL TOOL J 45096 23 AUTOMATIC TRANSMISSION OIL COOLER LINE ADAPTER FOR ALLISON TRANSMISSION. *EH Read More »
-
TSB #030730044
INFORMATION ON ALLISON TRANSMISSION SERVICE REPAIRS - FULL SERVICE OF INTERNAL COMPONENTS. *TT Read More »
-
TSB #30559
ALLISON LCT1000 DIAGNOSTIC TROUBLE CODE P1711, P0872 AFTER COMPLETING REPAIRS. *TT Read More »
-
TSB #3259C
4L80E, 4L85E WHINE NOISE IN FIRST AND SECOND GEAR. *TT Read More »
-
TSB #3161
ALLISON LCT1000 CLUNK NOISE ON START IN PARK. *EH Read More »
-
TSB #3170
HARSH 1-2 SHIFT. *EH Read More »
-
TSB #3243
LEAK FROM THE VENT 4L80E/4L85E TRANSMISSION. *EH Read More »
-
TSB #3309
INVESTIGATION OF EXTENSION SEAL LEAKS ON 4L60E AUTOMATIC TRANSMISSION. *TT Read More »
-
TSB #3371
4L80E/4L85E AUTOMATIC TRANSMISSION LEAK CONCERN. *TT Read More »
-
TSB #3497
RANGE INHIBIT AND/OR WILL NOT MOVE. *TT Read More »
-
TSB #3438A
TCC SURGE AND/OR FLUID CONTAMINATION. *TT Read More »
-
TSB #3488
FLUID LEAKAGE FRONT PUMP OR TORQUE CONVERTER AREA. *TT Read More »
-
TSB #3136
SLIP CONDITION IN 2ND, 3RD, OR 4TH. DAMAGED 2-4 OR 3-4 CLUTCH. *KB UPDATED 10/31/07. *NJ Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
-
TSB #PIP-4290
ENGINE SURGE OR STALL AT STOP AND/OR DTC P0742 POSSIBLE TCC APPLIED. EQUIPPED WITH ALLISON LCT1000 TRANSMISSION RPO M74 OR MW7. *NJ UPDATED 4/22/13. *PE Read More »
-
TSB #PIP3394
DURAMAX DIESEL INJECTOR DRIVER CODES WITH 6.6 ENGINE (VIN 2 - RPO LLY). *NJ Read More »
-
TSB #05539
PRODUCT EMISSION RECALL TO REPLACE THE POWERTRAIN/ENGINE CONTROL MODULE (PCM/ECM). THE POWERTRAIN/ENGINE CONTROL MODULE (PCM/ECM) MAY HAVE BEEN MANUFACTURED WITH DAMAGED INTERNAL IC CHIPS, WHICH MAY AFFECT THE FUEL PUMP CONTROL AND EGR ... Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
-
TSB #020730024A
DIAGNOSIS OF CRACKED OR BROKEN TRANSMISSION CASE. *TT 2006 AND PRIOR CARS AND LIGHT DUTY TRUCKS. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
-
TSB #PIT-4722
GMC: FLUID LEAK FROM TRANSMISSION OIL COOLER LINES DUE TO CORROSION. ALL 2000-2006 LIGHT DUTY TRUCKS EQUIPPED WITH THE LIGHT DUTY AUTOMATIC TRANSMISSION. *PE Read More »
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
-
TSB #05-04-21-003
SERVICE 4WD LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODE (DTC) C0374 SET. *TT UPDATED 10/05/07. *NJ INSPECT WIRING HARNESS TO TRANSFER CASE SPEED SENSORS, REPLACE WIRING HARNESS. Read More »
-
TSB #3132A
NVG149 NP3 TRANSFER CASE MAY EXHIBIT A BIND OR SHUDDER ON TURNS. *TC Read More »
-
TSB #3134B
SERVICE 4WD INDICATOR ILLUMINATED. *TC WITH DIAGNOSTIC TROUBLE CODE CO327. *TT Read More »
-
TSB #3351
INTERMITTENT MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) C0374 OR ERRATIC 4WD/AWD OPERATION. *TT Read More »
-
TSB #3526
INTERMITTENT SERVICE 4WD LIGHT COMES ON WITH DIAGNOSTIC TROUBLE CODE (DTC) C0306 OR C0308 STORED IN TCCM. *TT Read More »
-
TSB #3424
ELECTRONIC TRANSFER CASE UNABLE TO COMPLETE SHIFT. *TT Read More »
-
TSB #3480A
RATTLE NOISE AT HIGHWAY SPEED IN 2WD. *TT Read More »
-
TSB #3665
4WD INOPERATIVE AND POSSIBLE DTC C0327 STORED IN THE TRANSFER CASE CONTROL MODULE. *TT Read More »
POWER TRAIN:DRIVELINE
-
TSB #3300
4WD MODELS WITH NOISE, VIBRATION ON DRY PAVEMENT. *EH Read More »
POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT
-
TSB #PIP4054A
EATON LOCKING DIFFERENTIAL CHATTER SHUDDER NOISE ON TURNS, EQUIPPED WITH A LOCKING REAR DIFFERENTIAL RPO G80. *NJ UPDATED 7/17/2008. *PE Read More »
POWER TRAIN:AXLE ASSEMBLY
-
TSB #702
THE FACTORY LUBRICANT FILL LEVEL MAY APPEAR LOWER THAN THE PUBLISHED SPECIFICATION ON VEHICLES EQUIPPED WITH THE 11.5-INCH RING GEAR REAR AXLE ASSEMBLY. *TT Read More »
-
TSB #3001
THE SERVICE INFORMATION AND OWNERS MANUAL DO NOT SHOW A SERVICE INTERVAL FOR THE 8.6, 9.5, 9.75, 10.5, AND 11.5 INCH REAR AXLES WITH OR WITHOUT G80 (LOCKING DIFFERENTIAL). Read More »
-
TSB #3137
SERVICE 4WD LIGHT ON AND NO COMMUNICATION WITH TRANSFER CASE CONTROL MODULE. *EH Read More »
-
TSB #3294
HIGHWAY SPEED VIBRATION ON SMOOTH SURFACE. *EH Read More »
-
TSB #3364
REAR AXLE RETAINER BUTTON BREAKAGE. *EH Read More »
-
TSB #4030
NEW DESIGN FRONT AXLE SIDE BEARING ADJUSTERS. *KB Read More »
ELECTRICAL SYSTEM
-
TSB #PB-10037A
GM: ONSTAR IS MAKING INCOMPLETE CALLS WITHOUT THE DRIVER KNOWING. WHEN HAVE A DATA CONNECTION. *RM Read More »
-
TSB #08089-B
GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE Read More »
-
TSB #030850014
INTERMITTENT NO START, SERVICE STABILITY MESSAGE, ANTI-LOCK BRAKE SYSTEM (ABS) LIGHT ILLUMINATED, MULTIPLE DIAGNOSTIC TROUBLE CODES (DTCS), DIC SHOWS UNKNOWN DRIVER, VARIOUS ELECTRICAL RELATED CONDITIONS. Read More »
-
TSB #050849010
INFORMATION ON RESETTING THE BATTERY LIGHT IF IT REMAINS ILLUMINATED AFTER (POWERTRAIN CONTROL MODULE) PCM REPLACEMENT. *TT Read More »
-
TSB #040850015
DRIVER SEAT ADJUSTER MEMORY & HEATER SWITCH WILL NOT ILLUMINATE. *TT Read More »
-
TSB #3159
INSTRUMENT PANEL CLUSTER PARTS RESTRICTION. *TC Read More »
-
TSB #3094
ALLISON LCT 1000 P1781 OR P0802 SETTING IN THE ELECTRONIC CONTROL MODULE. (2005 CHEVROLET KODIAK AND 2005 GMC TOP KICK) *SC Read More »
-
TSB #3001
NO COMMUNICATION WITH ANY MODULES, MULTIPE U-DIAGNOSTIC TROUBLE CODES (DTCS), INSTRUMENT PANEL CLUSTER (IPC) WARNING INDICATORS. Read More »
-
TSB #3089
SERVICE ENGINE SOON LIGHT AND REDUCED ENGINE POWER WITH A DIAGNOSTIC TROUBLE CODE P1516. DIAGNOSTIC TROUBLE CODES P0120, P0220, P1514, P1515, P1518 AND P2135 MAY ALSO BE PRESENT. *TT Read More »
-
TSB #3075B
BLOWN MBEC 1 OR LBEC 1 FUSE. *TT Read More »
-
TSB #3061C
DIAGNOSTIC TROUBLE CODE C0327 WITH OR WITHOUT ADDITIONAL DIAGNOSTIC TROUBLE CODES SETTING. *TT Read More »
-
TSB #3391
UNWANTED OPERATION OF THE HAZARD FLASHERS. *EH Read More »
-
TSB #3155
NO SHIFT, SPEEDOMETER ERRATIC/INOPERATIVE, P0721 C0237 P0500 C0055. *TT Read More »
-
TSB #3357
MALFUNCTION INDICATOR LIGHT IS ON AND THE VEHICLE HAS A CODE P0706. *TT Read More »
-
TSB #3427
ADDITIONAL DIAGNOSTIC INFORMATION DTC P0757. *TT Read More »
-
TSB #3190
UNABLE TO LOCATE EMERGENCY LIGHT RELAY AND/OR BLUNT CUT WIRES. *KB Read More »
ELECTRICAL SYSTEM:HORN
-
TSB #3300C
APPLICATION OF HORN AT HORN PAD INOPERATIVE. RKE FUNCTION FOR PANIC ALARM WORKS. *TT Read More »
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
-
TSB #01060A
ROOF BEACON SWITCH LEFT ON CAUSING BATTERY DRAW. GMC GMT 800. *MJ 2005 MODELS ADDED. *TT Read More »
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
-
TSB #3075
BLOWN MBEC 1 OR LBEC 1 FUSE. *KB Read More »
ELECTRICAL SYSTEM:IGNITION
-
TSB #3893
LOSS OF IGNITION 1 VOLTAGE TO THE IGNITION COILS. CONSUMER EXPERIENCED INTERMITTENT STALL, MISFIRE, OR CRANK NO START. THERE MAY BE NO TROUBLE CODES SET. *KB UPDATED 3/17/09. *PE Read More »
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
-
TSB #3331
VOLTMETER IS FLUCUATING BETWEEN 12 AND 14 VOLTS ON THEIR NEW 2005 CHEVROLET/ GMC/ CADILLAC MODEL YEAR LIGHT DUTY FULL SIZE PICKUP AND UTILITY. *SC Read More »
-
TSB #4486
ONE OF THE FOLLOWING CONCERNS WHEN PROGRAMMING THE MILEAGE OR THE HOURS INTO AN EXCHANGE INSTRUMENT PANEL CLUSTER THAT IS RECEIVED FROM AN ELECTRONIC SERVICE CENTER (ESC). *NJ Read More »
ELECTRICAL SYSTEM:SOFTWARE
-
TSB #08089-B
GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE Read More »
EXTERIOR LIGHTING:HEADLIGHTS
-
TSB #3170E
IPC, INTERIOR LIGHTS AND/OR HEADLAMPS FLICKER. *AK FB2 Read More »
EXTERIOR LIGHTING:TURN SIGNAL
-
TSB #3654
TURN SIGNALS INOPERATIVE. *TT Read More »
EXTERIOR LIGHTING:TURN SIGNAL:FLASHER UNIT
-
TSB #070842013
TURN SIGNAL IN CAMPER STYLE OUTSIDE REARVIEW MIRROR (RPO DPN) DOES NOT ILLUMINATE TURN SIGNAL FLASH (REPLACE UPPER MIRROR GLASS) *NJ Read More »
VISIBILITY
-
TSB #3541A
FRONT DOOR GLASS WILL NOT MOVE OR RATTLE IN DOOR. *TT Read More »
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
-
TSB #3713
DOOR GLASS POPS OUT OF RUN CHANNEL. *KB Read More »
-
TSB #3573
UNWANTED OPERATION OF REAR WINDOWS. *TT Read More »
VISIBILITY:REARVIEW MIRRORS/DEVICES
-
TSB #3639
SERVICE VME-OUTSIDE REAR VIEW MIRROR INOPERATIVE. *SC Read More »
VISIBILITY:REARVIEW MIRRORS/DEVICES:INTERIOR
-
TSB #3422
INACCURATE OUTSIDE TEMPERATURE READING ON INSIDE REARVIEW MIRROR. *TT Read More »
VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
-
TSB #3002
SERVICE VME - SWITCHING MIRRORS FROM POWER FOLDING TO POWER EXTENDING. *MJ Read More »
-
TSB #3671
SERVICE VME - OUTSIDE REARVIEW MIRROR VIBRATION. *TT Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR
-
TSB #040139009
HVAC BLOWER MOTOR INOPERATIVE OR STAYS RUNNING. *TT Read More »
-
TSB #3545
BLOWER MOTOR INOPERATIVE AT LOW AMBIENT TEMPERATURES. *TT Read More »
-
TSB #3766
FRONT BLOWER INOPERATIVE STAY RUNNING DURING LOW AMBIENT TEMPERATURE. *TT Read More »
-
TSB #3691A
FRONT HVAC BLOWER INOPERATIVE. *TT Read More »
AIR BAGS
-
TSB #3373
SIR LIGHT ON STEADY AFTER BULB TEST AND NO DIAGNOSTIC TROUBLE CODES (DTCS). *TT Read More »
-
TSB #4179
DUAL STAGE PASSENGER AIR BAG USED IN SINGLE STAGE APPLICATION. *KB Read More »
SEAT BELTS
-
TSB #09-09-40-001A
GM: THERE ARE SEAT BELT PROBLEMS: DIFFICULTY LATCHING AND UNLATCHING BUCKLE. BUCKLE RELEASE BUTTON IS STICKING. SEAT BELT WARNING LIGHT ILLUMINATED. LIKELY CAUSED BY STICKY BEVERAGES THAT ARE SPILLED INTO THE BUCKLE ASSEMBLY. Read More »
SEAT BELTS:FRONT:WEBBING
-
TSB #05-09-40-002E
GM: SERVICE BULLETIN EXPLAINING WHEN THE SAFETY BELTS ARE SUPPOSED TO LOCK. *RM UPDATED 12/6/11. *PE Read More »
SEAT BELTS:FRONT:RETRACTOR
-
TSB #05-09-40-002E
GM: SERVICE BULLETIN EXPLAINING WHEN THE SAFETY BELTS ARE SUPPOSED TO LOCK. *RM UPDATED 12/6/11. *PE Read More »
SEAT BELTS:FRONT:WARNING LIGHT/DEVICES
-
TSB #09-09-40-001A
GM: THERE ARE SEAT BELT PROBLEMS: DIFFICULTY LATCHING AND UNLATCHING BUCKLE. BUCKLE RELEASE BUTTON IS STICKING. SEAT BELT WARNING LIGHT ILLUMINATED. LIKELY CAUSED BY STICKY BEVERAGES THAT ARE SPILLED INTO THE BUCKLE ASSEMBLY. Read More »
SEAT BELTS:REAR/OTHER
-
TSB #3436
SECOND ROW SEAT BELT DOES NOT BUCKLE. *TT Read More »
STRUCTURE
-
TSB #3128
ALL FULL SIZE TRUCKS PICK UP BOX SHEET METAL FRACTURE/DAMAGE WITH AFTERMARKET ACCESSORIES INSTALLED. *SC Read More »
STRUCTURE:FRAME AND MEMBERS
-
TSB #PIT-3749D
GM: ON SOME TRUCK MODELS THERE IS SOME FRAME CORROSION. *RM UPDATED ON 5/2/2012. *KB Read More »
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
-
TSB #050861004
UNDERBODY RATTLE. *TT Read More »
STRUCTURE:BODY
-
TSB #610
RATTLE TYPE NOISE COMING FROM THE REAR OF THE CAB DURING BODY TWIST MANEUVERS OR OVER BUMPS. GM TECH LINK. *TT Read More »
-
TSB #3089
RATTLE TYPE NOISE COMING FROM THE REAR OF THE CAB DURING BODY TWIST MANEUVERS OR OVER BUMPS. *TT Read More »
STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
-
TSB #3464
DOOR HINGE REPLACEMENT KIT. *TT Read More »
STRUCTURE:BODY:TAILGATE
-
TSB #3227
TAILGATE CABLE SLACK. THIS INCLUDES 1998-2006 CHEVROLET AND GMC FULL AND MID SIZE TRUCKS. *EH UPDATED. *KB Read More »
LATCHES/LOCKS/LINKAGES
-
TSB #3189
UNABLE TO DISABLE AUTO DOOR LOCKS. THIS INCLUDES 05 CHEVROLET GMC CADILLAC FULL SIZE TRUCKS AND UTILITIES. *EH ALSO INCLUDES AVALANCE, SILVERADO SUBURBAN TAHOE; GMC SIERRA, YUKON, DENALI, YUKON XL, DENALI XL. UPDATED 8/26/08. Read More »
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
-
TSB #PI-0011A
GM: THE FRONT OR REAR DOOR MAY NOT OPEN FROM THE INSIDE OR OUTSIDE HANDLE, THE DOOR WILL NOT UNLOCK WITH ANY METHOD. THE PROBABLY CAUSE AN INCORRECT INSTALLATION OF A HANDLE COMPONENT. *RM UPDATED ON 7/26/2013. Read More »
-
TSB #3189
UNABLE TO DISABLE AUTO DOOR LOCKS. THIS INCLUDES 05 CHEVROLET GMC CADILLAC FULL SIZE TRUCKS AND UTILITIES. *EH ALSO INCLUDES AVALANCE, SILVERADO SUBURBAN TAHOE; GMC SIERRA, YUKON, DENALI, YUKON XL, DENALI XL. UPDATED 8/26/08. Read More »
VEHICLE SPEED CONTROL
-
TSB #3155
SPEEDOMETER INOPERATIVE. *TC Read More »
-
TSB #3272
DIESEL HESITATION OR THROTTLE DELAY. *SC Read More »
VEHICLE SPEED CONTROL:CRUISE CONTROL
-
TSB #3051
CRUISE CONTROL AND/OR THE POWER TAKE OFF UNIT (PTO) MAY BE INOPERATIVE. *TT Read More »
-
TSB #3073
DOWNHILL CRUISE CONTROL SURGE. *TT Read More »
-
TSB #3673
CRUISE CONTROL INOPERATIVE AND/OR MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0833 STORED. THE CONDITION MAY NOT BE ABLE TO BE DUPLICATED BY THE DEALER YET THE CONSUMER MAY HAVE A REPEAT CONCERN. Read More »
TIRES
-
TSB #PIT4193
P245/70R17 GENERAL AMERITRAC TIRE WEAR VIBRATION. *KB UPDATED 12/13/07. *NJ UPDATED 1/30/08. *NJ UPDATED 5/25/11. *PE Read More »
-
TSB #030310006D
20 INCH WHEELS AND TIRES AVAILABLE THROUGH GMSPO. *EH *TT Read More »
-
TSB #030310002
USE OF CORRECT INSTALLATION PROCEDURE FOR LOOSE HUBCAP ASSEMBLY. THIS SERVICE BULLETIN REPLACES 030310002. *EH Read More »
-
TSB #3157
EXCESSIVE TIRE SPIN SETTING DIAGNOSTIC TROUBLE CODE C0543. *TC Read More »
-
TSB #3132A
NVG149 NP3 TRANSFER CASE MAY EXHIBIT A BIND OR SHUDDER ON TURNS. *TC Read More »
-
TSB #3235
20 INCH WHEELS STOP SELL ON 1500 CREW CAB WITH 5'8' BED. *EH Read More »
-
TSB #3562A
BRIDGESTONE DUELER PRODUCT INFORMATION UPDATE. *TT *SC Read More »
-
TSB #3562
BRIDGESTONE DUELER PRODUCT INFORMATION UPDATE. *KB Read More »
-
TSB #4223
BRIDGESTONE DURAVIS TIRE CHIP AND TEAR ISSUE. *KB Read More »
-
TSB #3425
UNABLE TO PROGRAM TIRE SIZE IN EBCM/VSES. *KB Read More »
WHEELS
-
TSB #050310005
HANDLING CHARACTERISTICS OF VEHICLES WITH 20 INCH WHEEL/TIRE ASSEMBLIES INSTALLED. *TT Read More »
-
TSB #04056
20 INCH PLUS SIZE WHEEL RESTRICTION - SUPPLEMENT TO ACCESSORIES BULLETIN ACC04-056. GM VOICEMAIL EXPRESS. *TT Read More »
-
TSB #3045
VARIOUS STEERING OR SUSPENSION CONCERNS AFTER GM ACCESSORIES 20 INCH TIRE/WHEEL ASSEMBLIES HAVE BEEN INSTALLED. *TT Read More »
-
TSB #3192
AVAILABILITY OF 20 INCH WHEELS AND TIRES THROUGH GMSPO ON 2005 MODELS. *EH Read More »
TRAILER HITCHES:FIFTH WHEEL ASSEMBLY
-
TSB #3343
WHY THE CREW CAB SHORT BED (5 FOOT 8 INCH) IS NOT RECOMMENDED FOR FIFTH WHEEL TRAILERING. *TT Read More »
SEATS
-
TSB #050850012
UNWANTED/LOOSE SEAT MOVEMENT. *TT Read More »
-
TSB #040850016B
MEMORY SEAT MAY NOT RETURN TO REQUESTED POSITION. *EH Read More »
SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
-
TSB #708
HEATED SEATS TURN OFF. *SC Read More »
-
TSB #050850008
INTERMITTENT HEATED SEATS INOPERATIVE, DIAGNOSTIC TROUBLE CODE B3941 SET. *TT Read More »
-
TSB #3287B
HEATED SEAT INOPERATIVE OR SHUT OFF IN 30 SECONDS. DIAGNOSTIC TROUBLE CODES B2435, B2440, B3606 AND/OR B1825 SET IN THE DRIVERS SEAT MODULE. *TT Read More »
INTERIOR LIGHTING
-
TSB #3170E
IPC, INTERIOR LIGHTS AND/OR HEADLAMPS FLICKER. *AK FB2 Read More »
-
TSB #4365
IPC BACKLIGHTING INOPERATIVE TBC 2A FUSE OPEN. *KB Read More »
EQUIPMENT
-
TSB #030844018A
REAR SEAT AUDIO (RSA) AND/OR REAR HVAC INOPERATIVE. *TT UPDATE. *TT Read More »
-
TSB #0508132001
ACCESSORY POWER OUTLET (APO) TURNS OFF AUTOMATICALLY - PARALLEL HYBRID TRUCK (RPO HP2). *TT Read More »
-
TSB #3050A
02-05 ONSTAR EQUIPPED VEHICLES EMITTING BEEPING NOISE BEFORE CONNECTING TO ONSTAR. *TT Read More »
EQUIPMENT:ELECTRICAL
-
TSB #08-089
BUICK\CADILLAC\CHEVROLET\GMC\HUMMER\OLDSMOBILE\PONTIAC\SAAB\SATURN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPECIAL COVERAGE ADJUSTMENT-ANALOG ONSTAR DEACTIVATION. Read More »
EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
-
TSB #03092005
CDS STICK IN CD PLAYER. *EH Read More »
-
TSB #3106
XM RADIO WAS WORKING PRIOR TO JULY 26, 2004 AND IT IS INOPERATIVE NOW. *JB Read More »
EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
-
TSB #08089-B
GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE Read More »
-
TSB #3120
ONSTAR CENTER UNABLE TO PERFORM REMOTE DIAGNOSTIC. (2004-2005 CHEVROLET YUKON, 2005 CHEVROLET TRAILBLAZER, 2002, 2003, 2005 BUICK RAINIER, 2005 CHEVROLET EXPRESS VAN, AND 2005 CADILLAC SEVILLE) *SC Read More »
EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
-
TSB #PIT3504D
SOME CUSTOMERS MAY COMMENT ON VARIOUS HVAC CONCERNS INCLUDING TEMPERATURE DOORS DEFAULTING TO FULL HOT POSITION OR UNABLE TO OBTAIN DEFROST POSITION. *PE Read More »
-
TSB #08-089B
BUICK\CHEVROLET\GMC SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPECIAL COVERAGE ADJUSTMENT-ANALOG ONSTAR DEACTIVATION. CSC LETTER WAS RECEIVED. *PE Read More »
-
TSB #0508111002
REPLACEMENT PROCEDURE IF HYBRID EMBLEM IS MISSING FALLEN OFF. *EH Read More »
-
TSB #07012004
OIL LIFE SYSTEM RESET PROCEDURES-TRUCKS. BUICK TERAZZA 2005, GMC SIERRA DENALI 2002-2003, GMC B7 CHASSIS MEDIUM DUTY 2003-2005 AND GMC 560 C-SERIES 2003-2005 *SC Read More »
EQUIPMENT:APPLIANCE:AIR CONDITIONER
-
TSB #SB-10240
GENERAL MOTORS SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THE HVAC BLOWER MAY NOT WORK AT CERTAIN FUNCTIONS OR MAY BECOME INOPERABLE. THERE COULD BE A BURNING SMELL OR SMOKE. *RM UPDATED 4/6/12. Read More »
-
TSB #050138012
EI05082 - LOSS OF BLOWER MOTOR SPEEDS EXCEPT FOR HIGH SPEED OR INOPERATIVE. *TT UPDATED. *KB UPDATED *KB Read More »
-
TSB #040138013
HVAC NOT COLD ENOUGH A/C COMPRESSOR DOES NOT ENGAGE . *EH Read More »
-
TSB #040138014
HIGH PITCHED TONE HEARD INSIDE VEHICLE WHEN AC COMPRESSOR IS ENGAGED. *EH Read More »
-
TSB #040138010
DIAGNOSTIC INFORMATION TO ACCURATELY DIAGNOSE A/C LOW PRESSURE SWITCH USING NEW KENT MOORE SPECIAL TOOL GE-47742. *TT Read More »
-
TSB #040138008
HEAT VENTILATION AND AIR CONDITIONING SYSTEM CANNOT BE CONTROLLED OR DEFAULTS TO DEFROST MODE. *EH Read More »
-
TSB #3086
AIR CONDITIONER (A/C) LOW PRESSURE SWITCH DIAGNOSTIC TOOL. CURRENTLY THE A/C LOW PRESSURE SWITCH OPEN/CLOSE PRESSURES CANNOT BE ACCURATELY DETERMINED BY MEASURING PRESSURE AT THE LOW SIDE SERVICE PORT. Read More »
UNKNOWN OR OTHER
-
TSB #10-00-89-017C
GM: INFORMATION ON FIXING MULTIPLE SITUATIONS RIGHT THE FIRST TIME. *RM Read More »
-
TSB #990089015C
LIGHT SERVICE SUPPORT VEHICLE LSSV (FORMERLY COMMERCIAL UTILITY CARGO VEHICLE - CUCV II AND III) SERVICE. *TT Read More »
-
TSB #11172004
STOP DELIVERY OF CERTAIN FULL SIZE CREW CAB PICKUP TRUCKS. FLOOR PLAN EXPENSE REIMBURSEMENT INFORMATION. *TT Read More »
-
TSB #11102004
STOP DELIVERY OF CERTAIN FULL SIZE CREW CAB PICKUP TRUCKS BUILT AT THE FLINT ASSEMBLY. *TT Read More »
-
TSB #020139007
AUTOMATIC DUAL ZONE HVAC BATTERY DRAW. *AR Read More »
-
TSB #3656
LCT1000 TOW/HAUL INDICATOR INOPERATIVE WITH RPO 5G8. *KB Read More »
OTHER:SCHOOL BUS STOP ARM ASSEMBLY
-
TSB #3063
PERFORMANCE PACKAGE RPO PCX. *TT Read More »
Browse Other Silverado Years
- 2022 Chevrolet Silverado
- 2021 Chevrolet Silverado
- 2012 Chevrolet Silverado
- 2011 Chevrolet Silverado
- 2010 Chevrolet Silverado
- 2009 Chevrolet Silverado
- 2008 Chevrolet Silverado
- 2007 Chevrolet Silverado
- 2006 Chevrolet Silverado