Print this page

2.2

hardly worth mentioning
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
70,701 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2009 Chevrolet HHR fuel system problems

fuel system problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2009 Chevrolet HHR:

Unsubscribe any time. We don't sell/share your email.

2009 Chevrolet HHR Owner Comments (Page 4 of 4)

« Read the previous 20 complaints

problem #9

Aug 242018

HHR

  • 85,000 miles

A D V E R T I S E M E N T S

Was getting serviced and was informed that fuel lines were all rusted out and leaking very bad. Is GM doing anything about this"?"fire hazard

- Port Charlotte, FL, USA

problem #8

Jan 252017

HHR

  • 68,000 miles
The fuel line from the fuel tank to the engine bends around by the wheel and apparently rubs with everyday driving. Eventually it rubbed a hole in the fuel line. I noticed it after I parked the car and could see fuel dripping in front of the rear wheel. The line from front to back of the car is a single piece and cost something like $700 for the line alone. (stupid) instead of replacing the line I had a rubber fuel line clampped to the line as a temperary fix. After talking to a Chevy dealership and a mechanic at tire discounters, I was told by both places that this is a common problem. Both locations said that they get HHR's with this problem often. This needs to be on a recall list. This service was done on January 25, 2017 and the cost for the fix was $232. Thank you for your time.

- Cincinnati, OH, USA

problem #7

Jul 232018

HHR

  • 127,000 miles
Rusted fuel line at 127,000 miles with gas leaking. I noticed a strong gas smell from the driver side passenger area when outside of the vehicle when parked. After researching found this to be a known issue. The fuel line is not made out of stainless steel and therefor rusts out in areas of the country that use salt on the roads in winter. Huge safety concern. Spoke with GM and received no compensation for sub-par parts used for fuel line on this vehicle when manufactured.

- West Des Moines, IA, USA

problem #6

Jun 202018

HHR

  • 71,200 miles

A D V E R T I S E M E N T S

The fuel lines are rusting and have begun to leak gasoline. Leak occurs while stationary and while driving

- Chicago, IL, USA

problem #5

Jun 202018

HHR

  • 132,000 miles
Started smelling raw gasoline when driving and stationary... discovered fuel line leaking/seeping gas on driver side in front of rear tire, above the hot exhaust. Fuel tank straps are also rusted. This is very common in HHR and cobalt - need to recall before someone dies in a car fire! note: It can be seen in the attached photo - the discoloration of the metal is from it being saturated in gasoline.

- Livonia, MI, USA

Search CarComplaints.com for these popular complaint phrases...

problem #4

Aug 012017

HHR

  • miles
The gas line is rusted and leaking. There is a strong odor of gasoline at the rear drivers side tire of my car. It leaves a fuel on my driveway

- Gansevoort, NY, USA

problem #3

Nov 092017

HHR

  • 90,000 miles

A D V E R T I S E M E N T S

April of 2017 the fuel lines of my HHR rusted and I had them replaced. November of 2017 plastic fuel line connector that connects fuel line to fuel tank failed. While driving home through the city of lancaster I smelled gas. I pulled into a parking lot to inspect and I observed gas leaking from the tank. Gas leaked out while I was parked at a store. The fire department and hazmat had to be called to clean up spilled gas. I had the car towed to my mechanic. He reported to me that the plastic part (22719582) failed. He has been trying to find a part and he reports to me that the part is unavailable. He thinks many other HHR's are experiencing the same problem. While researching the problem on line I discovered many other HHR's had similar problems with the fuel line.

- Willow Street, PA, USA

problem #2

Nov 092017

HHR

  • 90,000 miles
The contact owns a 2009 Chevrolet HHR. While driving, the fuel line separated and there was an abnormal odor of fuel. The vehicle was towed to a local dealer (graybill bros 1459 beaver valley pike, refton, pa 17568) where it was diagnosed that the fuel line/locking clips failed. The contact was informed that the parts were on backorder. The vehicle was not repaired. The manufacturer was not notified. The failure mileage was 90,000.

- Willow Street, PA, USA

problem #1

Nov 042017

HHR

  • 107,000 miles
Gas lines exiting the fuel tank run through a flexible heat shield as they run past the left rear wheel to the bottom of the car (prior to running up to the engine). The fuel lines in the flexible heat shield have significant run and have started to leak fuel. This fuel pools under the car when stationary and sprays onto the exhaust system while in transit. This was not a sudden event, the rust has occurred over time, however is not detectable during routine inspection due to the heat shield. This incident was noticed due to the gas fumes which collected in the car during a start-up. There was no other indication until the fumes were investigated.

- Bloomington, IN, USA

Not what you are looking for?