Technical Service Bulletins (TSBs) for the 1999 Cavalier are official communications between Chevrolet & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
CONCERNS WITH CLUNK NOISE FROM FRONT OF VEHICLE TURNING MANEUVER / STEERING WHEEL ROTATION.*JB (LUBRICATE OR REPLACE INTERMEDIATE SHAFT AS APPROPRIATE). UPDATED 10/05/07. *NJ UPDATED 4/1/08. Read More »
CLUNK FELT/NOISE HEARD FROM STEERING COLUMN, STEERING GEAR AND/OR FRONT OF VEHICLE DURING TURNING MANEUVER AND/OR STEERING WHEEL ROTATION. *TT Read More »
THIS MESSAGE CONCERNS VEHICLES EXHIBITING A CLUNK NOISE COMING FROM THE FRONT OF THE VEHICLE. CUSTOMERS MAY STATE THAT A CLUNK NOISE IS HEARD WHEN TURNING THE STEERING WHEEL. *TT Read More »
UPPER RADIATOR HOSE CONTACTS THE BATTERY TRAY, WHICH MAY RESULT IN ENGINE COLLANT LEAK, WITH A LOW COOLANT TELLTALE (WARNING LAMP) ILLUMINATING ON THE INSTRUMENT CLUSTER. *MJS Read More »
SPECIAL POLICY ADJUSTMENT - AIR CLEANER COVER - REPLACE. BI-FUEL (COMPRESSED NATURAL GAS AND GASOLINE) ENGINE MAY EXPERIENCE A HIGHER RATE OF BACKFIRE THAN ON GASOLINE ENGINE CAVALIERS. *TT Read More »
ONWERS MAY COMMENT ON A LIGHT HESITATION OR STUMBLE AFTER A COLD START AT TEMPERATURES BELOW APPROXIMATELY 50 DEGREEES FAHRENHEIT OR TEN DEGREES C. *TT Read More »
SOME OWNERS MAY COMMENT ON A HISS NOISE AT CLOSED THROTTLE ONLY. IT MAY SOUND SIMILAR TO A BELT NOISE OR A POWER STEERING PUMP NOISE WHEN IT IS COLD. *TT Read More »
SOME CUSTOMERS MAY EXPERIENCE ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT AND CODE P0300 (GENERAL MISFIRE), WITH DRIVEABILITY COMPLAINTS OF ENGINE MISFIRE, ROUGH IDLE AND HESITATION. **MR Read More »
GENERAL MOTOR HAS DEDICED THAT CERTAIN VEHICLES EQUIPPED WITH 2.2L ENGINES (VIN 4), MAY EXHIBIT A CONDITION IN WHICH THE UPPER RADITOR HOSE CONTACTS THE BATTERY TRAY. *TT Read More »
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
ENGINEERING CHANGES TO THE VALVE BODY, PRESSURE REGULATOR VALVE, 2-3 ACCUMULATOR VALVE AND BORE FOR 2002-2003 MODEL YEAR 4T45E TRANSAXLES AND SUBSEQUENT OVERHAUL PROCEDURES WHICH AFFECT 1995-2001 MODEL YEAR TRANSAXLES. Read More »
INFORMATION ON 4T40-E (MN4) AND 4T45-E (MN5) FRONT WHEEL DRIVE AUTOMATIC TRANSMISSION VALVE BODY RECONDITIONING, DTC P0741, P0742, P0751, P0752, P0756, P0757, P1811, HARSH SHIFTS, SLIPS, NO DRIVE, NO REVERSE. Read More »
VEHICLE WILL NOT MOVE IN EITHER DIRECTION. TRANSMISSION MAY SHOW OVER FULL. P90 4T40E 4T45E NO MOVEMENT DRIVE OR REVERSE. CONVERTER MAY BE EMPTY OF FLUID. *TT Read More »
OWNERS OF SOME VEHICLES EQUIPPED WITH HYDRA-MATIC 3T40, 4T60, 4T60-E OR 4T65-E TRANSAXLES MAY COMMENT ON A GRINDING AND / OR GROWLING NOISE THAT IS NOTICEABLE WHEN STANDING IN PARK ON A HILL OR SLOPE WITH THE ENGINE RUNNING AND THE ... Read More »
SOME VEHICLES EQUIPPED WITH HYDRA-MATIC 3T40, 4T60 OR 4T60-E TRANSXALES MAY COMMENT ON A GRINDING AND / OR GROWLING NOISE THAT IS NOTICEABLE WHEN IN PARK ON INCLINE. *TT Read More »
IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE START POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS. Read More »
PROPER INSTALLATION INSTRUCTIONS FOR THE HIGH MOUNTED STOP LAMP THAT IS INTEGRATED IN THE REAR SPOILER. SOME DEALERS HAVE COMPLAINED ABOUT THE LAMP NOT FITTING PROPERLY OR THAT PARTS ARE BEING DAMAGED DURING INSTALLATION. Read More »
SOME CUSTOMES MAY COMMENT ON A ROUGH ENGINE IDLE AND / OR MISFIRE. THE CHECK ENGINE LIGHT MAY OR MAY NOT BE ILLUMINATED AND DIAGNOSTIC TROUBLE CODE P0300 MAY OR MAY NOT BE SET UNDER ROUGHT IDLE CONDITIONS. Read More »
CUSTOMERS MAY COMPLAIN OF COOLANT LEAKS, LOW COOLANT LIGHT 'ON', OVERHEATING, NO HEAT, NO START, OR ODORS EMITTED FROM THE AIR CONDITIONING SYSTEM. *TT Read More »
EXPERIENCING A RATTLE / SQUEAK IN RIGHT SIDE OF INSTRUMENT PANEL OR RIGHT FRONT DOOR TRIM PANEL SCRATCHED OR RIGHT SIDE END OF INSTRUMENT PANEL CONTACTING DOOR TRIM PANEL. *TT Read More »
