Technical Service Bulletins (TSBs) for the 1998 Cavalier are official communications between Chevrolet & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
CONCERNS WITH CLUNK NOISE FROM FRONT OF VEHICLE TURNING MANEUVER / STEERING WHEEL ROTATION.*JB (LUBRICATE OR REPLACE INTERMEDIATE SHAFT AS APPROPRIATE). UPDATED 10/05/07. *NJ UPDATED 4/1/08. Read More »
CLUNK FELT/NOISE HEARD FROM STEERING COLUMN, STEERING GEAR AND/OR FRONT OF VEHICLE DURING TURNING MANEUVER AND/OR STEERING WHEEL ROTATION. *TT Read More »
THIS MESSAGE CONCERNS VEHICLES EXHIBITING A CLUNK NOISE COMING FROM THE FRONT OF THE VEHICLE. CUSTOMERS MAY STATE THAT A CLUNK NOISE IS HEARD WHEN TURNING THE STEERING WHEEL. *TT Read More »
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester ... Read More »
UPPER RADIATOR HOSE CONTACTS THE BATTERY TRAY, WHICH MAY RESULT IN ENGINE COLLANT LEAK, WITH A LOW COOLANT TELLTALE (WARNING LAMP) ILLUMINATING ON THE INSTRUMENT CLUSTER. *MJS Read More »
SPECIAL POLICY ADJUSTMENT - AIR CLEANER COVER - REPLACE. BI-FUEL (COMPRESSED NATURAL GAS AND GASOLINE) ENGINE MAY EXPERIENCE A HIGHER RATE OF BACKFIRE THAN ON GASOLINE ENGINE CAVALIERS. *TT Read More »
SOME CUSTOMERS MAY EXPERIENCE ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT AND CODE P0300 (GENERAL MISFIRE), WITH DRIVEABILITY COMPLAINTS OF ENGINE MISFIRE, ROUGH IDLE AND HESITATION. **MR Read More »
GENERAL MOTOR HAS DEDICED THAT CERTAIN VEHICLES EQUIPPED WITH 2.2L ENGINES (VIN 4), MAY EXHIBIT A CONDITION IN WHICH THE UPPER RADITOR HOSE CONTACTS THE BATTERY TRAY. *TT Read More »
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester ... Read More »
This Preliminary Information communication provides information to the technician about a customer?s request to remove or disable the Bi-Fuel Compressed Natural Gas system. Read More »
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester ... Read More »
This Preliminary Information communication provides information to the technician about a customer?s request to remove or disable the Bi-Fuel Compressed Natural Gas system. Read More »
ENGINEERING CHANGES TO THE VALVE BODY, PRESSURE REGULATOR VALVE, 2-3 ACCUMULATOR VALVE AND BORE FOR 2002-2003 MODEL YEAR 4T45E TRANSAXLES AND SUBSEQUENT OVERHAUL PROCEDURES WHICH AFFECT 1995-2001 MODEL YEAR TRANSAXLES. Read More »
INFORMATION ON 4T40-E (MN4) AND 4T45-E (MN5) FRONT WHEEL DRIVE AUTOMATIC TRANSMISSION VALVE BODY RECONDITIONING, DTC P0741, P0742, P0751, P0752, P0756, P0757, P1811, HARSH SHIFTS, SLIPS, NO DRIVE, NO REVERSE. Read More »
VEHICLES EQUIPPED WITH 3T40 3-SPEED AUTOMATIC TRANSMISSIONS MAY EXHIBIT A CONDITION IN WHICH THERE IS A SLOW OR NO SECOND TO THIRD GEAR UPSHIFT. *YC Read More »
VEHICLE WILL NOT MOVE IN EITHER DIRECTION. TRANSMISSION MAY SHOW OVER FULL. P90 4T40E 4T45E NO MOVEMENT DRIVE OR REVERSE. CONVERTER MAY BE EMPTY OF FLUID. *TT Read More »
OWNERS OF SOME VEHICLES EQUIPPED WITH HYDRA-MATIC 3T40, 4T60, 4T60-E OR 4T65-E TRANSAXLES MAY COMMENT ON A GRINDING AND / OR GROWLING NOISE THAT IS NOTICEABLE WHEN STANDING IN PARK ON A HILL OR SLOPE WITH THE ENGINE RUNNING AND THE ... Read More »
SOME VEHICLES EQUIPPED WITH HYDRA-MATIC 3T40, 4T60 OR 4T60-E TRANSXALES MAY COMMENT ON A GRINDING AND / OR GROWLING NOISE THAT IS NOTICEABLE WHEN IN PARK ON INCLINE. *TT Read More »
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester ... Read More »
This Preliminary Information communication provides information to the technician about vehicles that have a Supplemental Inflatable Restraint lamp, Service Vehicle Soon lamp on and/or radio locked, possibly after module replacement. Read More »
IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE START POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS. Read More »
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester ... Read More »
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester ... Read More »
PROPER INSTALLATION INSTRUCTIONS FOR THE HIGH MOUNTED STOP LAMP THAT IS INTEGRATED IN THE REAR SPOILER. SOME DEALERS HAVE COMPLAINED ABOUT THE LAMP NOT FITTING PROPERLY OR THAT PARTS ARE BEING DAMAGED DURING INSTALLATION. Read More »
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester ... Read More »
This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Read More »
This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. Read More »
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester ... Read More »
This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Read More »
This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Read More »
This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Read More »
This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Read More »
This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. Read More »
This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Read More »
This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. Read More »
EXPERIENCING A RATTLE / SQUEAK IN RIGHT SIDE OF INSTRUMENT PANEL OR RIGHT FRONT DOOR TRIM PANEL SCRATCHED OR RIGHT SIDE END OF INSTRUMENT PANEL CONTACTING DOOR TRIM PANEL. *TT Read More »
