The oil filter housing, which is made of plastic, cracked while the vehicle was running on the highway, leading to sudden loss of the all the coolant and engine overheating.

- Metairie, LA, USA

* Components: Per dealership, Heat exchanger (metal) and oil filter housing (plastic), oil filter housing supports the heat exchanger, vehicle inspected by dealership and available for further inspection. *Vehicle unexpectedly overheated while driving on interstate risking the safety of driver/passengers and others. Dealer's (manufacturer) technician stated that the heat from the metal exchanger warped the plastic oil filter housing causing coolant to leak from heat exchanger, thus not allowing coolant to circulate to engine (leaking out) and causing vehicle to overheat. Metal warping (or potentially melting) plastic seems hazardous *Dealer's technician (manufacturer) inspected and identified the problem and quoted a cost of $3,140.80 to repair (this is seemingly a manufacturer's design flaw). Vehicle's warning system displayed an alert that coolant level was low while driving on interstate and recommended adding coolant soon. Driver pulled over within 5 min of warning light and added coolant. Within 5 min of driving away, Vehicle's onboard warning system displayed warning that vehicle coolant was low and engine temperature was elevated but it was safe to drive a low speed and consult nearest dealership, 2 min afterwards, vehicle alerted driver that engine overheated and to stop vehicle and contact nearest dealership. Vehicle towed to nearest dealership.

- Mcdonough, GA, USA

The contact owns a 2018 BMW X3. The contact stated that while her husband was driving at 80 mph, the coolant level low, drive at a moderate speed warning message had appeared on her instrument panel. The contact's husband continued to drive at a moderate speed as advised, soon after, the pull over, stop the car warning message also illuminated on the instrument panel and her husband proceeded as advised. Due to the failure, the contact's husband had the vehicle towed to the automaster BMW (3328 shelburne rd #3, shelburne, vt 05482). The dealer informed the contact that they discovered a coolant leak and that a part needed to be ordered to repair the vehicle. Prior to the failure, the contact stated that the same coolant level warning message had appeared on the instrument panel. The contact had twice taken the vehicle to South shore BMW(1040 hingham St, rockland, MA 02370) where they never discovered a coolant leak and would top off her coolant levels each time she visited the dealer for the same matter. The dealer was then notified again of the latest failure and the contact was informed that the failure was due to normal vehicle operation, they offered no further assistance with the failure. The vehicle remained in the possession of the automaster BMW(3328 shelburne rd #3, shelburne, vt 05482) and had yet to be repaired. The manufacturer had yet to be notified of the failure. The failure mileage was approximately 6,000.

- Hingham, MA, USA