Technical Service Bulletins (TSBs) for the 2006 X3 are official communications between BMW & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
This Service Information bulletin supersedes SI B07 03 14 dated October 2015. Diagnosing Stored Fault Codes to Help Avoid Repeat Repair Visits. Read More »
BMW: THE STEERING ANGLE SENSOR MUST BE ADJUSTED AFTER CERTAIN REPAIR WORK IS PERFORMED, SUCH AS A WHEEL ALIGNMENT OR CODING/PROGRAMMING OF THE DXC MODULE. Read More »
BMW AG has issued a Delivery Stop (effective March 28, 2022) on certain Model Year 2022 BMW vehicles that were produced between March 1, 2022 and March 8, 2022 because the torsion struts may not have been installed at the plant. Read More »
BMW AG has issued a Delivery Stop (effective March 28, 2022) on certain Model Year 2022 BMW vehicles that were produced between March 1, 2022 and March 8, 2022 because the torsion struts may not have been installed at the plant. Read More »
"REPAIRING TRANSFER CASE ACTUATOR (VTG SERVO-MOTOR). The Anti-lock Brakes (ABS), Brakes and Dynamic Stability Control (DSC) warnings are on and there may also be a ""Drivetrain Malfunction"" warning on in the Control Display. Read More »
This Service Information bulletin supersedes SI B07 03 14 dated October 2015. Diagnosing Stored Fault Codes to Help Avoid Repeat Repair Visits. Read More »
BMW VEHICLE: THE SERVICE ENGINE SOON (MIL) LAMP IS ILLUMINATED AND A POWER REDUCTION IS CLEARLY PERCEPTIBLE. THIS SITUATION MAY OCCUR AFTER DRIVING FOR SOME TIME WITH THE ENGINE ALREADY AT FULL OPERATING TEMPERATURE. Read More »
BMW VEHICLE: WATER HAS ENTERED ELECTRONICS BOX BECAUSE THE LID IS NOT PROPERLY FITTED. ONCE IT IS VERIFIED THAT WATER HAS INDEED ENTERED THE ELECTRONICS BOX, IT WILL BE NECESSARY TO REPLACE BOTH THE LOWER PART OF THE ELECTRONICS BOX AND ... Read More »
BMW: SIX DIFFERENT MODELS EQUIPPED WITH THE M54 ENGINE COULD HAVE VALVE COVERS BREAK IN COLD WEATHER AND RUIN THE ENGINE. THIS IS DUE TO MOISTURE ACCUMULATION. *RM Read More »
BMW VEHICLES: SERVICE ENGINE SOON LAMP OR CHECK GAS CAP WARNING ILLUMINATED WHILE DRIVING. SOFTWARE ERROR IN THE DME FOR THE TANK LEAK DIAGNOSTIC SYSTEM. Read More »
BMW VEHICLE: VEHICLES MAY BE DIFFICULT TO START, RUN ROUGH AND HAVE THE SERVICE ENGINE SOON LAMP ILLUMINATED. THE VANOS SOLENOID VALVE IS JAMMED OR STICKING. *PE Read More »
BMW VEHICLE: ENGINE ELECTRICAL SYSTEMS. POOR THROTTLE RESPONSE; LACK OF POWER WHEN ACCELERATING; ENGINE MAY CRANK TOO LONG BEFORE STARTING; LOSS OF POWER AT IDLE OR WHEN SLOWING TO A STOP. E83 (X3) MODELS. Read More »
BMW VEHICLE: THE SERVICE ENGINE SOON (MIL) LAMP IS ILLUMINATED AND A POWER REDUCTION IS CLEARLY PERCEPTIBLE. THIS SITUATION MAY OCCUR AFTER DRIVING FOR SOME TIME WITH THE ENGINE ALREADY AT FULL OPERATING TEMPERATURE. Read More »
BMW VEHICLE: WATER HAS ENTERED ELECTRONICS BOX BECAUSE THE LID IS NOT PROPERLY FITTED. ONCE IT IS VERIFIED THAT WATER HAS INDEED ENTERED THE ELECTRONICS BOX, IT WILL BE NECESSARY TO REPLACE BOTH THE LOWER PART OF THE ELECTRONICS BOX AND ... Read More »
BMW VEHICLE: VEHICLES MAY BE DIFFICULT TO START, RUN ROUGH AND HAVE THE SERVICE ENGINE SOON LAMP ILLUMINATED. THE VANOS SOLENOID VALVE IS JAMMED OR STICKING. *PE Read More »
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
BMW VEHICLES: SERVICE ENGINE SOON LAMP OR CHECK GAS CAP WARNING ILLUMINATED WHILE DRIVING. SOFTWARE ERROR IN THE DME FOR THE TANK LEAK DIAGNOSTIC SYSTEM. Read More »
BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS ... Read More »
Power Reduction FC2A82 Intake VANOS and/or FC2 A87 Exhaust VANOS Camshaft Fault: The "Service Engine Soon" (MIL) lamp is illuminated and engine power reduction is perceived. Read More »
GM6 - 6L45R: Diagnostic Procedure for Shudder or Vibration Issues. A shudder or vibration can be felt under light acceleration or when driving at constant suburban speeds. Read More »
BMW: DSC WARNING LIGHT IS ON. THE WARNING LAMPS FOR DSC, ABS AND BRAKE WARNING ILLUMINATED. THERE MAY ALSO BE A WARNING IN THE CONTROL DISPLAY FOR CHASSIS CONTROL SYSTEM FAILURE. *JS Read More »
BMW VEHICLES: DELAYED UPSHIFT MAY OCCUR UPHILL IN 3RD OR 4TH GEAR. THE TRANSMISSION WILL NOT UPSHIFT, USUALLY AFTER GOING UP A SLIGHT INCLINE, AND STAYS IN EITHER 3RD OR 4TH GEAR TOO LONG. Read More »
BMW VEHICLE: ENGINE ELECTRICAL SYSTEMS. POOR THROTTLE RESPONSE; LACK OF POWER WHEN ACCELERATING; ENGINE MAY CRANK TOO LONG BEFORE STARTING; LOSS OF POWER AT IDLE OR WHEN SLOWING TO A STOP. E83 (X3) MODELS. Read More »
"REPAIRING TRANSFER CASE ACTUATOR (VTG SERVO-MOTOR). The Anti-lock Brakes (ABS), Brakes and Dynamic Stability Control (DSC) warnings are on and there may also be a ""Drivetrain Malfunction"" warning on in the Control Display. Read More »
Shudder from the Driveline on Vehicles with xDrive. There is a shudder or vibration from the driveline when taking off from a stop, or when accelerating at highway speeds. Read More »
The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. Read More »
The 3G network in the US has been shut down. This means that only the 4G network will be available. In the 4G network, voice calls will be transferred via Voice over LTE (VoLTE) function. Read More »
Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may not start when placing the key against the steering column. Read More »
Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. Read More »
Power Reduction FC2A82 Intake VANOS and/or FC2 A87 Exhaust VANOS Camshaft Fault: The "Service Engine Soon" (MIL) lamp is illuminated and engine power reduction is perceived. Read More »
For the above-referenced vehicles with driver?s side airbag modules, BMW of North America, LLC (?BMW NA?) will provide a Customer Support Program as outlined in the Takata Settlement Customer Support Program Overview attachment. Read More »
Diagnosing Stored Fault Codes to Help Avoid Repeat Repair Visits This Service Information bulletin supersedes SI B07 03 14 dated October 2015.. Read More »
This Service Information bulletin supersedes SI B07 03 14 dated October 2015. Diagnosing Stored Fault Codes to Help Avoid Repeat Repair Visits. Read More »
SUBJECT Audio System Speaker Testing. For audio system speaker testing there is a NED (Non Electrical Diagnosis) Test Plan available. CAUSE We previously recommended use of the Audio Test CD (ATC) from BMW. This CD has been discontinued. Read More »
Diagnosing Stored Fault Codes to Help Avoid Repeat Repair Visits. Analysis of FASTA data and repeat repair visit reports indicates that there are many fault codes that are stored in the above vehicles, but they are not diagnosed to ... Read More »
This Service Information bulletin supersedes SI B07 03 14 dated February 2015. designates changes to this revision SUBJECT Diagnosing Stored Fault Codes to Help Avoid Repeat Repair Visits. Read More »
Check Control Messages Related to Battery Charge During Cold Ambient Temperatures. On cold days with an outside ambient temperature of less than 15?F, customers may notice a check control message related to the battery that is displayed ... Read More »
Check Control Messages Related to Battery Charge During Cold Ambient Temperatures. On cold days with an outside ambient temperature of less than 15F, customers may notice a check control message related to the battery that is displayed on ... Read More »
BMW: THE TELEMATICS CONTROL UNIT (TCU) IN VEHICLES MAY NOT HAVE BEEN PROPERLY ACTIVATED. THIS CAUSES THE MANUAL AND AUTOMATIC EMERGENCY CALL AND ROADSIDE CALL (BMW ASSIST) NOT TO FUNCTION. MODELS E53, E60, E90, E83 ARE AFFECTED. Read More »
BMW: BATTERY HAS AN INCREASED DEMAND DUE TO DEVELOPEMENTAL PROCESS OF THE ELECTRICAL SYSTEM. THIS IS CAUSING THE BATTER TO NEED TO UNDERGO AN ENERGY DIAGNOSIS. *KB Read More »
BMW VEHICLE: WATER HAS ENTERED ELECTRONICS BOX BECAUSE THE LID IS NOT PROPERLY FITTED. ONCE IT IS VERIFIED THAT WATER HAS INDEED ENTERED THE ELECTRONICS BOX, IT WILL BE NECESSARY TO REPLACE BOTH THE LOWER PART OF THE ELECTRONICS BOX AND ... Read More »
BMW: IN SOME VEHICLES, WHEN THE K CAN2 WIRING IS SHORTED, NO COMMUNICATION WITH ANY CONTROL MODULES (BOX ELECTRONICS, TELEMATIC CONTROL MODULE,CAR ACCESS SYSTEM, RADIO/NAVIGATION, CENTRAL GATEWAY MODEL OR FOOTWELL MODULE) DURING VEHICLE ... Read More »
BMW VEHICLE: AIR BAG WARNING LAMP ILLUMINATED AND FAULT CODE A1 IS STORED. A LOW VOLTAGE CONDITION CAUSED THE STEERING ANGLE SENSOR POSITION DATA TO BE LOST. THE BATTERY MAY HAVE BEEN DISCHARGED OR DISCONNECTED. (MODEL E83). Read More »
BMW: SOME VEHICLES, WITH 552 OPTION, ARE EXPERIENCING A MALFUNCTION OF LED HEADLIGHT ON ONE WHERE IT FLICKERS ON AN DOFF DURING DRIVING AND THE CONTROL CHECK MESSAGE IS INDICATING DEFECTIVE DRIVING LIGHT OR PARKING LIGHT. Read More »
"Panoramic Sunroof Repair Instructions. INFORMATION Sunroof Repair Instructions: The panoramic sunroof contains several ""mechanism sets"" which can be repaired and/or replaced independently in the event of a mechanical failure. Read More »
"?Panoramic Sunroof Repair Instructions. INFORMATION Sunroof Repair Instructions: The panoramic sunroof contains several ""mechanism sets"" which can be repaired and/or replaced independently in the event of a mechanical failure. Read More »
BMW: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION REGARDING THE DEFECT IN THE REAR WINDOW DEFROSTER THAT FAILS TO OPERATE PROPERLY. NO MODEL YEARS LISTED. *PE Read More »
TAKATA AIR BAG RECALL-RELATED SHORT-TERM ALTERNATE TRANSPORTATION AND CONSEQUENTIAL REPAIRS This Service Information bulletin supersedes SI B01 31 18 dated October 2018. Read More »
TAKATA AIR BAG RECALL-RELATED SHORT-TERM ALTERNATE TRANSPORTATION AND CONSEQUENTIAL REPAIRS This Service Information bulletin supersedes SI B01 31 18 dated October 2018. Read More »
For the above-referenced vehicles with driver?s side airbag modules, BMW of North America, LLC (?BMW NA?) will provide a Customer Support Program as outlined in the Takata Settlement Customer Support Program Overview attachment. Read More »
In an effort to improve the completion rate on Takata air bag recall affected vehicles; BMW NA has expanded the BMW Ultimate Rewards platform to include a new Recall Support page. Read More »
"This Service Information bulletin supersedes SI B65 69 06 dated June 2008. designates changes to this revision SUBJECT Airbag Warning Lamp Illuminated, FC 93EB or FC 55 . Read More »
BMW SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THE AIRBAG WARNING LAMP (AWL) IS ILLUMINATED, TOGETHER WITH THE PASSENGER AIRBAG STATUS LAMP (POL). THE PROBLEM MAY BE INTERMITTENT. MICROCRACKS IN THE OC3 SEAT MAT. Read More »
BMW VEHICLE: AIR BAG WARNING LAMP ILLUMINATED AND FAULT CODE A1 IS STORED. A LOW VOLTAGE CONDITION CAUSED THE STEERING ANGLE SENSOR POSITION DATA TO BE LOST. THE BATTERY MAY HAVE BEEN DISCHARGED OR DISCONNECTED. (MODEL E83). Read More »
Component-Specific Limited Warranty Extension. For the eligible vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the vehicle's Radiator Grille Upper and Lower Active Air Flaps to: 15 years/150,000 miles ... Read More »
Valve Stem Replacement with Wheel Electronics. INFORMATION The valve stems are single-use only, and must be replaced every time the wheel electronics are replaced. If you loosen the nut (1), you must replace the valve stem. Read More »
Shudder from the Driveline on Vehicles with xDrive. There is a shudder or vibration from the driveline when taking off from a stop, or when accelerating at highway speeds. Read More »
Valve Stem Replacement with Wheel Electronics. INFORMATION The valve stems are single-use only, and must be replaced every time the wheel electronics are replaced. If you loosen the nut (1), you must replace the valve stem. Read More »
A noise can be heard from underneath the seat while the seat is being moved either forwards or backwards. This can occur to the driver??A?A?s and/or the passenger??A?A?s front seat. Read More »
"REPAIRING TRANSFER CASE ACTUATOR (VTG SERVO-MOTOR). The Anti-lock Brakes (ABS), Brakes and Dynamic Stability Control (DSC) warnings are on and there may also be a ""Drivetrain Malfunction"" warning on in the Control Display. Read More »
Component-Specific Limited Warranty Extension. For the eligible vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the vehicle's Leak Diagnosis Module with hose assembly (NVLD, shown) to: 15 years/150,000 ... Read More »
Component-Specific Limited Warranty Extension. For the eligible vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the vehicle's Radiator Grille Upper and Lower Active Air Flaps to: 15 years/150,000 miles ... Read More »
The 3G network in the US has been shut down. This means that only the 4G network will be available. In the 4G network, voice calls will be transferred via Voice over LTE (VoLTE) function. Read More »
Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may not start when placing the key against the steering column. Read More »
Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. Read More »
This Service Information bulletin supersedes SI B07 03 14 dated October 2015. Diagnosing Stored Fault Codes to Help Avoid Repeat Repair Visits. Read More »
This Service Information bulletin supersedes SI B07 03 14 dated May 2015. designates changes to this revision SUBJECT Diagnosing Stored Fault Codes to Help Avoid Repeat Repair Visits. Read More »
Diagnosing Stored Fault Codes to Help Avoid Repeat Repair Visits. Analysis of FASTA data and repeat repair visit reports indicates that there are many fault codes that are stored in the above vehicles, but they are not diagnosed to ... Read More »
Check Control Messages Related to Battery Charge During Cold Ambient Temperatures. On cold days with an outside ambient temperature of less than 15F, customers may notice a check control message related to the battery that is displayed on ... Read More »
State Inspection and Emission (I/M) Test Fails Due To an Invalid VIN Number. The customer of an affected vehicle may fail to pass an I/M test due to a non-compliant 17digit vehicle identification number (VIN) stored in the DME (Digital ... Read More »
"?Panoramic Sunroof Repair Instructions. INFORMATION Sunroof Repair Instructions: The panoramic sunroof contains several ""mechanism sets"" which can be repaired and/or replaced independently in the event of a mechanical failure. Read More »
Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may not start when placing the key against the steering column. Read More »
BMW: THE TELEMATICS CONTROL UNIT (TCU) IN VEHICLES MAY NOT HAVE BEEN PROPERLY ACTIVATED. THIS CAUSES THE MANUAL AND AUTOMATIC EMERGENCY CALL AND ROADSIDE CALL (BMW ASSIST) NOT TO FUNCTION. MODELS E53, E60, E90, E83 ARE AFFECTED. Read More »
NAVIGATION SYSTEM: REPORTING MISSING OR INCORRECT ROAD MAP DATA: The route guidance is inaccurate and therefore irritating to the customer; or it is not possible to locate certain addresses, for ... Read More »
NAVIGATION SYSTEM: REPORTING MISSING OR INCORRECT ROAD MAP DATA: The route guidance is inaccurate and therefore irritating to the customer; or it is not possible to locate certain addresses, for ... Read More »
BMW: THE TELEMATICS CONTROL UNIT (TCU) IN VEHICLES MAY NOT HAVE BEEN PROPERLY ACTIVATED. THIS CAUSES THE MANUAL AND AUTOMATIC EMERGENCY CALL AND ROADSIDE CALL (BMW ASSIST) NOT TO FUNCTION. MODELS E53, E60, E90, E83 ARE AFFECTED. Read More »
"?Panoramic Sunroof Repair Instructions. INFORMATION Sunroof Repair Instructions: The panoramic sunroof contains several ""mechanism sets"" which can be repaired and/or replaced independently in the event of a mechanical failure. Read More »
BMW: REPLACE THE CHAIN TENSIONING RAIL BEARING BOLT THAT COULD COME LOOSE AND CAUSE DAMAGE TO THE ENGINE. MODELS E60 (5 SERIES), E70 (X5 SERIES), E83 (X3 SERIES), E9X (3 SERIES). *PE Read More »
Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. Read More »
SUBJECT Audio System Speaker Testing. For audio system speaker testing there is a NED (Non Electrical Diagnosis) Test Plan available. CAUSE We previously recommended use of the Audio Test CD (ATC) from BMW. This CD has been discontinued. Read More »
"This Service Information bulletin supersedes SI B65 69 06 dated June 2008. designates changes to this revision SUBJECT Airbag Warning Lamp Illuminated, FC 93EB or FC 55 . Read More »
Check Control Messages Related to Battery Charge During Cold Ambient Temperatures. On cold days with an outside ambient temperature of less than 15F, customers may notice a check control message related to the battery that is displayed on ... Read More »
Whistling Noise Coming from the Center Vent - A/C is Off . A very high pitched whistling or beeping noise is heard coming from the center vents. The flow of refrigerant through the expansion valve at certain temperature differentials. Read More »
