Technical Service Bulletins (TSBs) for the 2001 740 are official communications between BMW & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
Cracking noises are heard from the front axle area while maneuvering at low speeds (e.g., parking lot maneuvers) or when turning the steering wheel while stationary. Read More »
BMW: THERE MAY BE EXCESSIVE CRANKING BEFORE THE VEHICLE STARTS. THE SERVICE ENGINE SOON LIGHT MAY ALSO BE ON WITH A LACK OF ENGINE POWER. *RM Read More »
BMW: AFTER A FEW MILES OR SEVERAL THOUSAND MILES, CHECK CONTROL MESSAGE, HYBRID MALFUNCTION, MAY APPEAR AFTER PROGRAMMING OF SOFTWARE FOR VEHICLE. *PE Read More »
BMW: DIAGNOSIS OF DME ME 9.2 MAP THERMOSTAT FAULT 2EF4/279B. THE SERVICE ENGINE SOON LIGHT ILLUMINATED. THE ENGINE DOES NOT OVERHEAT AND THE MAP THERMOSTAT OPERATES PROPERLY. Read More »
BMW: VEHICLE MAY INTERMITTENTLY EXHIBIT ANY OF THE FOLLOWING: HARD TO START OR MAY NOT START; ENGINE RUNS ROUGH AND LACKS OR LOSES POWER; ENGINE POWER REDUCED. Read More »
BMW: SMALL NUMBER OF VEHICLES EXPERIENCE PROBLEMS RANGING FROM LEAKING OIL FILLER CAPS, LEAKING OR BROKEN VALVE COVERS, TO COMPLETE ENGINE FAILURE IN EXTREMELY COLD CLIMATE CONDITIONS. Read More »
BMW VEHICLES: N63 TURBOCHARGER AUXILIARY WATER PUMP FAULTS. THE SERVICE ENGINE SOON LAMP IS ILLUMINATED WITH THE FOLLOWING FAULT CODES STORED IN THE DME CONTROL MODULE. Read More »
BMW: SMALL NUMBER OF VEHICLES EXPERIENCE PROBLEMS RANGING FROM LEAKING OIL FILLER CAPS, LEAKING OR BROKEN VALVE COVERS, TO COMPLETE ENGINE FAILURE IN EXTREMELY COLD CLIMATE CONDITIONS. Read More »
ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER
BMW VEHICLES: N63 TURBOCHARGER AUXILIARY WATER PUMP FAULTS. THE SERVICE ENGINE SOON LAMP IS ILLUMINATED WITH THE FOLLOWING FAULT CODES STORED IN THE DME CONTROL MODULE. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
BMW: SMALL NUMBER OF VEHICLES EXPERIENCE PROBLEMS RANGING FROM LEAKING OIL FILLER CAPS, LEAKING OR BROKEN VALVE COVERS, TO COMPLETE ENGINE FAILURE IN EXTREMELY COLD CLIMATE CONDITIONS. Read More »
BMW: SERVICE ENGINE SOON LAMP OR THE CHECK GAS CAP WARNINGS ARE ILLUMINATED WHILE DRIVING. WHEN DIAGNOSED, THE DME HAS STORED FAULTS FOR SMALL LEAK, MICRO LEAK, SUPER FINE LEAK, OR LARGE LEAK IN RELATION TO THE TANK VENTILATION OR ... Read More »
BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS ... Read More »
BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS ... Read More »
BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS ... Read More »
BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS ... Read More »
BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS ... Read More »
BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS ... Read More »
BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS ... Read More »
BMW: SERVICE ENGINE SOON LAMP OR THE CHECK GAS CAP WARNINGS ARE ILLUMINATED WHILE DRIVING. WHEN DIAGNOSED, THE DME HAS STORED FAULTS FOR SMALL LEAK, MICRO LEAK, SUPER FINE LEAK, OR LARGE LEAK IN RELATION TO THE TANK VENTILATION OR ... Read More »
BMW VEHICLES: N63 TURBOCHARGER AUXILIARY WATER PUMP FAULTS. THE SERVICE ENGINE SOON LAMP IS ILLUMINATED WITH THE FOLLOWING FAULT CODES STORED IN THE DME CONTROL MODULE. Read More »
BMW: DIAGNOSIS OF DME ME 9.2 MAP THERMOSTAT FAULT 2EF4/279B. THE SERVICE ENGINE SOON LIGHT ILLUMINATED. THE ENGINE DOES NOT OVERHEAT AND THE MAP THERMOSTAT OPERATES PROPERLY. Read More »
BMW: SPORADICALLY, THE FOLLOWING CONDITIONS MAY OCCUR-WIPERS ARE RUNNING ON A DRY WINDOW; SPEEDOMETER AND TACHOMETER ARE INOPERATIVE; CHECK CONTROL MESSAGE EMF DROPPED OUT (DRIVE CONTROL SYSTEM EMERGENCY MODE). Read More »
BMW: THE HIGH-VOLTAGE (HV) BATTERY CELLS COULD BE DAMAGED IF THE VEHICLE IS PREVENTED FROM ENTERING SLEEP MODE FOR AN EXTENDED PERIOD OF TIME. UPDATED 03/11/2013 *JS Read More »
BMW: AFTER A FEW MILES OR SEVERAL THOUSAND MILES, CHECK CONTROL MESSAGE, HYBRID MALFUNCTION, MAY APPEAR AFTER PROGRAMMING OF SOFTWARE FOR VEHICLE. *PE Read More »
BMW: SPORADICALLY, THE FOLLOWING CONDITIONS MAY OCCUR-WIPERS ARE RUNNING ON A DRY WINDOW; SPEEDOMETER AND TACHOMETER ARE INOPERATIVE; CHECK CONTROL MESSAGE EMF DROPPED OUT (DRIVE CONTROL SYSTEM EMERGENCY MODE). Read More »
BMW VEHICLE: ADAPTIVE HEADLIGHTS. A CHECK CONTROL (CC) MESSAGE IS DISPLAYED FOR THE ADAPTIVE HEADLIGHTS. THE HEADLAMPS NO LONGER TURN WITH STEERING WHEEL MOVEMENT. FAULT CODE 800FC6 IS ENTERED IN THE FOOTWELL MODULE (FRM3). Read More »
BMW: LOW BEAM HEADLAMPS ARE SWITCHED ON, OR AFTER STARTING THE ENGINE, ONE OF THE XENON LOW BEAM HEADLAMPS FLASHES SERVERAL TIMES, AND THEN INTERMITTENLY SWITCHES OFF. *PE Read More »
BMW: HEADLAMP MOISTURE: FAULT DIAGNOSTICS. WATER OR CONDENSATION IN ONE OR BOTH HEADLAMPS. MODELS 5 SERIES, 6 SERIES, 7 SERIES, X5, X6, 1 SERIES, AND 3 SERIES. MODEL YEARS 2000-20008. *PE Read More »
BMW: LOW BEAM HEADLAMPS ARE SWITCHED ON, OR AFTER STARTING THE ENGINE, ONE OF THE XENON LOW BEAM HEADLAMPS FLASHES SERVERAL TIMES, AND THEN INTERMITTENLY SWITCHES OFF. *PE Read More »
BMW: WIPERS LIGHTS AND FRONT POWER WINDOWS ARE INOPERATIVE. THIS SITUATION MAY START AND LEAD TO A PERMANENT FAULT. ALSO INCLUDED MODEL F07 (5 SERIES GRAN TURISMO) MODEL YEARS UP TO MARCH 2012. *JS Read More »
BMW: WIPERS LIGHTS AND FRONT POWER WINDOWS ARE INOPERATIVE. THIS SITUATION MAY START AND LEAD TO A PERMANENT FAULT. ALSO INCLUDED MODEL F07 (5 SERIES GRAN TURISMO) MODEL YEARS UP TO MARCH 2012. *JS Read More »
BMW SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THE AIRBAG WARNING LAMP (AWL) IS ILLUMINATED, TOGETHER WITH THE PASSENGER AIRBAG STATUS LAMP (POL). THE PROBLEM MAY BE INTERMITTENT. MICROCRACKS IN THE OC3 SEAT MAT. Read More »
BMW: THE SAFETY BELTS FOR THE FRONT SEATS HAVE AN ELECTRIC MOTOR-DRIVEN REEL (EMA) WHICH WILL RETRACT/PRETENSION THE SEAT BELT A SPECIFIED AMOUNT WHEN CERTAIN HAZARDOUS DRIVING SITUATIONS ARE PRESENT. Read More »
BMW: THE SAFETY BELTS FOR THE FRONT SEATS HAVE AN ELECTRIC MOTOR-DRIVEN REEL (EMA) WHICH WILL RETRACT/PRETENSION THE SEAT BELT A SPECIFIED AMOUNT WHEN CERTAIN HAZARDOUS DRIVING SITUATIONS ARE PRESENT. Read More »
SUBJECT REGARDING A DAMAGED THROTTLE HOUSE ASSEMBLY. THIS SERVICE ACTION INVOLVES E65 AND E66 VEHICLES WITH N62 ENGINES WHICH WERE PRODUCED FROM 8/20/2001 - 12/28/2001. *TT Read More »
SUBJECT REGARDING INTERMITTENT ACCELERATOR PEDAL FEEL PROBLEM - REVISED WITH SIMPLIFIED ORDERING PROCEDURE FOR CERTAIN MODELS INCLUDING E65/E66 SINCE SERIES INTRODUCTION UP TO 06/02. *TT Read More »
CUSTOMER MAY COMPLAIN OF THE ACCELERATOR PEDAL FEELINGNOTCHY OR NOT MOVING SMOOTHLY WHEN DEPRESSED IN SMALL INCREMENTS ON CERTAIN MODELS INCLUDING E52, E53 AND E65/E66 VEHICLES FROM SERIES INTRODUCTION UP TO 06/02. Read More »
BMW VEHICLES: REPLACED SEAT OCCUPANCY SENSOR MAT WILL NOT ENABLE. AFTER REPLACING A CIS (CAPACITIVE SENSING PASSENGER OCCUPANCY MAT), THE NEW MAT WILL NOT ENABLE WHEN USING ISTA/P. Read More »
BMW: WIPERS LIGHTS AND FRONT POWER WINDOWS ARE INOPERATIVE. THIS SITUATION MAY START AND LEAD TO A PERMANENT FAULT. ALSO INCLUDED MODEL F07 (5 SERIES GRAN TURISMO) MODEL YEARS UP TO MARCH 2012. *JS Read More »
Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may not start when placing the key against the steering column. Read More »
BMW VEHICLES: N63 TURBOCHARGER AUXILIARY WATER PUMP FAULTS. THE SERVICE ENGINE SOON LAMP IS ILLUMINATED WITH THE FOLLOWING FAULT CODES STORED IN THE DME CONTROL MODULE. Read More »
BMW VEHICLE: ADAPTIVE HEADLIGHTS. A CHECK CONTROL (CC) MESSAGE IS DISPLAYED FOR THE ADAPTIVE HEADLIGHTS. THE HEADLAMPS NO LONGER TURN WITH STEERING WHEEL MOVEMENT. FAULT CODE 800FC6 IS ENTERED IN THE FOOTWELL MODULE (FRM3). Read More »
