Technical Service Bulletins (TSBs) for the 2006 530 are official communications between BMW & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
BMW VEHICLE: SPORT TRANSMISSION PADDLE SHIFTERS INOPERATIVE-DIAGNOSIS. THE DIRECT COMMUNICATION INPUT LINE BETWEEN THE PADDLE SHIFTERS AND THE EGS TRANSMISSION CONTROL MODULE IS INTERRUPTED. NO MODEL YEARS LISTED. Read More »
BMW: A GRINDING NOISE IS COMING FROM THE DIFFERENTIAL DURING SLOW CORNERING. WHEN TURNING A SLIP/STICK EFFECT IS CREATED ON THE LINING AND STEEL DISCS INCORPORATED IN THE DIFFERENTIAL CLUTCH CAUSES A GRINDING NOISE. Read More »
BMW VEHICLE: DSC DISABLING FUNCTION. DUE TO REVISED DME, DSC AND CCC SOFTWARE, THE MDM (M DYNAMIC MODE) BUTTON LOCATED IN THE CENTER CONSOLE SWITCH CLUSTER (SZM) NOW HAS TRIPLE FUNCTIONALITY-DEFAULT STATE-DSC ON; SHORT PRESS-MDM ON ... Read More »
BMW: WHILE DRIVING VEHICLE, AT TIMES WOULD BE ROUGH RUNNING; WHITE OR BLUE SMOKE SEEN EXITING EXHAUST SYSTEM AND THE ENGINE OIL IS CONSUMED ABOVE SPECIFICATIONS. *PE UPDATED 1/11/13. *PE Read More »
BMW VEHICLE: THE SERVICE ENGINE SOON (MIL) LAMP IS ILLUMINATED AND A POWER REDUCTION IS CLEARLY PERCEPTIBLE. THIS SITUATION MAY OCCUR AFTER DRIVING FOR SOME TIME WITH THE ENGINE ALREADY AT FULL OPERATING TEMPERATURE. Read More »
BMW: ONE OR A COMBINATION OF THE FOLLOWING SITUATIONS MAY EXIST: INTERMITTENT HARSH 4-3, 3-2 OR 2-1 DOWNSHIFT (JOLT) WHEN COMING TO A STOP WITH LIGHT BRAKE APPLICATION; JOLTS AND/OR JERKS FELT WHEN REACCELERATING AFTER COASTING; AND ... Read More »
BMW: COMPLAINTS THAT THE ENGINE MANAGEMENT SYSTEM HAS ENTERED THE ENGINE FAILSAFE MODE AND THAT THE TURBOCHARGER BOOST IS REDUCED. E82, E88, E90, E92, E93, E60, E61, AND E71. ALL MODELS WITH NAY ENGINES. NO MODEL YEARS LISTED. Read More »
BMW: SIX DIFFERENT MODELS EQUIPPED WITH THE M54 ENGINE COULD HAVE VALVE COVERS BREAK IN COLD WEATHER AND RUIN THE ENGINE. THIS IS DUE TO MOISTURE ACCUMULATION. *RM Read More »
BMW: VEHICLE HAS A CHECK CONTROL MESSAGE SELF LEVELING SUSPENSION FAILED/MALFUNCTIONING DISPLAYED. AT LEAST ONE OF THE FOLLOWING FAULT CODES IS STORED AND IS CURRENTLY PRESENT IN THE EHC CONTROL UNIT: 5F98 CONTROL TIME FAULT LIFTING REAR ... Read More »
BMW VEHICLES: EDK THROTTLE POTENTIOMETER FAULTS-DIAGNOSIS. MODELS E60, E63, E64, E65, E66, AND E70. THE SERVICE ENGINE SOON AND DSC/DTC WARNING LAMPS ARE ILLUMINATED. THE ENGINE ENTERS THE POWER REDUCTION (FAIL SAFE) MODE. Read More »
BMW VEHICLES: SERVICE ENGINE SOON LAMP OR CHECK GAS CAP WARNING ILLUMINATED WHILE DRIVING. SOFTWARE ERROR IN THE DME FOR THE TANK LEAK DIAGNOSTIC SYSTEM. Read More »
BMW: SMALL NUMBER OF VEHICLES EXPERIENCE PROBLEMS RANGING FROM LEAKING OIL FILLER CAPS, LEAKING OR BROKEN VALVE COVERS, TO COMPLETE ENGINE FAILURE IN EXTREMELY COLD CLIMATE CONDITIONS. Read More »
BMW VEHICLE: VEHICLES MAY BE DIFFICULT TO START, RUN ROUGH AND HAVE THE SERVICE ENGINE SOON LAMP ILLUMINATED. THE VANOS SOLENOID VALVE IS JAMMED OR STICKING. *PE Read More »
N54 RATTLE NOISE FROM TURBOCHARGER AREA. MODELS E90, E92 AND E93 (3 SERIES) 335I AND 335XI; E60 AND E61 (5 SERIES) 535I AND 535XI, ALL WITH N54 ENGINE FROM THE START OF PRODUCTION TO JANUARY 17, 2008 PRODUCTION. Read More »
BMW VEHICLE: SERVICE ENGINE SOON LIGHT ILLUMINATED: S85-VARIOUS VANOS RELATED FAULTS STORED. (E60 (5SERIES), E63 & E64 (6SERIES). NO MODEL YEARS LISTED. *PE Read More »
BMW VEHICLE: N54 TURBOCHARGER WASTE GATE CONTROL NOISES AND OPERATION. AFTER TURNING OFF ENGINE, A SLIGHT RATTLE NOISE IS HEARD FROM THE ENGINE COMPARTMENT. THIS NOISE IS SIMILAR TO A MECHANICAL TYPEWRITER. Read More »
BMW: COMPLAINTS THAT THE ENGINE MANAGEMENT SYSTEM HAS ENTERED THE ENGINE FAILSAFE MODE AND THAT THE TURBOCHARGER BOOST IS REDUCED. E82, E88, E90, E92, E93, E60, E61, AND E71. ALL MODELS WITH NAY ENGINES. NO MODEL YEARS LISTED. Read More »
N54 RATTLE NOISE FROM TURBOCHARGER AREA. MODELS E90, E92 AND E93 (3 SERIES) 335I AND 335XI; E60 AND E61 (5 SERIES) 535I AND 535XI, ALL WITH N54 ENGINE FROM THE START OF PRODUCTION TO JANUARY 17, 2008 PRODUCTION. Read More »
BMW VEHICLE: N54 TURBOCHARGER WASTE GATE CONTROL NOISES AND OPERATION. AFTER TURNING OFF ENGINE, A SLIGHT RATTLE NOISE IS HEARD FROM THE ENGINE COMPARTMENT. THIS NOISE IS SIMILAR TO A MECHANICAL TYPEWRITER. Read More »
BMW VEHICLE: THE SERVICE ENGINE SOON (MIL) LAMP IS ILLUMINATED AND A POWER REDUCTION IS CLEARLY PERCEPTIBLE. THIS SITUATION MAY OCCUR AFTER DRIVING FOR SOME TIME WITH THE ENGINE ALREADY AT FULL OPERATING TEMPERATURE. Read More »
BMW VEHICLES: EDK THROTTLE POTENTIOMETER FAULTS-DIAGNOSIS. MODELS E60, E63, E64, E65, E66, AND E70. THE SERVICE ENGINE SOON AND DSC/DTC WARNING LAMPS ARE ILLUMINATED. THE ENGINE ENTERS THE POWER REDUCTION (FAIL SAFE) MODE. Read More »
BMW: SMALL NUMBER OF VEHICLES EXPERIENCE PROBLEMS RANGING FROM LEAKING OIL FILLER CAPS, LEAKING OR BROKEN VALVE COVERS, TO COMPLETE ENGINE FAILURE IN EXTREMELY COLD CLIMATE CONDITIONS. Read More »
BMW VEHICLE: VEHICLES MAY BE DIFFICULT TO START, RUN ROUGH AND HAVE THE SERVICE ENGINE SOON LAMP ILLUMINATED. THE VANOS SOLENOID VALVE IS JAMMED OR STICKING. *PE Read More »
BMW VEHICLE: SERVICE ENGINE SOON LIGHT ILLUMINATED: S85-VARIOUS VANOS RELATED FAULTS STORED. (E60 (5SERIES), E63 & E64 (6SERIES). NO MODEL YEARS LISTED. *PE Read More »
ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER
N54 RATTLE NOISE FROM TURBOCHARGER AREA. MODELS E90, E92 AND E93 (3 SERIES) 335I AND 335XI; E60 AND E61 (5 SERIES) 535I AND 535XI, ALL WITH N54 ENGINE FROM THE START OF PRODUCTION TO JANUARY 17, 2008 PRODUCTION. Read More »
BMW VEHICLE: N54 TURBOCHARGER WASTE GATE CONTROL NOISES AND OPERATION. AFTER TURNING OFF ENGINE, A SLIGHT RATTLE NOISE IS HEARD FROM THE ENGINE COMPARTMENT. THIS NOISE IS SIMILAR TO A MECHANICAL TYPEWRITER. Read More »
BMW VEHICLE: DRIVEABILITY COMPLAINTS DUE TO COOLING FAN RELAY FAILURE. THE CUSTOMER MAY COMPLAIN OF INTERMITTENT DRIVEABILITY PROBLEMS, DESCRIBED AS-ENGINE IS LACKING POWER WHEN ACCELERATING UPHILL; TRANSMISSION WILL NOT UPSHIFT UNDER ... Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
BMW: ON SOME VEHICLES, THE HIGH PRESSURE FUEL PUMP HAS AN INTERNAL COMPONENT THAT MAY FAIL AND CAUSING DRIVABILITY SYMPTOMS SUCH AS ERRATIC ENGINE OPERATION AND LONGER STARTING TIMES. *PE Read More »
BMW: VOLUNTARY EMISSION RECALL 08E-A02: M5 AND M6 (5 & 6 SERIES) WITH S85 OBD COMMUNICATION. SOFTWARE ERROR IN THE DME CONTROL MODULE MAY CAUSE COMMUNICATION INCOMPATIBILITY WITH CERTAIN GENERIC OBD SCANNER TOOLS. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
BMW: SMALL NUMBER OF VEHICLES EXPERIENCE PROBLEMS RANGING FROM LEAKING OIL FILLER CAPS, LEAKING OR BROKEN VALVE COVERS, TO COMPLETE ENGINE FAILURE IN EXTREMELY COLD CLIMATE CONDITIONS. Read More »
BMW: SERVICE ENGINE SOON LAMP OR THE CHECK GAS CAP WARNINGS ARE ILLUMINATED WHILE DRIVING. WHEN DIAGNOSED, THE DME HAS STORED FAULTS FOR SMALL LEAK, MICRO LEAK, SUPER FINE LEAK, OR LARGE LEAK IN RELATION TO THE TANK VENTILATION OR ... Read More »
BMW VEHICLES: SERVICE ENGINE SOON LAMP OR CHECK GAS CAP WARNING ILLUMINATED WHILE DRIVING. SOFTWARE ERROR IN THE DME FOR THE TANK LEAK DIAGNOSTIC SYSTEM. Read More »
BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS ... Read More »
BMW: SERVICE ENGINE SOON LAMP OR THE CHECK GAS CAP WARNINGS ARE ILLUMINATED WHILE DRIVING. WHEN DIAGNOSED, THE DME HAS STORED FAULTS FOR SMALL LEAK, MICRO LEAK, SUPER FINE LEAK, OR LARGE LEAK IN RELATION TO THE TANK VENTILATION OR ... Read More »
BMW: ONE OR A COMBINATION OF THE FOLLOWING SITUATIONS MAY EXIST: INTERMITTENT HARSH 4-3, 3-2 OR 2-1 DOWNSHIFT (JOLT) WHEN COMING TO A STOP WITH LIGHT BRAKE APPLICATION; JOLTS AND/OR JERKS FELT WHEN REACCELERATING AFTER COASTING; AND ... Read More »
BMW VEHICLE: SPORT TRANSMISSION PADDLE SHIFTERS INOPERATIVE-DIAGNOSIS. THE DIRECT COMMUNICATION INPUT LINE BETWEEN THE PADDLE SHIFTERS AND THE EGS TRANSMISSION CONTROL MODULE IS INTERRUPTED. NO MODEL YEARS LISTED. Read More »
BMW VEHICLE: DSC DISABLING FUNCTION. DUE TO REVISED DME, DSC AND CCC SOFTWARE, THE MDM (M DYNAMIC MODE) BUTTON LOCATED IN THE CENTER CONSOLE SWITCH CLUSTER (SZM) NOW HAS TRIPLE FUNCTIONALITY-DEFAULT STATE-DSC ON; SHORT PRESS-MDM ON ... Read More »
BMW: INTERMITTENTLY GOES INTO PARK DURING A MSA ENGINE START. THE TRANSMISSION CAN INTERMITTENTLY GO INTO THE PARK POSITION (P) WHEN MSA ENGINE START IS OCCURRING. Read More »
BMW VEHICLE: TRANSMISSION WARNING LIGHT IS ILLUMINATED AND THE TRANSMISSION ENTERS FAILSAFE MODE. FAULT CODE 4F81 (RATIO MONITORING, CLUTCH A), IN SOME CASES COMBINED WITH THE SUBSEQUENT FAULTS 507B/507C (PARKING GEAR SENSOR IMPLAUSIBLE ... Read More »
BMW VEHICLE: VARIOUS ELECTRICAL PROBLEMS CAUSED BY WATER INGRESS. WATER INGRESS IN LUGGAGE COMPARTMENT MAY CAUSE VARIOUS ELECTRICAL PROBLEMS OR FAULTS ASSOCIATED WITH MPM (MICRO POWER MODULE); PDC (PARK DISTANCE CONTROL); M-ASK (MULTI ... Read More »
BMW: THE TELEMATICS CONTROL UNIT (TCU) IN VEHICLES MAY NOT HAVE BEEN PROPERLY ACTIVATED. THIS CAUSES THE MANUAL AND AUTOMATIC EMERGENCY CALL AND ROADSIDE CALL (BMW ASSIST) NOT TO FUNCTION. MODELS E53, E60, E90, E83 ARE AFFECTED. Read More »
BMW VEHICLE: SERVICE ENGINE SOON LIGHT ILLUMINATED: S85-VARIOUS VANOS RELATED FAULTS STORED. (E60 (5SERIES), E63 & E64 (6SERIES). NO MODEL YEARS LISTED. *PE Read More »
BMW VEHICLE: DRIVEABILITY COMPLAINTS DUE TO COOLING FAN RELAY FAILURE. THE CUSTOMER MAY COMPLAIN OF INTERMITTENT DRIVEABILITY PROBLEMS, DESCRIBED AS-ENGINE IS LACKING POWER WHEN ACCELERATING UPHILL; TRANSMISSION WILL NOT UPSHIFT UNDER ... Read More »
BMW: BATTERY HAS AN INCREASED DEMAND DUE TO DEVELOPEMENTAL PROCESS OF THE ELECTRICAL SYSTEM. THIS IS CAUSING THE BATTER TO NEED TO UNDERGO AN ENERGY DIAGNOSIS. *KB Read More »
BMW: THE HIGH-VOLTAGE (HV) BATTERY CELLS COULD BE DAMAGED IF THE VEHICLE IS PREVENTED FROM ENTERING SLEEP MODE FOR AN EXTENDED PERIOD OF TIME. UPDATED 03/11/2013 *JS Read More »
BMW: THE ENGINE OIL LEVEL DISPLAYED IN THE INSTRUMENT CLUSTER MAY BE TOO HIGH OR TOO LOW. OIL LEVEL COULD BE LOWER THAN WHAT IS DISPLAYED AND THE LOW OIL LEVEL WARNING IS NOT PROMPTLY SHOWN. E60, E61, E82, E90, E92 & E93 MODELS. Read More »
BMW: ONE OR A COMBINATION OF THE FOLLOWING SITUATIONS MAY EXIST: INTERMITTENT HARSH 4-3, 3-2 OR 2-1 DOWNSHIFT (JOLT) WHEN COMING TO A STOP WITH LIGHT BRAKE APPLICATION; JOLTS AND/OR JERKS FELT WHEN REACCELERATING AFTER COASTING; AND ... Read More »
BMW: WIRING ON THE HEADLIGHTS MAY HAVE DETERIORATED DUE TO ENVIRONMENTAL CONDITIONS AND THE COVER NOT BEING SECURED PROPERLY. E60/E92. *RM UPDATED 9/30/11. *PE Read More »
BMW VEHICLE: ADAPTIVE HEADLIGHTS. A CHECK CONTROL (CC) MESSAGE IS DISPLAYED FOR THE ADAPTIVE HEADLIGHTS. THE HEADLAMPS NO LONGER TURN WITH STEERING WHEEL MOVEMENT. FAULT CODE 800FC6 IS ENTERED IN THE FOOTWELL MODULE (FRM3). Read More »
BMW: HEADLAMP MOISTURE: FAULT DIAGNOSTICS. WATER OR CONDENSATION IN ONE OR BOTH HEADLAMPS. MODELS 5 SERIES, 6 SERIES, 7 SERIES, X5, X6, 1 SERIES, AND 3 SERIES. MODEL YEARS 2000-20008. *PE Read More »
BMW: WIPERS LIGHTS AND FRONT POWER WINDOWS ARE INOPERATIVE. THIS SITUATION MAY START AND LEAD TO A PERMANENT FAULT. ALSO INCLUDED MODEL F07 (5 SERIES GRAN TURISMO) MODEL YEARS UP TO MARCH 2012. *JS Read More »
BMW: WIPERS LIGHTS AND FRONT POWER WINDOWS ARE INOPERATIVE. THIS SITUATION MAY START AND LEAD TO A PERMANENT FAULT. ALSO INCLUDED MODEL F07 (5 SERIES GRAN TURISMO) MODEL YEARS UP TO MARCH 2012. *JS Read More »
BMW: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. LIMITED WARRANTY HAS BEEN EXTENDED, UP TO 15 YEARS, ON CERTAIN VEHICLES, WITHOUT MILEAGE LIMITATION FOR FRONT PASSENGER AIR BAG SEAT OCCUPANCY SENSOR (OC3) (MATERIALS AND WORKMANSHIP). Read More »
BMW: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. LIMITED WARRANTY HAS BEEN EXTENDED, UP TO 15 YEARS, ON CERTAIN VEHICLES, WITHOUT MILEAGE LIMITATION FOR FRONT PASSENGER AIR BAG SEAT OCCUPANCY SENSOR (OC3) (MATERIALS AND WORKMANSHIP). Read More »
BMW: WHEN OUTSIDE TEMP IS BELOW FREEZING THE OUTSIDE DOORS WILL NOT CLOSE OR ARE DIFFICULT TO OPEN. A DOOR CABLE HAS MOISTURE INTRUSION AND FREEZES. *RM Read More »
BMW VEHICLES: REPLACED SEAT OCCUPANCY SENSOR MAT WILL NOT ENABLE. AFTER REPLACING A CIS (CAPACITIVE SENSING PASSENGER OCCUPANCY MAT), THE NEW MAT WILL NOT ENABLE WHEN USING ISTA/P. Read More »
BMW: WIPERS LIGHTS AND FRONT POWER WINDOWS ARE INOPERATIVE. THIS SITUATION MAY START AND LEAD TO A PERMANENT FAULT. ALSO INCLUDED MODEL F07 (5 SERIES GRAN TURISMO) MODEL YEARS UP TO MARCH 2012. *JS Read More »
BMW: THE TELEMATICS CONTROL UNIT (TCU) IN VEHICLES MAY NOT HAVE BEEN PROPERLY ACTIVATED. THIS CAUSES THE MANUAL AND AUTOMATIC EMERGENCY CALL AND ROADSIDE CALL (BMW ASSIST) NOT TO FUNCTION. MODELS E53, E60, E90, E83 ARE AFFECTED. Read More »
BMW: THE TELEMATICS CONTROL UNIT (TCU) IN VEHICLES MAY NOT HAVE BEEN PROPERLY ACTIVATED. THIS CAUSES THE MANUAL AND AUTOMATIC EMERGENCY CALL AND ROADSIDE CALL (BMW ASSIST) NOT TO FUNCTION. MODELS E53, E60, E90, E83 ARE AFFECTED. Read More »
BMW: REPLACE THE CHAIN TENSIONING RAIL BEARING BOLT THAT COULD COME LOOSE AND CAUSE DAMAGE TO THE ENGINE. MODELS E60 (5 SERIES), E70 (X5 SERIES), E83 (X3 SERIES), E9X (3 SERIES). *PE Read More »
BMW VEHICLE: ADAPTIVE HEADLIGHTS. A CHECK CONTROL (CC) MESSAGE IS DISPLAYED FOR THE ADAPTIVE HEADLIGHTS. THE HEADLAMPS NO LONGER TURN WITH STEERING WHEEL MOVEMENT. FAULT CODE 800FC6 IS ENTERED IN THE FOOTWELL MODULE (FRM3). Read More »
