Technical Service Bulletins (TSBs) for the 1999 328 are official communications between BMW & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
BMW VEHICLES: REAR AXLE CARRIER (SUB FRAME) SUPPORT PROPOSED CLASS ACTION SETTLEMENT. UNDER CERTAIN CIRCUMSTANCES, A FRACTURE IN THE STEEL BODY STRUCTURE COULD FORM IN THE AREA AROUND ONE OF THE REAR AXLE CARRIER MOUNTING POINTS. Read More »
BMW VEHICLES: TEILECLEARING FOR DYNAMIC STABILITY CONTROL (DSC). A PART REPLACEMENT AUTHORIZATION MUST BE OBTAINED BY SUBMITTING A TC CASE IN PUMA BEFORE ANY OF THE FOLLOWING DSC COMPONENTS ARE REPLACED UNDER WARRANTY FOR THE VEHICLES ... Read More »
BMW VEHICLES: TEILECLEARING FOR DYNAMIC STABILITY CONTROL (DSC). A PART REPLACEMENT AUTHORIZATION MUST BE OBTAINED BY SUBMITTING A TC CASE IN PUMA BEFORE ANY OF THE FOLLOWING DSC COMPONENTS ARE REPLACED UNDER WARRANTY FOR THE VEHICLES ... Read More »
BMW: SERVICE ENGINE LAMP IS ILLUMINATED. DME FC 2A15 MINOR LEAK AND 2A16 SUPERFINE LEAK IN EVAPORATION SYSTEM. TANK VENTILATION CORRUGATED HOSE MAY CONTACT THE LOW SIDE AIR CONDITIONING PRESSURE LINE ALUMINUM FERREL. Read More »
N54 RATTLE NOISE FROM TURBOCHARGER AREA. MODELS E90, E92 AND E93 (3 SERIES) 335I AND 335XI; E60 AND E61 (5 SERIES) 535I AND 535XI, ALL WITH N54 ENGINE FROM THE START OF PRODUCTION TO JANUARY 17, 2008 PRODUCTION. Read More »
N52 EDK THROTTLE JAMMING FAULTS 2D09, 2CED AND 2CEC. MODEL E90 AND E91 (3 SERIES) AND E60 AND E61 (5 SERIES), ALL MODELS UP TO 11/2005 WITH N52 ENGINE. *PE Read More »
N54 RATTLE NOISE FROM TURBOCHARGER AREA. MODELS E90, E92 AND E93 (3 SERIES) 335I AND 335XI; E60 AND E61 (5 SERIES) 535I AND 535XI, ALL WITH N54 ENGINE FROM THE START OF PRODUCTION TO JANUARY 17, 2008 PRODUCTION. Read More »
ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER
N54 RATTLE NOISE FROM TURBOCHARGER AREA. MODELS E90, E92 AND E93 (3 SERIES) 335I AND 335XI; E60 AND E61 (5 SERIES) 535I AND 535XI, ALL WITH N54 ENGINE FROM THE START OF PRODUCTION TO JANUARY 17, 2008 PRODUCTION. Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS
BMW: SERVICE ENGINE LAMP IS ILLUMINATED. DME FC 2A15 MINOR LEAK AND 2A16 SUPERFINE LEAK IN EVAPORATION SYSTEM. TANK VENTILATION CORRUGATED HOSE MAY CONTACT THE LOW SIDE AIR CONDITIONING PRESSURE LINE ALUMINUM FERREL. Read More »
BMW: FUEL LEVEL SENSOR REPAIR PROCEDURE. THE CASE WHERE IT IS NECESSARY TO REPLACE THE RIGHT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING DOES NOT NEED TO BE REPLACED. NO MODEL YEARS LISTED. Read More »
BMW: FUEL LEVEL SENSOR REPAIR PROCEDURE. THE CASE WHERE IT IS NECESSARY TO REPLACE THE RIGHT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING DOES NOT NEED TO BE REPLACED. NO MODEL YEARS LISTED. Read More »
BMW VEHICLES: ENGINE CRANKS BUT DOES NOT START; FUEL LEVEL GAUGE DISPLAYS A SUFFICIENT AMOUNT OF FUEL, ALTHOUGH THE FUEL TANK IS EMPTY; FAULT CODE 2A1C (FUEL LEVEL PLAUSIBILITY) IS STORED IN MSV80. Read More »
BMW: FUEL LEVEL SENSOR REPAIR PROCEDURE. THE CASE WHERE IT IS NECESSARY TO REPLACE THE RIGHT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING DOES NOT NEED TO BE REPLACED. NO MODEL YEARS LISTED. Read More »
BMW: DSC WARNING LIGHT IS ON. THE WARNING LAMPS FOR DSC, ABS AND BRAKE WARNING ILLUMINATED. THERE MAY ALSO BE A WARNING IN THE CONTROL DISPLAY FOR CHASSIS CONTROL SYSTEM FAILURE. *JS Read More »
BMW: THE HIGH-VOLTAGE (HV) BATTERY CELLS COULD BE DAMAGED IF THE VEHICLE IS PREVENTED FROM ENTERING SLEEP MODE FOR AN EXTENDED PERIOD OF TIME. UPDATED 03/11/2013 *JS Read More »
VOLUNTARY EMISSIONS RECALL 00E-AO1 - FAULT ACCESS / O2 READINESS CODES. BMW HAS DETERMINED THAT DUE TO AN ENGINE CONTROL MODULE SOFTWARE ERROR, A COMMUNICATION CONFLICT EXISTS BETWEEN THE ENGINE CONTROL MODULE AND THE TRANSMISSION ... Read More »
VOLUNTARY EMISSIONS RECALL 00E-AO1 - FAULT ACCESS / O2 READINESS CODES. BMW HAS DETERMINED THAT DUE TO AN ENGINE CONTROL MODULE SOFTWARE ERROR, A COMMUNICATION CONFLICT EXISTS BETWEEN THE ENGINE CONTROL MODULE AND THE TRANSMISSION ... Read More »
BMW: A SOFTWARE PROBLEM IS CAUSING ONE OR BOTH OF THE SEAT BELT ASSISTANTS TO NOT EXTEND FULLY OR MAY NOT EXTEND AT ALL. THE POSITION AT WHICH THE ASSISTANT COMES TO REST VARIES. E92. *RM Read More »
REAR BULB FAILURE. MODEL E92 (3 SERIES COUPE) VEHICLES PRODUCED UP TO JANUARY 21, 2008 ARE AFFECTED. THE BULB OUT WARNING SHOWS IN THE INSTRUMENT CLUSTER. *PE Read More »
BMW SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THE AIRBAG WARNING LAMP (AWL) IS ILLUMINATED, TOGETHER WITH THE PASSENGER AIRBAG STATUS LAMP (POL). THE PROBLEM MAY BE INTERMITTENT. MICROCRACKS IN THE OC3 SEAT MAT. Read More »
SUBJECT REGARDING MRS 3 SATELLITE SENSORS REPLACEMENT FOR SIDE AIRBAG ON SEDANS MANUFACTURED FROM 09/99 UP TO 11/99 AND COUPES MANUFACTURED UP TO 11/99. *TT Read More »
BMW: A SOFTWARE PROBLEM IS CAUSING ONE OR BOTH OF THE SEAT BELT ASSISTANTS TO NOT EXTEND FULLY OR MAY NOT EXTEND AT ALL. THE POSITION AT WHICH THE ASSISTANT COMES TO REST VARIES. E92. *RM Read More »
BMW VEHICLE: FRONT SAFETY BELT DOES NOT RETRACT SMOOTHLY OR JAMS. THE UPPER PART OF THE DRIVER'S OR PASSENGER'S FRONT SAFETY BELT DOES NOT ROLL UP FULLY OR ROLLS UP SLOWLY. Read More »
BMW VEHICLE: FRONT SAFETY BELT DOES NOT RETRACT SMOOTHLY OR JAMS. THE UPPER PART OF THE DRIVER'S OR PASSENGER'S FRONT SAFETY BELT DOES NOT ROLL UP FULLY OR ROLLS UP SLOWLY. Read More »
BMW VEHICLES: REAR AXLE CARRIER (SUB FRAME) SUPPORT PROPOSED CLASS ACTION SETTLEMENT. UNDER CERTAIN CIRCUMSTANCES, A FRACTURE IN THE STEEL BODY STRUCTURE COULD FORM IN THE AREA AROUND ONE OF THE REAR AXLE CARRIER MOUNTING POINTS. Read More »
BMW VEHICLES: REAR AXLE CARRIER (SUB FRAME) SUPPORT PROPOSED CLASS ACTION SETTLEMENT. UNDER CERTAIN CIRCUMSTANCES, A FRACTURE IN THE STEEL BODY STRUCTURE COULD FORM IN THE AREA AROUND ONE OF THE REAR AXLE CARRIER MOUNTING POINTS. Read More »
BMW: SEAT FRAME DESIGN CHANGED FOR 392 (3 SERIES COUPE) PRODUCED UP TO MAY 2007. ON EARLY PRODUCTION E92S, THE SOCKET WHICH SECURES THE SEAT BACKREST RELEASE CABLE TO THE RELEASE MECHANISM COULD PULL FREE FROM THE RELEASE MECHANISM. Read More »
